Efficient removal of norfloxacin from water using batch airlift-electrocoagulation reactor: optimization and mechanisms analysis

Xuege Gu,Junfeng Li,Xueting Feng,Wenying Qu,Wenhuai Wang,Jiankang Wang

DOI: https://doi.org/10.1039/d3ra00471f

IF: 4.036

2023-01-01

RSC Advances

Abstract:A novel airlift reactor combined with electrocoagulation for efficient removal of norfloxacin from water.

chemistry, multidisciplinary

What problem does this paper attempt to address?

Reactive electrochemical ceramic membrane filtration system for efficient treatment of enrofloxacin from wastewater: Mechanisms and applications

Huajun Feng,Ling Ye,Yijing Xia,Jingsong Dai,Xiangjuan Ma,Fengtao Chen,Zhiwei Wang

DOI: https://doi.org/10.1016/j.cej.2023.145742

IF: 15.1

2023-01-01

Chemical Engineering Journal

Abstract:A novel reactive electrochemical ceramic membrane (RECM), assembled by ceramic membrane and reduced TiO2 nanotube arrays (rTNA) based PbO2 membrane anode with a Sb-SnO2 interlayer (rTNA/Sb-SnO2/PbO2), was developed in this study with the dual functions of low-pressure membrane filtration and efficient removal of antibiotics from wastewater. Compared with Ti/Sb-SnO2 and rTNA/Sb-SnO2 membrane anodes, rTNA/Sb-SnO2/ PbO2 anode exhibited higher oxygen evolution potential, larger active surface area and promising electrochemical stability, owing to the introduction of rTNA structure and PbO2 layer. The rTNA/Sb-SnO2/PbO2 RECM also achieved a higher electrochemical degradation performance than Ti/Sb-SnO2 and rTNA/Sb-SnO2 RECMs, as well as a lower energy consumption. The antibiotic enrofloxacin (ENR) removal of the rTNA/Sb-SnO2/PbO2 RECM in the flow-through mode was 5.4 times higher than that in the flow-by mode. These results were ascribed to the improved mass transfer of ENR towards anode surface and reactive oxygen species (i.e., H2O2, O2 center dot-, and center dot OH) production. According to theoretical computations and the detection results of intermediates, the degradation pathway involved the defluorination, hydroxylation, decarboxylation, and breakage of quinolone and/or piperazine rings of ENR under the attack of hydroxyl radicals in the RECM system. The findings demonstrated the application potential of the rTNA/Sb-SnO2/PbO2 RECM in removing ENR from wastewater.
Understanding and Characteristics of Coagulation Removal of Composite Pollution of Microplastic and Norfloxacin During Water Treatment

Jinsong He,Ye Zhang,Fan Ni,Dong Tian,Yanzong Zhang,Lulu Long,Yan He,Chao Chen,Jianmei Zou

DOI: https://doi.org/10.1016/j.scitotenv.2022.154826

IF: 9.8

2022-01-01

The Science of The Total Environment

Abstract:Water composite pollution is still a great challenge in the field of water treatment. Especially for microplastic (MP), as an emerging pollutant, its wide distribution in water and persistent eco-environmental influence have received great concerns in recent years. Nevertheless, the removal characteristics and mechanism of conventional coagulation on MP composite pollution is quite insufficient. In this study, the coagulation removal performance and mechanisms of MP (polyethylene, PE) and norfloxacin (NOR) was investigated by polyaluminium chloride (PAC) and anionic polyacrylamide (APAM). Compared with single system, the removal efficiency of PE was significantly improved (>99.0%) under plateau stage in composite system, while the removal efficiency of NOR was slightly decreased to around 42% regardless of the addition of APAM. The scanning electron microscopy (SEM), Fourier transform infrared spectroscopy (FTIR), zeta potential and One-way analysis of variance (ANOVA) of experimental data were used to explore the coagulation mechanisms. The results demonstrated that the removal of individual PE and NOR was mainly controlled by charge neutralization and sweep flocculation by PAC and APAM, and adsorption by formation of Al-NOR complex, respectively. Importantly, in composite system, the removal of PE was enhanced not only by the stronger charge neutralization but also the adsorption via the formation of PE-NOR-Al complex. Furthermore, the removal efficiency of PE and NOR in neutral and weak alkaline conditions was higher than that in weak acidic or strong alkaline conditions. The presence of metal ions and humic acid had obvious inhibition and promoting effects on the removal efficiency of PE and NOR. This study can provide a new perspective on fundamental understanding in characteristics and mechanisms of MP composite pollutants removed by coagulation.
Efficient adsorption and separation of norfloxacin from water by allophane aerogel microspheres

