Abstract:Heated pipe transportation is one of the most common used ways of offshore oil and gas transportation, and the mechanism of pipe-soil foundation interaction is the key to the controllable thermal buckling design of heated pipes. The change of pipe temperature not only causes the strong thermo-hydro-mechanical coupling response of the surrounding seabed saturated soil foundation, but also induces the migration of pore water under the temperature gradient, showing a significant thermo-osmosis effect. In this paper, a numerical study is presented to study the heated pipe-saturated soil foundation interaction considering thermo-osmosis (T-O) effect based on the OpenGeoSys finite element platform. Based on the mass equation and energy equation, the theoretical expression of the influence factors of thermo-osmosis effect was derived and the critical influence factors were proposed, which determined the critical values of T-O coefficient for some common soil and water parameters. Through the secondary development in OpenGeoSys embedding the T-O effect, a heated pipe-saturated soil interaction model, which can consider the thermohydro-mechanical coupling behavior and the T-O effect of soils surrounding the pipe, was established. The validity of the model was verified by comparing with the analytical results, and then the effect of T-O on the pipe-soil interaction was discussed based on the influence factors of T-O effect and numerical results, including the evolutions of pore water pressure and vertical displacement of seabed soils around the pipe with different oil transportation temperature and different initial buried depth during the operation period. Results showed that the critical value of the T-O cofficient is 43x10(-12) m(2)/(s . K), which provides a basis for evaluating whether the T-O effect is considered in practical engineering. The T-O effect has little influence on the peak value of pore pressure of soil, but it can cause significant stable-state negative pore pressure. The proportional relationship between the amplitude and the peak value of the negative pore pressure is determined by the proposed influence factor of T-O effect. During pipeline operation, temperature often induces soil weakening and negative pore pressure, which have adverse effects on pipe stability. This adverse effect is enhanced with the increase of oil transportation temperature and depth within 3 D (D is the diameter of the pipe), but there is no significant difference in this adverse effect caused by T-O with depth above 3 D.

A new model of temperature-dependent permeability coefficient and simulating of pipe leakage produced immersion of loess foundation

Three-dimensional pipe leakage assessment in water distribution system

Influence of Clod Size and Water Content on Gas Permeability of A Compacted Loess

Numerical Studies on Filter of Piping in Broadly Graded Cohesionless Soils

Analysis of Fluidized Zone in Transparent Soil under Jet Induced by Pipe Leakage

Time-dependent behaviour of thermal-hydro-mechanical coupling of gassy soils

Impact of water delivery pipeline leakage on collapsible loess foundations and treatment methods

Analysis of pipeline leakage in unsaturated stratum: A new seepage-diffusion model

Numerical study on heated pipe-saturated soil foundation interaction considering thermo-osmosis effect

Hydro-mechanical Behavior of Unsaturated Soil Surrounding a Heated Pipeline Considering Moisture Evaporation and Condensation

Transformation mechanism of suffusion and backward erosion piping in gap-graded soil: an experimental study

Experimental Study on the Penetration of Natural Unsaturated and Collapsible Loess Based on the Permeability Velocity

Thermo–Hydro–Mechanical Behavior of Unsaturated Loess Considering the Effect of Porosity and Temperature on Water Retention Properties

Effect of moisture content, temperature, and microstructure on the thermal conductivity of loess and its prediction model

Collapsibility Mechanisms and Water Diffusion Morphologies of Loess in Weibei Area

A study of the permeability of the Malan loess under rainfall

Response and prediction of unsaturated permeability of loess to microstructure

Measurement and modeling of the evaporation rate of loess under high temperature

Variation and correlation between water retention capacity and gas permeability of compacted loess overburden during wetting-drying cycles

Saturated permeability of compacted loess based on low-field nuclear magnetic resonance (NMR)

Study on Piping Leakage of Dam with Limited-Length Line Heat Source Model and Experiment