Abstract:In this work, carrier-phase direct numerical simulation (CP-DNS) is conducted for a pulverized coal flame in a temporally evolving turbulent jet with flue gas recirculation (FGR). Detailed gas phase kinetics are considered and heavy hydrocarbon molecules up to C20 are included to accurately represent tars in the volatile matter. The structure of the pulverized coal flame is analyzed with different flamelet models considering two mixing scenarios, namely the mixing of recirculated flue gases with the other fuel or oxidizer streams. In the first model approach, the mixing of recirculated flue gases with the gaseous fuels released from the coal particle is characterized with a fuel-split-based flamelet (FLT-FS) model. In the second approach, the mixing of flue gases with the transport air is described with an oxidizer-split-based flamelet (FLT-OS) model. In total, five trajectory variables are introduced in the flamelet table to represent the pulverized coal combustion states with FGR. The suitability of the flamelet models is evaluated through an a priori analysis for both the fully ignited state, as well as (more challenging) the igniting states. Comparisons show that both the FLT-FS model and the FLT-OS model perform well in predicting the thermo-chemical quantities for the fully ignited state. The FLT-OS model performs slightly better than the FLT-FS model in predicting the gas temperature and specific species mass fractions. This is due to the fact that the partial oxidization of the gaseous fuels by the hot flue gases outside the mixing layers cannot be reproduced by the FLT-FS model. While the state at the beginning of ignition can still be accurately predicted by the FLT-OS model, discrepancies can be observed for the tar species C20H10 and the intermediate species CO at a later stage when many particles ignite and the reason for this is explained. Further analysis in the flamelet solution spaces shows that the gaseous fuels are ignited on the fuel-lean side. The time evolution of the gas temperature from the beginning of ignition to the fully ignited state can be overall characterized by both flamelet models.

Impact of P-1 radiation model on simulated free jet flame characteristics of gaseous fuels: CFD with PDF approach

Large Eddy Simulation/dynamic Thickened Flame Modeling of a High Karlovitz Number Turbulent Premixed Jet Flame

Performance assessment of flamelet models in flame-resolved LES of a high Karlovitz methane/air stratified premixed jet flame

The effect of thermal radiation using different models on methane–air flames combustion modelling using CFD

Flame Structure Analysis and Flamelet Modeling of Turbulent Pulverized Solid Fuel Combustion with Flue Gas Recirculation

Flame Characterisation of Gas-Assisted Pulverised Coal Combustion Using FPV-LES

Effects of Radiation on the Uncertainty of Flame Speed Determination Using Spherically Propagating Flames with CO/CO2/H2O Dilutions at Elevated Pressures

Multi-dimensional and Transient Effects on Flamelet Modeling for Turbulent Pulverized Coal Combustion

A Transported Probability Density Function/photon Monte Carlo Method for High-Temperature Oxy–natural Gas Combustion with Spectral Gas and Wall Radiation

Flame Radiation Distribution from Fires

Numerical Study of Methane/air Jet Flame in Vitiated Co-Flow Using Tabulated Detailed Chemistry

Thermal radiation distribution of low-momentum jet diffusion flame under the effect of cross airflow

Effect of Ammonia Addition to Hydrocarbon Fuels on Thermal Radiation of Turbulent Diffusion Jet Flame

Studies of Radiation Absorption on Flame Speed and Flammability Limit of CO2 Diluted Methane Flames at Elevated Pressures

Impacts of longitudinal air velocity and fuel flow rate on flame radiative fraction in tunnel

The Effects of Fuel Sooting Tendency and the Flow on Flame Radiation in Luminous Turbulent Jet Flames

Thermal Radiation from Vertical Turbulent Jet Flame: Line Source Model

Experimental investigation on flame spread over jet fuel with influence of external heat radiation

Numerical Investigation of a High Momentum Jet Flame at Elevated Pressure: A Quantitative Validation with Detailed Experimental Data

Impact of Flue Gas Radiative Properties and Burner Geometry in Furnace Simulations

Numerical Simulations of Heat Loss Effect on Premixed Jet Flame Using Flamelet Generated Manifold Combustion Model