Qiyi Ma,Ning Zhao,Yanfu Wei,Shun Wang,Dong Liu,Peng Yuan

DOI: https://doi.org/10.1016/j.seppur.2023.124808

IF: 8.6

2023-08-30

Separation and Purification Technology

Abstract:Norfloxacin contamination in the water environment has garnered international attention due to the dire risks it poses to ecosystems and public health. Aerogel can be easily extracted or separated from aqueous solutions, and it can be used for norfloxacin practical wastewater treatment. In this study, allophane and β-cyclodextrin were prepared as copolymers, and sodium alginate as a cross-linking agent to prepare allophane aerogel microspheres (A-M) for the efficient separation of norfloxacin in an aqueous environment. The A-M provides a highly three-dimensional porous structure, allowing norfloxacin to effectively penetrate the aerogels and enhancing their adsorption capacity. At pH = 7, the adsorption capacity of allophane microspheres on norfloxacin was 529 mg/g, which was 429 and 209 mg/g higher than that of β-cyclodextrin and allophane, respectively. Adsorption capacity after 5 regeneration cycles was 78.5% of the initial adsorbents. Fourier transform infrared spectroscopy (FTIR) and X-ray photoelectron spectroscopy (XPS) analysis showed that the key adsorption mechanisms of A-M are surface complexation and hydrophobic interaction. Therefore, the prepared A-M materials are excellent adsorbents for the effective separation and removal of norfloxacin from the aquatic environment.

engineering, chemical
High-efficiency degradation of norfloxacin by cathodic micro-arc plasma electrolysis:Optimization of operation parameters and investigation on kinetics

Bin Wang,Chuanli Gao,Hui Li,Yifan Zhang,Xiaoyue Jin,Chi Xu,Wenbin Xue

DOI: https://doi.org/10.1016/j.seppur.2023.124036

IF: 8.6

2023-05-15

Separation and Purification Technology

Abstract:In this work, the norfloxacin antibiotic (NOR) in simulated wastewater solution was rapidly degraded by a novel cathodic micro-arc plasma electrolysis (CMPE) treatment within 20 min. The effects and kinetics of initial pH value of solution, supporting electrolyte, and applied voltage on this NOR degradation process were systematically investigated. The intermediate products are analyzed by a Liquid Chromatograph-Mass Spectrometer (LC-MS), and the possible degradation pathways in the NOR degradation process were proposed. The results obtained showed that the NOR removal efficiency increased with the increase of the initial pH value of the solution. When KCl was employed as the supporting electrolyte instead of KNO 3 and K 2 SO 4 , the removal efficiency of NOR is the highest. In addition, the removal efficiency is not significantly different at 340 V, 380 V, and 420 V, but it is more beneficial to the removal of chemical oxygen demand (COD) and the increase of average current efficiency (ACE) at 380 V. Furthermore, under the optimized operating parameters for the initial pH value of 9, supporting electrolyte of KCl, and applied voltage of 380 V, the 100 mg/L NOR solution can be completely removed within 10 min, and the energy yield and average current efficiency were 0.385 g (kW⋅h) -1 and 0.118. Further, it is found that the degradation pathways of NOR mainly include the piperazine ring opening, hydroxylation, defluorination, and quinoline ring transformation. Overall, this study provides a high-efficiency and novel technique for the NOR degradation treatment.

engineering, chemical
Degradation of norfloxacin in aqueous solution using hydrodynamic cavitation: Optimization of geometric and operation parameters and investigations on mechanism

Ludong Yi,Boqian Li,Yanan Sun,Shu Li,Qianqian Qi,Jun Qin,Haosheng Sun,Xinruo Wang,Jun Wang,Dawei Fang

DOI: https://doi.org/10.1016/j.seppur.2020.118166

IF: 8.6

2021-03-01

Separation and Purification Technology

Abstract:Hydrodynamic cavitation (HC), as one of novel advanced oxidation processes (AOPs), is considered to be a promising technology for wastewater treatment because it has the advantages of wide application range, simple operation and no secondary pollution. In this work, the effects of different orifice plate geometric parameters such as orifice shape (circle, square and triangle), orifice plate thickness (2.00 - 6.00 mm), orifice number (n = 1 - 5) and orifice divergence angle (α = 0° and ±45°) on the norfloxacin degradation by using HC were studied to obtain a strong HC effect. And the effects of various operating parameters such as solution pH (3.0 - 9.0) and initial norfloxacin concentrations (5.0 - 15 mg/L) on the norfloxacin degradation by using HC were discussed. The trapping experiments of free radicals (•OH and •O2-) were also carried out for exploring the mechanism of norfloxacin degradation. In addition, adopting the designed orifice plates with optimized geometric parameters, the norfloxacin degradation efficiencies by using HC combined with some added oxidants (H2O2, K2S2O8 and NaClO) were investigated. The Total Organic Carbon (TOC) analysis at the optimum conditions was also performed to identify the mineralization extent. The intermediate products during the norfloxacin degradation were detected by using Liquid Chromatograph-Mass Spectrometer (LC-MS). The experimental results indicated that, under 5.0 bar inlet pressure for 10 mg/L initial norfloxacin concentration at 40 °C operating temperature in pH = 3.0 solution, the degradation ratio of norfloxacin can reach up to 84.20 % in the HC system and can reach up to 96.45 % in the HC+H2O2 system by using the orifice plate with 4.00 mm thickness, three square orifices and α = 0° orifice divergence angle. The TOC test results show that the mineralization ratio can reach 71.57 % in the HC system for 150 min successive cycling, which demonstrated that the HC can effectively mineralize norfloxacin. In addition, the LC-MS results manifested that norfloxacin moleculars can be degraded into a series of organic compounds with low molecular weight and further be oxidized into CO2, H2O and some inorganic ions during the HC process. Overall, the work has demonstrated that the HC is an effective strategy for a large-scale treatment of antibiotics wastewater.

