Abstract:During high pressure processing, the adiabatic compression increase of food materials would cause non-uniform temperature distribution and heat transfer, which would also influence the inactivation of bacteria, spore, enzyme and the quality of foods. Thermal conductivity of food materials at high pressure is a very important parameter for understanding heat transfer and temperature variation during high pressure processing. Available data and measuring method of thermal conductivity of food materials under high pressure are still scarce. In this study, a thermal conductivity probe developed based on the line heat source theory was installed in a high pressure chamber to measure thermal conductivity of food materials under high pressure. The thermal conductivity probe was calibrated using 1.5% agar gel whose thermal conductivity was very close to that of pure water but the convective effect during the measurement was eliminated due to the gel network at pressure from 0.1 to 400 MPa with a pressure increment of 50 MPa. The results of calibration experiment indicated that thermal conductivity values of 1.5% agar gel measured under different pressures using the thermal conductivity probe were very close to that of reference data of pure water. Calibration factors defined as the ratio of measured and reference values of the thermal conductivity of 1.5% agar gel were found almost no effect by pressure. A general calibration coefficient value of 0.9944 (R square was 0.9997, observation number was 30) was obtained by linear regression analysis (zero intercept) of measured thermal conductivity values of 1.5% agar gel against reference values of pure water. The coefficient value was used for the correction of all experimental results in the following. Thermal conductivities of egg white, egg yolk, ham sausages and cream were measured at pressure from 0.1 to 400 MPa with a pressure increment of 50 MPa. The results demonstrated that the thermal conductivities of these selected food materials at high pressure conditions were higher (up to 28%) than that of the sample at the atmospheric pressure conditions and had a tendency to increase with increasing pressure. Results at atmospheric pressure in this study were compared to estimate values using empirical equation based on water content. The measured thermal conductivities of egg yolk (0.43 W/(m·℃)), ham sausages (0.45 W/(m·℃)) and cream (0.49 W/(m·℃)) were very close to the estimated values (egg yolk 0.40 W/(m·℃), ham sausages 0.43 W/(m·℃), cream 0.41 W/(m·℃)) , while the measured value of egg white (0.65 W/(m·℃)) was significantly higher than that of the estimated value (0.53 W/(m·℃)) as well as that of pure water. The reason probably was that the flowability of egg white caused the generation of convective heat transfer. Measured thermal conductivities of egg white decreased at pressure higher than 300 MPa which was different from other three materials. The reason probably was that the pressure processing more than 300 MPa induced coagulation of egg white resulting in decrease of flowability as well as convective heat transfer. The water content of food materials had a significant effect on thermal conductivity. In general, the higher the water content, the higher the thermal conductivity. This rule was also confirmed at high pressure as the thermal conductivity from highest to lowest in order being egg white (83.1% water) > ham sausages (63.5%) > cream (57.5%) > egg yolk (50.7%). An empirical equation was established for prediction of the thermal conductivity of food materials at high pressure. The fourth-order polynomial was used to fit the thermal conductivity values of egg white, egg yolk, ham sausages and cream at pressure range from 0.1 to 400 MPa with temperature of 25℃. The regression coefficients of these equations were all above 0.91. This study could provide basic scientific datas for high pressure processing of food materials.

Effect of ultra-high pressure homogenization on structural and techno-functional properties of egg yolk granule proteins

Impact of Ultra-High Pressure Homogenization on the Structural Properties of Egg Yolk Granule

Study on potential antigenicity and functional properties of whey protein treated by high hydrostatic pressure based on structural analysis

Ultra High Pressure Increasing Thermal Conductivity of Food Materials

Formation mechanism and stability of egg white fluid gels under ultrahigh-pressure homogenization pretreatment and synergistic heating effect

Effect of dynamic ultra-high pressure homogenization on the structure and functional properties of whey protein

The Impact of High-Pressure Processing on the Structure and Sensory Properties of Egg White-Whey Protein Mixture at Acidic Conditions

Preparation of microgel particles from egg yolk components by combining phospholipase A2 with high-pressure homogenization: Physicochemical, structural properties and their effects on foaming, processing stability of egg white protein

The Effect of High Pressure Homogenization on the Structure of Dual-Protein and Its Emulsion Functional Properties

Enhancing salt-induced gelation of egg yolk granules through pH-ultrasound combined treatment: A physicochemical and microstructural analysis

Applications of High and Ultra High Pressure Homogenization for Food Safety

Impact of High-Pressure Homogenization on Physicochemical, Structural, and Rheological Properties of Quinoa Protein Isolates

Effects of high hydrostatic pressure on physicochemical and functional properties of walnut (Juglans regia L.) protein isolate

Impact of Ultra-High-Pressure Homogenization of Buttermilk for the Production of Yogurt

Physicochemical, conformational and functional changes of quinoa protein affected by high-pressure homogenization

The effects of high-pressure treatment on the structure, physicochemical properties and digestive property of starch - A review

Modifying the Physicochemical and Functional Properties of Water-soluble Protein from Mussels by High-pressure Homogenization Treatment

Effect of High Hydrostatic Pressure Intensity on Structural Modifications in Mealworm (Tenebrio molitor) Proteins

High-pressure microfluidization of whey proteins: Impact on protein structure and ability to bind and protect lutein

Application of pressure homogenization on whole human milk pasteurized by high hydrostatic pressure: Effect on protein aggregates in milk fat globule membrane and skim milk phases

Improvement of egg yolk powder properties through ultrasound coupled sodium sulfite pretreatment assisted enzymatic hydrolysis and underlying mechanism