Abstract:A comprehensive investigation into the synthesis of the FER/MFI composite zeolite based on the isopropylamine-silica sol-NaAlO2-H2O system has been carried out. Parameters such as the Na2O/SiO2 molar ratio, SiO2/Al2O3 molar ratio, water concentration, and structure-directing agent (SDA) concentration were of great importance in the crystal phase transition and the morphology control. FER/MFI composite zeolites could be successfully prepared under the conditions of the SiO2/Al2O3 molar ratio ranging from 20 to 30 in the gel mixture. SEM and TEM images showed that the two different crystals (FER and MFI frameworks) in FER/MFI composite zeolites had a state of co-existence and staggered growth, which was typical of composite zeolites. Among these factors influencing the synthesis process, adjusting the Na2O/SiO2 molar ratio was easy to control the relative contents of each phase in the composite zeolites. The higher Na2O/SiO2 molar ratio was, the more content of the FER phase was. NH3-TPD and FT-IR of adsorbed pyridine results showed the acidity properties of composite zeolites were significantly different from those of corresponding physical mixtures. Interestingly, the distribution of aluminum between the FER and MFI structures in the composite zeolites was unequal, and aluminum atoms tended to enrich in the phase predominating in the FER/MFI composite zeolites. The catalytic performance in the cracking of olefins like butene and pentene of the FER/MFI composite zeolite was superior to that of the pure ZSM-5 zeolite. The FER/MFI composite zeolite after further modification is expected to become an excellent catalyst for the catalytic cracking of low carbon olefins to ethylene and propylene.

FAU-to-MFI Interzeolite Transformations: Effects of Synthesis Conditions on Physicochemical Properties and Catalytic Performance

Preparation and catalytic performance of FAU-type zeolite films supported on FeCrAl grids

Synthesis of FER/MFI composite zeolite using isopropylamine as a structure-directing agent

Interzeolite Transformation from FAU to CHA and MFI Zeolites Monitored by UV Raman Spectroscopy

Microstructural Manipulation of MFI-type Zeolite Films/membranes: Current Status and Perspectives

Key Factors During the Milling Stage of the Seed‐assisted and Solvent‐free Synthesis of MFI and Catalytic Behavior in the Alkylation of Phenol with Tert‐butyl Alcohol

Influence of Channel, Construction and Brønsted Acid Sites on the Catalytic Conversion Pathways of Isobutane over MFI, TON and RFE Zeolites

Sustainable synthesis of MFI zeolite and derived metal-acid bifunctional catalysts for hydroisomerization of n-heptane

Microstructure Manipulation of MFI-type Zeolite Membranes on Hollow Fibers for Ethanol–water Separation

Studies on the Use of Faujasite As a Reagent to Deliver Silica and Alumina in Building New Zeolite Structures with Organo-Cations

Seed-induced Synthesis of Functional MFI Zeolite Materials: Method, Mechanism, and Catalytic Property

Advances in the Synthesis of Ferrierite Zeolite

Selective Incorporation of Iron Sites into MFI Zeolite Framework by One-Pot Synthesis

A nickel silicate MFI-type zeolite catalyst prepared by interzeolite transformation: tailoring the catalytic active sites for glucose conversion

Seed-induced synthesis of functional MFI zeolite materials: Method development, crystallization mechanisms, and catalytic properties

Assessment of acid catalytic properties of ferrosilicate MFI zeolite by methanol-to-hydrocarbon conversion

Influence of various templates on the performance of MFI zeolite in catalytic synthesis of trioxane

Sn‐MFI and Fe‐MFI zeolites for fructose conversion to levulinic and lactic acids by the one‐pot method

One-pot synthesis of silanol-free nanosized MFI zeolite

Mechanochemically Assisted Coal Fly Ash Conversion into Zeolite

Conventional Hydrothermal Synthesis of MFI Zeolite in Methanol Solution