engineering, chemical
Electrolysis-sulfate-reducing up-flow sludge bed-biological contact oxidation reactor for Norfloxacin removal from wastewater with high sulfate content

Jinlong Gao,Yifan Chen,Jiwei Li,Yalin Yu,Jun Wang,Tiantian Pang,Yuting Qi,Jingge Shang,Qianjiahua Liao

DOI: https://doi.org/10.1016/j.envres.2020.110455

IF: 8.3

2021-05-01

Environmental Research

Abstract:This study investigated the treatment of 100-mg/L Norfloxacin (NOR) wastewater containing high concentrations of sulfate through a combination of electrolysis, sulfate-reducing up-flow sludge bed (SRUSB), and biological contact oxidation reactor (BCOR) treatments. Results revealed that after 62 h, the reaction system had processed over 97% of the NOR. Additionally, electrolysis with sodium sulfate as the electrolyte transformed 87.8% of the NOR but only 33.5% of the total organic carbon (TOC). In the SRUSB, the TOC and SO42- contents were simultaneously reduced by 87.4% and 95.6%, respectively, providing a stable environment to the BCOR. In the BCOR, 36.3% and 85.9% of the NOR and TOC were degraded. High-performance liquid chromatography-tandem mass spectrometry analysis identified three possible degradation pathways under the attack of -OH during electrolysis, including defluorination, piperazinyl ring transformation, and quinolone ring transformation. Furthermore, the Illumina HiSeq sequencing results demonstrated that the sulfate-reducing bacteria (represented by Desulfobacter and Desulfobulbus) in the SRUSB and the sulfate-oxidizing bacteria (mainly consisting of Gammaproteobacteria and Alphaproteobacteria) in the BCOR played important roles in carbon chain oxidation and benzene ring opening and thoroughly degraded the electrolysis products. Thus, this method effectively overcomes the incomplete degradation and low removal efficiency issues associated with single electrolysis or biological methods in traditional processes.

environmental sciences,public, environmental & occupational health
Enhanced H2O2 formation and norfloxacin removal by electro-Fenton process using a surface-reconstructed graphite felt cathode: New insight into synergistic mechanism of defective active sites

Hongkai Guo,Chengwen Zhao,Hu Xu,Honglin Hao,Ziyuan Yang,Na Li,Weijun Xu

DOI: https://doi.org/10.1016/j.envres.2023.115221

IF: 8.3

2023-03-01

Environmental Research

Abstract:The efficient catalytic activity and strong durability possibility of carbon-based three-dimensional fiber materials remains an important challenge in Electro-Fenton advanced oxidation technology. Graphite felt (GF) is a promising electrode material for 2-electron oxygen reduction reaction but with higher catalytic inertia. Anodizing modification of GF has been proved to enhance it electro-catalytic property, but the disadvantages of excessive or insufficient oxidation of GF need further improved. Herein, the surface reconstituted graphite felt by anodizing and HNO3 ultrasonic integrated treatment was used as cathode to degrade norfloxacin (NOR) and the substantial role of different modification processes was essentially investigated. Compared with the single modification process, the synergistic interaction between these two methods can generate more defective active sites (DASs) on GF surface and greatly improved 2-electron ORR activity. The H2O2 can be further co-activated by Fe2+ and DASs into •OH(ads and free) and •O2- to efficiently degrade NOR. The treated GF with 20 min anodizing and 1 h HNO3 ultrasound had the highest electrocatalytic activity in a wide electric potential (-0.4 V to -0.8 V) and pH range (3-9) in system and the efficient removal rate of NOR was basically maintained after 5 cycles. Under optimal reaction conditions, 50 mg L-1 NOR achieved 93% degradation and almost 63% of NOR was completely mineralized within 120 min. The possible NOR degradation pathways and ecotoxicity of intermediates were analyzed by LC-MS and T.E.S.T. theoretical calculation. This paper provided the underlying insights into designing a high-efficiency carbon-based cathode materials for commercial antibiotic wastewater treatment.

environmental sciences,public, environmental & occupational health
Unraveling the highly efficient synergy of adsorption and degradation for norfloxacin elimination by Mo/Fe anchored carbon fiber aerogel via peroxydisulfate activation

Wei Liu,Yingbo Dong,Dongsheng Yang,Conghui Zhang,Liping Zhang,Yanrong Lu,Qi Jin,Zhirui Liu,Junfei Liu,Hai Lin

