Abstract:Swelling and dissolution of cellulose in ionic liquids (ILs) as the pretreatment processes are key steps for the high-value conversion and utilization of cellulose. However, the molar ratio of H 2 O to ILs has a significant effect on the swelling and dissolution of cellulose, and its molecular-scale mechanism is still unclear, which limits screening out the suitable ILs and recovery of ILs from coagulation bath in the spinning process. Herein, three phosphate-based ILs were chosen to couple with water as solvents for swelling and dissolution of cellulose by combining in-situ observation and molecular dynamics (MD) simulation. The results show that the redissolution time of swollen cellulose is greatly reduced, especially [Emim]DEP-H 2 O has the best swelling and dissolution performance for cellulose due to its high β value and low viscosity. Meanwhile, when the molar ratio of IL to H 2 O was more than 1: -1, the IL-H 2 O system still has the ability to dissolve cellulose. While with the molar ratio further decreased, cellulose was no longer dissolved and began to swell, and the fiber diameter obtained the maximum swelling rate with 40.1% at a molar ratio of 1:3. Moreover, MD simulation was used to calculate the interaction between IL/water/cellulose, which further illustrated that the combination of IL with water molecular has a significant influence on the behavior of cellulose in IL-H 2 O systems at the molecular scale. Thus, the potential swelling and dissolution mechanism of cellulose in ILs-H 2 O binary systems was proposed based on experimental and simulation results. Furthermore, the characterization results of swollen cellulose indicate that the crystal structure and degree of polymerization (DP) were almost unchanged, but the specific surface area and pore size increased significantly, and the thermal stability and heat absorption were decreased, all the results prove that the swelling process increased the accessibility of cellulose and benefited to the subsequent dissolution. Consequently, preferable swelling and dissolving parameters of experiments and simulations will provide a new idea for the selection of suitable ILs and the recovery of ILs from a coagulation bath in the dry-wet spinning process.

The Effect of Non-Solvent Nature on the Rheological Properties of Cellulose Solution in Diluted Ionic Liquid and Performance of Nanofiltration Membranes

Fabrication of Cellulose Nanofiltration Membranes by Reusing a Binary Solvent of EMIMAc Ionic Liquid and DMSO

Effect of cellulose solubility on the thermal and mechanical properties of regenerated cellulose/graphene nanocomposites based on ionic liquid 1-allyl-3-methylimidazoliun chloride

Preparation and Characterization of Sulfated Carboxymethyl Cellulose Nanofiltration Membranes with Improved Water Permeability

High-flux and anti-fouling cellulose nanofiltration membranes prepared via phase inversion with ionic liquid as solvent

Rheology and dissolution capacity of cellulose in novel [mTBNH][OAc] ionic liquid mixed with green co-solvents

Effects of different ionic liquids as green solvents on the formation and ultrafiltration performance of CA hollow fiber membranes

Effect of Antisolvent Used to Regenerate Cellulose Treated with Ionic Liquid on Its Properties

The Effect of Solvent/Nonsolvent Pair on the Structure and Properties of the Polyethersulfone Membranes

Enhancing the Separation Performance of Cellulose Membranes Fabricated from 1-Ethyl-3-methylimidazolium Acetate by Introducing Acetone as a Co-Solvent

Effect of DMSO Addition on Dissolution of Cellulose in Ionic Liquid

Dissolution of Cellulose in Ionic Liquid–DMSO Mixtures: Roles of DMSO/IL Ratio and the Cation Alkyl Chain Length

Celluloses in an ionic liquid: the rheological properties of the solutions spanning the dilute and semidilute regimes.

Dual Effects of Dimethylsulfoxide on Cellulose Solvating Ability of 1-Allyl-3-methylimidazolium Chloride

Influence of Solvent on the Structure and Performance of Cellulose Acetate Membranes

Formation of Cellulose Acetate Membranes Via Phase Inversion Using Ionic Liquid, [BMIM]SCN, As the Solvent

Swelling and dissolution of cellulose in binary systems of three ionic liquids and three co-solvents

Swelling and dissolution behaviors of cellulose in phosphate-based ionic liquids-H 2 O binary systems: In-situ observation and molecular dynamics simulation

Investigation of unique interactions between cellulose acetate and ionic liquid [EMIM]SCN, and their influences on hollow fiber ultrafiltration membranes

Effect of green co-solvents on properties and synthesis of cellulose esters in superbase ionic liquid

Efficient preparation of high concentration cellulose solution with complex DMSO/ILs solvent