Abstract:In order to improve the volumetric gas production efficiency of pig manure in continuous biogas project and reduce the heat loss during its feeding and unloading process, the high concentration and small volume feeding method isadopted in this study.The total solid content (TS) of swine manure collected from dry cleaning mode is usually greater than 20％, and thus the manure can be used in not only wet but also the semi-dry or dry anaerobic digestion (AD). Previous reports showed that the dry AD mode can obtain better biogas production than wet AD process with a TS lower than 10％, and can also reduce the volume of dilution water and biogas slurry. Recently, Chinese government is pushing ahead the dry cleaning mode in the livestock and poultry farms, and thus there will be more and more "dry manure" with TS of above 20％ produced from these farms. Therefore, it will be more necessary to study the semi-dry or dry AD process of swine manure. In present assay, a semi-continuous AD experiment up to 100 days was carried out to investigate the interaction between feedstock TS and the hydraulic retention time (HRT). There are 3 sets of reactors, and the feedstock TS is set as 10％, 12％ and 14％, respectively. All the reactors start up from HRT of 25 d, and then the HRT is decreased to 20 and 18.5 d in step by step. The descent process of HRT will cause an increase of organic loading rate (OLR), and thus the reactor state and the biogas production will be influenced. The real-time biogas yield, volumetric biogas production rate (VBPR) and the buffer capacity of each reactor were investigated. The experimental results showed that all the 3 sets of reactors obtained a maximum biogas yield in the continuous AD test when they operated in the stage of HRT of 25 d, and there was no significant difference on the biogas yields among the 3 sets of reactors, around 460 mL/g which reached 86％ of the maximum biogas yield of swine manure obtained from the batch AD process also carried out in present assay. The VBPR of each reactor reached the maximum value at the HRT of 20 d, and the highest VBPR of 2.29 L/(L·d) was observed at the TS of 14％ and the HRT of 20 d. When the HRT decreased to 18.5 d, the biogas yield and the VBPR showed a larger reduction, mainly due to that the higher OLR had exceeded the bear capacity of these reactors. Moreover, the VFA/TA values were close to or exceeded 0.4 at HRT of 18.5 d, which suggested these reactors had a weaker buffer capacity at this time and might be running to the acidification. The optimum operating combination of feedstock TS and HRT could be selected by synthesizing the 3 factors of biogas yield, VBPR and the buffer capacity, and the feedstock TS of 14％ and HRT of 25 d were recommended according to the present experimental results. The present study can provide a help to the practical biogas engineering for the matching of feedstock TS and HRT.

The Influence of CO2 Injection into Manure as a Pretreatment Method for Increased Biogas Production

Characteristics of Biogas Producing by Anaerobic Co-Digestion of Agricultural Straw and Swine Wastewater Based on Improved Straw-Bed Bioreactor

Stimulating Methane Production from Poultry Manure Digest with Sewage Sludge and Organic Waste by Thermal Pretreatment and Adding Iron or Sodium Hydroxide

Study of the Performance of Biogas Production by Mixed Fermentation of Cow Dung, Deer Manure, and Mushroom Fungus

The Influence of Inoculum on High-solids Anaerobic Digestion about Corn Wastes and Pig Manure for Biogas Production

Dry Anaerobic Co-digestion of Cow Dung with Pig Manure for Methane Production

Anaerobic Digestion of Chicken Manure for Production of Methane by Adding Exogenous CO2

Enhanced Biomethane Production by 2-Stage Anaerobic Co-Digestion of Animal Manure with Pretreated Organic Waste

Influence of Molasses and Caesalpinia spinosa Meal Inoculums on Biogas Production from Cattle Manure

Hydrogen–methane Production from Swine Manure: Effect of Pretreatment and VFAs Accumulation on Gas Yield

The Potential of Utilizing Cattle (Cow) Manure for Biomethane Production—An Experiment for Photofermentation

Biogas production performance of swine manure by mesophilic semi-dry continuous anaerobic digestion

Recycling Of Livestock Manure Into Bioenergy

Co‐substrate composition is critical for enrichment of functional key species and for process efficiency during biogas production from cattle manure

Anaerobic Co-Digestion of Animal Manures with Corn Stover or Apple Pulp for Enhanced Biogas Production

Effect of aeration pretreatment on anaerobic digestion of swine manure

Optimization of the Process Conditions for Methane Yield from Co-Digestion of Mixed Vegetable Residues and Pig Manure Using Response Surface Methodology

Biogas Production by Co-Digestion of Goat Manure with Three Crop Residues

Performance Enhancement by Rumen Cultures in Anaerobic Co-Digestion of Corn Straw with Pig Manure

Effect of manure co-digestion on methane production, carbon retention, and fertilizer value of digestate

Pulsed CO2 Feeding Promotes Methane Yield in Anaerobic Digester by Diverting Acidogenic Pathways