DOI: https://doi.org/10.1016/j.cej.2023.142667

IF: 15.1

2023-04-06

Chemical Engineering Journal

Abstract:In peroxydisulfate (PDS) advanced oxidation processes (AOPs), the mass transfer of reactive oxygen species (ROS) and sustainability of catalysts are the rate-limiting steps for pollutant elimination. Recently, norfloxacin (NOR) has received growing concern due to its ecotoxicological potential. Here, a novel Mo 2 C-Fe 3 C anchored in-plane biomass carbon fiber aerogel (Mo/Fe-KFA) was constructed to firstly enrich NOR on a nano-surface and immediately in situ degraded from the interface via PDS activation. Mo/Fe-KFA-PDS system achieves over 99% removal of NOR within 5 min in a wide range of pH 3–11 due to NOR fast enriched on Mo/Fe interface and enhancing the mass transfer of ROS within its lifetime. The electron transport between Mo and Fe via the graphitic carbon chain (Mo-C-Fe) in Mo/Fe-KFA accelerates the Fe 3+ /Fe 2+ cycle and largely prolongs the durability of the catalyst which the removal of NOR is over 85% after continuous operation for 96 h with a retention time of 0.5–1 s. This means that 1 g of Mo/Fe-KFA can purify ∼43.2L of NOR wastewater driven by gravity and maintain ∼85% activity. The detailed highly removal kinetics of NOR and durability of catalyst were systematically investigated associated with DFT calculations. Finally, degradation intermediates of NOR were identified by UPLC-MS and the corresponding toxicity potential was evaluated. This work develops a sustainable, high-efficiency and economical strategy for purification of water organic contaminates.

engineering, chemical, environmental
Constructing of Fe-Cu bimetallic MOFs derived electro-Fenton cathode for efficient norfloxacin removal

Yixin Du,Zhenpeng Li,Rui Feng,Qing Liu,Yanming Yang,Meng Sun,Yanxia Zhao,Tao Yan,Liangguo Yan

DOI: https://doi.org/10.1016/j.jece.2024.112324

IF: 7.7

2024-04-01

Journal of Environmental Chemical Engineering

Abstract:Heterogeneous electro-Fenton (H-EF) is a promising technology for the removal of persistent organic pollutants. It is urgently necessary to exploit effective cathode. In this study, the development of a stable FeCu-N doped C is modified in carbon felt (FC12-NC@CF) as a cathode for norfloxacin removal in heterogeneous electro-Fenton. FC12-NC, with a typical rod-like morphology derived from Fe/Cu bimetal MOF, is synthesized via carbonization in N2. The synergistic effect of Fe-Cu accelerated electron transfers and remarkably enhanced the oxygen reduction reaction (ORR) toward the two-electron process (n = 2.13). At a wide pH range (pH 3–9), norfloxacin (NOR) is removed efficiently within 90 min, while the modified cathode has excellent stability and catalytic capacity after six recycle runs. A possible mechanism of NOR removal was suggested for this H-EF process, confirming that hydroxyl radicals were the main active species. Based on the experimental results, the intermediates of NOR and the possible degradation pathways were proposed. According to the Toxicity Estimation Software Tool (T.E.S.T.), the toxicity of NOR was predicted to be partly minimized after the H-EF reaction. The prepared cathode was cost-effective, demonstrating a good application prospect in wastewater treatment.

engineering, chemical, environmental
Magnetic Fe/carbon/sodium alginate hydrogels for efficient degradation of norfloxacin in simulated wastewater

Da Liu,Wenyi Gu,Wenqi Zhou,Ying Xu,Wenjia He,Lizheng Liu,Liang Zhou,Juying Lei,Jinlong Zhang,Yongdi Liu

DOI: https://doi.org/10.1016/j.jclepro.2022.133239

IF: 11.1

2022-10-01

Journal of Cleaner Production

Abstract:The activation of hydrogen peroxide (H2O2) by Fe/carbon composites has been widely used for the removal of antibiotics. However, the secondary pollution of iron ions limits the application of Fe2+/H2O2 system. In this work, three kinds of hydrogel materials combining metal-organic framework (MOF)-derived magnetic Fe/porous carbon (MagFePC) with sodium alginate (SA), polyacrylic acid (PAA) and agarose (AG) were prepared by different methods for removal of norfloxacin (NOR) antibiotics in simulated wastewater. After comparison, MagFePC/SA hydrogels synthesized by a titration forming method were found to have the advantages of good toughness, abundant pores and best Fenton activity. MagFePC/SA can effectively activate H2O2 to remove NOR under neutral conditions, and there was almost no leaching of iron ions, causing no secondary pollution to the environment. The effects of pH, ionic strength and surfactants on the degradation performance for NOR were studied. Mechanism study revealed that ·O2− and 1O2 were the main active species for the degradation of NOR, and the materials still had good stability and reusability after repeated cycles. More important, we built a simple automated unit for wastewater treatment under laboratory conditions that can completely degrade a 5 mg/L NOR solution at a flow rate of 2 mL/min. Current works showed that MagFePC/SA had the advantages of simple synthesis, outstanding degradability, excellent stability and eco-friendly reaction, which was a wastewater treatment material with good prospect for industrial application.

environmental sciences,green & sustainable science & technology,engineering, environmental
Application of the membrane bioreactor process in upgrading a norfloxacin pharmaceutical wastewater treatment system

