Abstract:Drying is the process of moisture removal which is applied to many foodstuffs including fruits and vegetables for preservation and storage purposes. Since solar energy is one type of environmentally friendly renewable energy, open-type solar dryers, natural convective type solar dryers and greenhouse type solar dryers were designed and fabricated in this study for the preservation of fruits and vegetables. A comparative study among various solar drying methods was performed to study the drying performance by maintaining the quality and texture of the dried foodstuffs. Factors such as solar radiation, ambient temperature, moisture in the air, materials used for glazing, inclination, etc., were considered during the fabrication of the solar dryer so that a better estimate of the performance of the solar dryer could be obtained. The lowest drying rate was observed when convective drying was used as an indirect mode of heating. The maximum drying rate observed in open drying was 0.088 kg/kgh, whereas in convective drying under the same conditions, it was 0.03 kg/kgh, which was almost 65% less. This in turn also resulted in the dried samples displaying a better texture and better color. The shrinkage effect on the samples was less pronounced for those samples in the convective dryer than it was for those in the open and greenhouse dryers, as the method uses indirect drying. Comparing convective and greenhouse drying, more shrinkage and a greater browning effect were observed for the open drying method. Out of three types of solar dryers, the greenhouse dryer was selected to study thermal performance because of its better drying rate. DHT11 sensors controlled through Arduino programming were employed in this study to record the temperature and moisture at various locations in the greenhouse dryer setup. The range of energy efficiency of the greenhouse solar dryer was estimated to be from around 15% to 25% on average. This might be due to a greater extent of energy losses. No significant difference was observed in the energy efficiency with respect to the samples used for drying.

Study of air movement and temperature distribution in a greenhouse used as a dryer

Modeling of coupled heat and mass transfer during drying of ebony wood using indirect natural convection solar dryer

Experimental and computational validation of thermal performance of an active greenhouse solar dryer in no-load conditions

Experimental Investigation on a Solar Assisted Heat Pump In-Store Drying System

CFD simulation of solar grain dryer

Employing a Combination of a Double-Glazed Flat Solar Collector and Sensible Heat Storage for Drying Agricultural Products

Numerical investigation of a solar greenhouse tunnel drier for drying of copra

Efficient simulation of bitter gourd drying in active solar dryer: A state-of-the-art model

Experimental Study of the Thermal Performance of a Sensitive Solar Energy Storage System on a Rock Bed (Granite) for a Drying Application

Improving the sustainability and effectiveness of photovoltaic evaporative cooling greenhouse in the Sahel

Modeling, numerical simulation and validation of a convective dryer in steady conditions: case study of tropical woods

TEMPERATURE GRADIENTS IN A SWEET COLOURED PEPPER COMMERCIAL GRENHOUSES EQUIPPED WITH SOLAR HEATING AND EVAPORATIVE COOLING SYSTEMS

A Comparative Management Analysis on the Performance of Different Solar Drying Methods for Drying Vegetables and Fruits

A medium-size greenhouse solar dryer for drying eco-friendly handmade papers: Performance analysis and drying kinetics

EXERGETIC ANALYSIS OF THE SOYBEAN DRYING PROCESS WITH SOLAR ENERGY IN HOT-HUMID CLIMATES

Solar Assisted Dehydrator for Decentralized Controlled and Homogeneous Multi-Product Drying

Comprehensive exergy analysis of dandelion root during physical pre-treatment by convective solar drying

A Preliminary Experimental and Numerical Analysis of a Novel Solar Dryer

Drying Performance of a Combined Solar Greenhouse Dryer of Sewage Sludge

Analysis of seasonal variations and their impact on the microclimate of soilless glass greenhouses: Numerical and experimental investigations

Modification and the Performance Enhancement of Solar Biomass Dryer