Abstract:Water-soluble amphiphilic polymers are vital chemicals in the oil and gas industry to retard crystal growth of hydrocarbon hydrate via surface adsorption and suppress nucleation of a pristine hydrate nucleus, thereby preventing formation of hydrate blockages in flow lines during oil and natural gas production. Apart from a few theoretical modeling studies, an experimental method to study the polymer/water interface in the crystal growth is critically needed. Here, water motions in the hydration shells of an exemplary kinetic inhibitor, poly(N-vinylcaprolactam), during hydrate formation from the tetrahydrofuran/water system are revealed via nuclear magnetic resonance relaxometry. Unequivocal experiments show that the pivotal interfacial water in the tightly bound state gradually freezes at rates depending on the polymer molecular weight (MW). This is supported by nonfreezable water analysis, which is correlated to the inhibition time. The polymers tune the kinetics of the hydration process via interaction with and perturbation of the water molecules. The free water component in the polymer solution crystallizes at a very slow rate when in partially restricted mobility, whereas the bound water component increases in the reaction, with the polymer/water interface serving as the reaction sites. The appropriate MW (including average MW and polydispersity values) of the inhibitive polymers can give rise to maximal retardation of the hydrate crystal growth. This work will help control other multiphase crystallization kinetic processes through the design of inhibitors or promoters functioning in the interface.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acs.langmuir.2c00472.Isothermal hold time measurement of THF/water solutions in the presence of PVCap samples with different MWs; T2 distribution curves of d8-THF aqueous solution without the polymer; Arrhenius plot of the T2 relaxation peak position of free water and bound water species in d8-THF/water with PVCap versus temperature; time-dependent changes of bound water in their T2 relaxation distributions in solution with PVCap during isothermal crystallization; isothermal changes of the bound water peak areas in the presence of PVCap with time at 258 K Typical calorimetric traces of water mixed with different amounts of PVCap polymers; determination method of free and bound water dynamics based on the BPP theory; and activation energies and correlation times of bound and free water in d8-THF/water solutions with and without PVCap (PDF)This article has not yet been cited by other publications.

Inhibition effects of poly(N-vinylcaprolactam)/poly(ε-caprolactone) amphiphilic block copolymers on methane hydrate formation

Synthesis, micellization, and thermally-induced macroscopic micelle aggregation of poly(vinyl chloride)-g-poly(N-isopropylacrylamide) amphiphilic copolymer

Micellization Phenomena of Amphiphilic Block Copolymers Based on Methoxy Poly(ethylene Glycol) and Either Crystalline or Amorphous Poly(caprolactone-b-lactide)

Amphiphilic Block Copolymers Based on Methoxy Poly(ethylene Glycol) and Either Crystalline or Amorphous Poly(caprolactone‐b‐lactide): Synthesis, Solid‐state and Aqueous Solution Characterizations

Investigation into the Inhibition of Methane Hydrate Formation in the Presence of Hydroxy- and Esteryl-Terminated Poly( N -vinylcaprolactam)

Influence of the introduction of small hydrophilic groups on the kinetic hydrate inhibition effect of poly(N-vinylcaprolactam)

Effects of Poly(styrene/pentafluorostyrene-block-vinylpyrrolidone) Amphiphilic Kinetic Hydrate Inhibitors on the Dynamic Viscosity of Methane Hydrate Systems at High-Pressure Driving Forces

Inhibition Effect of Novel Amphiphilic Poly(amino Acid)s on Methane Hydrate

Synthesis and evaluation of poly (N-vinyl caprolactam)-co-tert-butyl acrylate as kinetic hydrate inhibitor

Kinetic Inhibition of Clathrate Hydrate by Copolymers Based on N -Vinylcaprolactam and N -Acryloylpyrrolidine: Optimization Effect of Interfacial Nonfreezable Water of Polymers

Effects of PVP and PVCap in Brine Solutions on the Formation Kinetics and Morphological Evolution of Sour Gas Hydrates

Dependence of the Kinetic Hydrate Inhibition Effect of Poly( N -vinylpyrrolidone) upon the Molecular Weight Is Influenced by Water Mobility in Millisecond Dynamics

Insights into the synergistic effect of polylactam kinetic hydrate inhibitor and amino acid via molecular dynamics simulations

Inhibition on methane hydrate formation by polyacrylate superabsorbent hydrogel

Unraveling Amphiphilic Poly( N -vinylcaprolactam)/Water Interface by Nuclear Magnetic Resonance Relaxometry: Control of Clathrate Hydrate Formation Kinetics

Experimental study on the effect of PVP, NaCl and EG on the methane hydrates formation and dissociation kinetics

Effect of Composition on the Crystallization, Water Absorption, and Biodegradation of Poly(ε-caprolactam -co-ε-caprolactone) Copolymers

The effect of PVP and PVA on hydrate formation kinetics of ethane and propane mixture in the presence of kaolin nanoparticles

Differences in Nucleator Adsorption May Explain Distinct Inhibition Activities of Two Gas Hydrate Kinetic Inhibitors

Biomedical Property Modifications of Poly(vinyl Chloride) with Methoxylated Poly(ethylene Glycol)‐poly(ε‐caprolactone) Diblock Copolymer

Effects of Poly(vinylpyrrolidone) on the Dynamic Viscosity of Methane Hydrate Systems at High-Pressure Driving Forces: Investigation of Concentration, Molecular Weight, and Shear Rate