Jianlei Gao,Zhihao Yue,Yixin Yan,Yongfeng Zhang,Xianglong Guo,Wanqiu Zhu

DOI: https://doi.org/10.5004/dwt.2022.28130

IF: 1.1

2022-01-01

Desalination and Water Treatment

Abstract:A norfloxacin pharmaceutical factory in Henan Province, China, uses a metal-based electrochemical redox pretreatment step followed by anaerobic hydrolytic acidification and the anoxic/oxic (A/O) process for biological treatment. The effluent chemical oxygen demand (COD) does not meet the limit of 120 mg L–1 in the national “Discharge Standards of Water Pollutants for Pharmaceutical Industry Chemical Synthesis Products Category” (GB21904-2008, in Chinese) and therefore needs to be improved. In this study, influent from the hydrolytic acidification tank and a built-in membrane bioreactor are used to determine the effects of operating parameters such as the sludge load (Ns), sludge concentration (mixed liquor suspended solids, MLSS), dissolved oxygen (DO) and sludge age (sludge retention time, SRT) on the effluent COD and NH3–N. The results show that the optimal operating ranges of each parameter are as follows: MLSS, 8,000~12,000 mg L–1; Ns, 0.14~0.33 kg COD/kg MLSS d; DO, 2.0~3.0 mg L–1; and SRT, 15~50 d. The actual operational results after optimization of each parameter show that effluent COD is between 60 and 130 mg L–1, effluent NH3–N is less than 5 mg L–1, and 90% and 100% of the effluent COD and NH3–N measurements, respectively, meet the discharge standard. Through kinetic analysis of the reactor, the kinetic parameters of sludge degradation are found to be V max = 0.32 d–1 and K s = 270.36 mg L–1.

engineering, chemical,water resources
Aqueous norfloxacin removal by novel biochar adsorbent prepared through ethanol-combined ball milling

Shixin Yang,Chuangye Yang,Xin Hu,Zhuhong Ding,Ranran Zhou,Hengchen Wei,Lei Wang

DOI: https://doi.org/10.1080/26395940.2024.2311675

2024-02-06

Environmental Pollutants and Bioavailability

Abstract:Ethanol combined-ball milling was used to modify corn-stover biochar. The adsorption performance and mechanisms of aqueous norfloxacin (NOR) onto the resulting biochar (C2H6O-BC) were evaluated. Ball-milling modulated its surface oxygen-containing functional groups and enhanced its specific surface area. The adsorption capacity of C2H6O-BC was 163 mg·g−1, and about 72% of the equilibrium adsorption capacity could be reached within 60 min. The electrostatic interaction was not the dominant mechanism when initial pH was lower than 8.00. The antagonistic effect of Cu(II) on NOR adsorption was observed. The fixed-bed column adsorption showed its potential to remove NOR and Cu(II) spontaneously. Sequential two-stage batch reaction experiment showed that it was a fast and efficient technology to remove NOR using C2H6O-BC. The adsorption mechanisms were suggested as π-π interactions, H-bonding and pore-filling. In summary, ethanol-combined ball milling in this study provided an efficient adsorbent for NOR.

environmental sciences,toxicology,biochemistry & molecular biology
Deep oxidation of norfloxacin by the electrochemical enhanced heterogeneous catalytic oxidation: The role of electric field and reaction optimization

Lili Liu,Rui Zhan,Yunxiao Zhang,Meng Zhang,Zhiping Wang,Jianan Li

DOI: https://doi.org/10.1016/j.chemosphere.2022.134894

IF: 8.8

2022-09-01

Chemosphere

Abstract:In this study, electrochemical (ECG-G: graphite anode and cathode, ECI-G: iron anode and graphite cathode) enhanced heterogeneous activation of peroxymonosulfate (PMS) by CoFe2O4 nanoparticles for the degradation of norfloxacin (NOR) in water was investigated. Although a higher NOR removal efficiency was achieved in ECI-G/CoFe2O4/PMS system, the generation of Fe3+ had resulted in the deposition of iron mud and affect the recovery of CoFe2O4. Under the optimum reaction conditions of CoFe2O4/PMS system, the final removal efficiency of NOR did not show significant difference in ECG-G/CoFe2O4/PMS system (96.0%) and CoFe2O4/PMS system (95.5%), but the value of apparent rate constant significantly increased in ECG-G/CoFe2O4/PMS system (0.21 min−1) compared with CoFe2O4/PMS system (0.11 min−1). Similar NOR degradation pathways were obtained in these two systems, and the TOC removal efficiency in ECG-G/CoFe2O4/PMS system (28.8%) is almost as low as CoFe2O4/PMS system (26.0%). Therefore, it can be proposed that the applied electric field through active electrodes can accelerate the reaction of heterogeneous catalytic oxidation, but does not participate much in NOR degradation. However, the TOC removal efficiency (30 min) could be reached 68.7% as the mass ratio of PMS to CoFe2O4 increased to 5:1 (250 mg L−1: 50 mg L−1). The ECG-G/CoFe2O4/PMS system is a promising low-cost technique for efficient mineralization of antibiotics in wastewater.

environmental sciences
Highly synergetic effect for norfloxacin degradation by coupling underwater bubble plasma formation with a Fe (III)–S (IV) system

Sitao Wang,Zhijie Liu,Bolun Pang,Yuting Gao,Santu Luo,Qiaosong Li,Hailan Chen,Michael G Kong

DOI: https://doi.org/10.1016/j.cej.2022.134570

IF: 15.1

2022-04-01

Chemical Engineering Journal

Abstract:Antibiotics are widely used to treat or prevent infectious diseases in human and veterinary medicine. Excessive residues in the aquatic environment lead to increasingly prominent antibiotic pollution; therefore, it is urgent to develop sustainable strategies for rapidly degrading antibiotics. In this study, a highly synergetic effect for norfloxacin (NOR) remediation is achieved by coupling underwater bubble plasma formation with a Fe (III)–S (IV) system due to the efficient utilization of reactive species in chain reactions. The degradation rate using synergetic approach can reach 76.4% within 50 min discharge, and further increases significantly to 94.4% after 5 h post-discharge. The effects of pulsed peak voltage and Fe (III)/S (IV) dosage on NOR removal are characterized. The existence of hydroxyl radicals (•OH) and sulfate radicals (SO4 •−) are proved by electron spin resonance spectrometer (ESR) during degradation. Furthermore, radical scavenger experiments demonstrate that •OH and SO4 •− play a crucial role in degradation. Underwater bubble plasma provides the oxic and acidic liquid environment for the Fe (III)–S (IV) system to accelerate the self-perpetuating chain reactions. These reactions not only introduce SO4 •− and generate more •OH during plasma-on, but also induce their regeneration and further prolong the degradation process during plasma-off through plasma-generated effects. Finally, the degradation intermediates of NOR are identified, and a possible degradation pathway is proposed. The possible contribution weight of each approach on the degradation rate is speculated. These new findings offer promising applications for developing a technology with real potential for the treatment of organic compounds in industrial wastewater treatment.
Preparation-Height-Specific Surface Area of Flower-like ZnO for Norfloxacin Removal in Dialysis Wastewater

Shui-Shu Hsiao,Thi-Minh-Phuong Nguyen,Li-Pang Wang,Gui-Bing Hong,Yu-Chen Cheng,Pei-Hua Wang,Cong-Chinh Duong,Chia-Jui Yang

DOI: https://doi.org/10.3390/catal13060979

IF: 3.9

2023-06-07

Catalysts

Abstract:According to statistics, the number of patients with kidney dialysis is increasing every year, especially in Taiwan. The high content of antibiotics in kidney dialysis wastewater can create an environmental burden if not properly treated. Therefore, in this study, a new design for a flower-like ZnO catalyst that can effectively treat norfloxacin (NF) in dialysis wastewater is presented and its NF treatment efficiency is investigated under different operating parameters (including different dosages, pH, ambient temperatures, and pollutant concentrations). Scanning electron microscope results indicate that the ZnO sample consists of flower-like nanostructures with diameters of about 4.97 μm. The surface area, pore volume, and pore size of the flower-like ZnO were estimated to be 46.45 m2g−1, 0.132 cm3g−1, and 19.50 nm, respectively. The total removal efficiency increased with the increase in the initial pH value of NF, when the initial pH value of NF increased from 3.5 (38.1%) to 7.5 (82.5%). However, the total removal efficiency decreased with an increase in the initial pH value of NF, when the initial pH value of NF increased from 9.5 (79.5%) to 11.5 (32.9%). The second-order kinetic simulation results show that the linear relationship is better than that of the first-order kinetic, and the Rc2 values are all above 0.9.

chemistry, physical
Application of a novel polymer cross-linked with magnetite for efficient norfloxacin adsorption at a wide pH range

Xinyu Zheng,Cong Shen,Ziran Deng,Chenqi Pan,Yongfu Guo

DOI: https://doi.org/10.1016/j.envres.2024.118471

IF: 8.3

2024-05-01

Environmental Research

Abstract:Nowadays, NOR-containing wastewater has placed huge pressure on global ecology. In this study, a chemically-modified chitosan-based polymer was cross-linked with magnetite to prepare a novel magnetic composite adsorbent named Fe3O4/CS-P(AM-SSS) for norfloxacin (NOR) removal. The preparation conditions were optimized by single factor experiments and response surface methodology. A series of characterization analyses were carried out on the morphology, structure, and properties of Fe3O4/CS-P(AM-SSS), verifying that Fe3O4/CS-P(AM-SSS) was successfully prepared. Batch adsorption experiments showed that NOR was efficiently removed by Fe3O4/CS-P(AM-SSS), with a broad pH applicability of 3-10, short adsorption equilibrium time of 60 min, maximum adsorption capacity of 268.79 mg/g, and high regeneration rate of 86% after eight adsorption-desorption cycles. Due to the three-dimensional network structure and abundant functional groups provided by modified chitosan polymer, the superior adsorption capability of Fe3O4/CS-P(AM-SSS) was achieved through electrostatic interaction, π-π stacking, hydrophobic interaction, and hydrogen bonding. Adsorption process was exothermic and well fitted by the pseudo-second-order kinetic model and the Langmuir isothermal model. The presence of cations had a slight inhibitory effect on NOR adsorption, while humic acid nearly had no effect. In model swine wastewater, 90.3% NOR was removed by Fe3O4/CS-P(AM-SSS). Therefore, with these superior characteristics, Fe3O4/CS-P(AM-SSS) was expected to be an ideal material for treating NOR-containing wastewater in the future.

environmental sciences,public, environmental & occupational health
Efficient removal of ciprofloxacin and ofloxacin from aqueous solutions using a novel nano-scale adsorbent: Modeling, optimization, and characterization

Omid Farzinmanesh,Mina Hosseini Sabzevari,Mohammad R Asghariganjeh,Mohammad R. Asghariganjeh

DOI: https://doi.org/10.1016/j.chemosphere.2024.141640

IF: 8.8

2024-03-21

Chemosphere

Abstract:In the fascinating realm of water purification, our study unveils the remarkable potential of a cutting-edge nano-scale adsorbent—combining graphene oxide (GO), chitosan (CS), and polydopamine (PDA)—in efficiently remove ciprofloxacin (CPF) and ofloxacin (OFL) from aqueous solutions. Our exploration delves deep into the adsorbent's character, utilizing a range of analytical techniques including SEM, RAMAN, FTIR, TGA, BET, XRD, and Zeta potential analyses provided insights into the adsorbent's properties. Modeling the adsorption process with Response Surface Methodology (RSM), Artificial Neural Network (ANN) and General Regression Neural Network (GRNN) indicated excellent predictions by GRNN, with RMSE = 0.0200 and 0.0166, MAE = 0.0082 and 0.0092, as well as AAD = 0.0002 and 0.0006, highlighting its modeling power. Optimization using genetic algorithm (GA) revealed maximum CPF removal efficiency of approximately 95.20% under pH = 6.3, sonication time = 9.0 min, adsorbent dosage = 2.10 g L− 1 , temperature = 45 °C and initial CPF concentration = 90.0 mg L− 1 . Similarly, OFL removal reached about 95.50% under pH = 6.30, sonication time = 8.0 min, adsorbent dosage = 2.0 g L− 1 , temperature = 45 °C and OFL concentration = 115.0 mg L− 1 . RSM optimization closely aligned with GA results. Pseudo-second-order (PSO) kinetic model and Langmuir isotherm model best fitted the experimental data for both antibiotics. Thermodynamic analysis indicated a favorable and spontaneous adsorption process for CPF and OFL. The study concludes that the proposed adsorbents show effectiveness in removing CPF and OFL at lower doses and shorter sonication times compared to various reported adsorbents.

environmental sciences
Tuning the heterostructure improves the catalytic activity of recyclable nanozymes for efficient absorption and degradation of norfloxacin-contaminated water

Yanning Zheng,Dankui Liao,Bimei Xie,Jinlei Sun,Jianhua Sun,Zhangfa Tong,Guangzhi Zhou

DOI: https://doi.org/10.1016/j.seppur.2024.126576

IF: 8.6

2024-01-31

Separation and Purification Technology

Abstract:Effective removal of antibiotic residues from water is crucial for maintaining balance and cleanliness in the ecological environment. To achieve this, we conducted a study on the development of a highly efficient catalyst from the in-situ growth of Fe 3 O 4 nanoparticles on nitrogen-doped hollow porous carbon spheres (Fe 3 O 4 @N-HollCS). We controlled the in-situ growth time to optimize its performance. Material characterization and theoretical calculations revealed that the improved catalytic performance of Fe 3 O 4 @N-HollCS is due to electron transfer from the graphitic-N in N-HollCS to the catalytic interface of Fe 3 O 4 nanoparticles. Fe 3 O 4 @N-HollCS, with an ordered mesoporous structure and high specific surface area, had remarkable adsorption capacity for NOR antibiotics, with an enrichment efficiency exceeding 60% within 10 min. Moreover, the Fe 3 O 4 @N-HollCS degraded more than 90% of fluoroquinolone antibiotics, especially norfloxacin (NOR), which was eliminated within 60 min. The Fe 3 O 4 @N-HollCS also exhibited stable catalytic recycling ability within 10 magnetic separations. Fukui function predicted the sensitive sites of NOR, and we proposed potential degradation pathways. Ecological structure activity relationship model evaluation showed that the intermediate produced by Fe 3 O 4 @N-HollCS degradation of NOR has low levels of ecotoxicity. Overall, Fe 3 O 4 @N-HollCS catalysts have great potential for antibiotic wastewater treatment.

engineering, chemical
Degradation of norfloxacin in aqueous solution by ionizing irradiation: Kinetics, pathway and biological toxicity

Xiaoying Chen,Jianlong Wang

DOI: https://doi.org/10.1016/j.cej.2020.125095

IF: 15.1

2020-01-01

Chemical Engineering Journal

Abstract:Norfloxacin (NOR) has been extensively applied worldwide to treat various infectious diseases, which is ubiquitous in the aquatic environments. In this study, ionizing irradiation was used to degrade NOR in aqueous solution. The results showed that 5-40 mg/L NOR could be degraded completely at 0.4-4 kGy. The mineralization of NOR was enhanced by 1.55-3.02 times in the presence of 10-40 mg/L H2O2 at 6 kGy. Scavenging experiments indicated that hydroxyl radical ((OH)-O-center dot) was the predominant radical species during NOR radiolytic degradation. In addition, three possible degradation steps were proposed, including defluorination, quinolone group transformation, and the opening of the piperazinyl ring. The antimicrobial activity of NOR solution against Staphylococcus aureus was eliminated by gamma irradiation, while some more toxic intermediate products were predicted during irradiation process. Ionizing irradiation could also degrade NOR effectively in real wastewater and ground water. Overall, ionizing irradiation is an efficient technology for degrading NOR, while more attention should be paid to the toxicity of the intermediate products generated during NOR radiolytic degradation.
Degradation of norfloxacin in aqueous solution by atmospheric-pressure non-thermal plasma: Mechanism and degradation pathways

Qifu Zhang,Hong Zhang,Qunxia Zhang,Qing Huang

DOI: https://doi.org/10.1016/j.chemosphere.2018.07.035

IF: 8.8

2018-11-01

Chemosphere

Abstract:Norfloxacin is a synthetic antibiotics drug which is widely used in the treatment of infectious diseases and also often carelessly released into natural environment resulting in antibiotics-contaminated wastewater. In this work, we employed atmospheric-pressure non-thermal dielectric barrier discharge (DBD) to treat norfloxacin-contaminated water and investigated the degradation efficiency and mechanism for the plasma treatments under different conditions with varied working gas atmospheres. Our results showed that the DBD efficiency for norfloxacin degradation depended on reactive oxygen/nitrogen species (RONS) produced in the plasma treatment, while the plasma-induced hydroxyl radical played a critical role in the norfloxacin degradation. For O2-DBD, except for the contribution from reactive oxygen species (ROS), ozone could also play an important role. For N2-DBD, reactive nitrogen species (RNS) could work synergistically with H2O2 to enhance the degradation effect. We also checked the plasma activated liquid (PAL) effect and analyzed the degradation products so that the degradation mechanism and pathways could be elucidated. This work may therefore provide the guidance for effective and feasible application of low-temperature plasma technology in treatment of antibiotics-contaminated wastewater.

environmental sciences

Efficient removal of norfloxacin from water using batch airlift-electrocoagulation reactor: optimization and mechanisms analysis

Reactive electrochemical ceramic membrane filtration system for efficient treatment of enrofloxacin from wastewater: Mechanisms and applications

Understanding and Characteristics of Coagulation Removal of Composite Pollution of Microplastic and Norfloxacin During Water Treatment

Efficient adsorption and separation of norfloxacin from water by allophane aerogel microspheres

High-efficiency degradation of norfloxacin by cathodic micro-arc plasma electrolysis:Optimization of operation parameters and investigation on kinetics

Degradation of norfloxacin in aqueous solution using hydrodynamic cavitation: Optimization of geometric and operation parameters and investigations on mechanism

Electrolysis-sulfate-reducing up-flow sludge bed-biological contact oxidation reactor for Norfloxacin removal from wastewater with high sulfate content

Enhanced H2O2 formation and norfloxacin removal by electro-Fenton process using a surface-reconstructed graphite felt cathode: New insight into synergistic mechanism of defective active sites

Unraveling the highly efficient synergy of adsorption and degradation for norfloxacin elimination by Mo/Fe anchored carbon fiber aerogel via peroxydisulfate activation

Constructing of Fe-Cu bimetallic MOFs derived electro-Fenton cathode for efficient norfloxacin removal

Magnetic Fe/carbon/sodium alginate hydrogels for efficient degradation of norfloxacin in simulated wastewater

Application of the membrane bioreactor process in upgrading a norfloxacin pharmaceutical wastewater treatment system

Aqueous norfloxacin removal by novel biochar adsorbent prepared through ethanol-combined ball milling

Deep oxidation of norfloxacin by the electrochemical enhanced heterogeneous catalytic oxidation: The role of electric field and reaction optimization

Highly synergetic effect for norfloxacin degradation by coupling underwater bubble plasma formation with a Fe (III)–S (IV) system

Preparation-Height-Specific Surface Area of Flower-like ZnO for Norfloxacin Removal in Dialysis Wastewater

Application of a novel polymer cross-linked with magnetite for efficient norfloxacin adsorption at a wide pH range

Efficient removal of ciprofloxacin and ofloxacin from aqueous solutions using a novel nano-scale adsorbent: Modeling, optimization, and characterization

Tuning the heterostructure improves the catalytic activity of recyclable nanozymes for efficient absorption and degradation of norfloxacin-contaminated water

Degradation of norfloxacin in aqueous solution by ionizing irradiation: Kinetics, pathway and biological toxicity

Degradation of norfloxacin in aqueous solution by atmospheric-pressure non-thermal plasma: Mechanism and degradation pathways