Abstract:It has been predicted that several changes will occur when premixed flames are subjected to the extreme levels of turbulence that can be found in practical combustors. This paper is a review of recent experimental and DNS results that have been obtained for the range of extreme turbulence, and it includes a discussion of cases that agree or disagree with predictions. "Extreme turbulence" is defined to correspond to a turbulent Reynolds number (Re-T, based on integral scale) that exceeds 2800 or a turbulent Karlovitz number that exceeds 100, for reasons that are discussed in Section 2.1. Several data bases are described that include measurements made at Lund University, the University of Sydney, the University of Michigan and the U.S. Air Force Research Lab. The data bases also include DNS results from Sandia National Laboratory, the University of New South Wales, Newcastle University, the California Institute of Technology and the University of Cambridge. Several major observations are: (a) DNS now can be achieved for a realistic geometry (of the Lund University jet burner) even for extreme turbulence levels, (b) state relations (conditional mean profiles) from DNS and experiments do tend to agree with laminar profiles, at least for methane-air and hydrogen-air reactants that are not preheated, and (c) regime boundaries have been measured and they do not agree with predicted boundaries. These findings indicate that the range of conditions for which flamelet models should be valid is larger than what was previously believed. Additional parameters have been shown to be important; for example, broken reactions occur if the "back-support" is insufficient due to the entrainment of cold gas into the product gas. Turbulent burning velocity measurements have been extended from the previous normalized turbulence levels (u'/S-L) of 24 up to a value of 163. Turbulent burning velocities no longer follow the trend predicted by Shchelkin but they tend to follow the trend predicted by Damkohler. The boundary where flamelet broadening begins was measured to occur at Re-Taylor = 13.8, which corresponds to an integral scale Reynolds number (Re-T) of 2800. This measured regime boundary can be explained by the idea that flame structure is altered when the turbulent diffusivity at the Taylor scale exceeds a critical value, rather than the idea that changes occur when Kolmogorov eddies just fit inside a flamelet. A roadmap to extend DNS to complex chemistry and to higher Reynolds numbers is discussed. Exascale computers, machine learning, adaptive mesh refinement and embedded DNS show promise. Some advances are reviewed that have extended the use of line and planar PLIF and CARS laser diagnostics to studies that consider complex hydrocarbon fuels and harsh environments. (C) 2019 Elsevier Ltd. All rights reserved.

Autoignition Regime Boundaries for n-Heptane Droplets Under Microgravity

On the Low Temperature and Low Pressure Regime Diagram of n-Heptane Droplet Burning in Microgravity

Low-temperature Chemistry in N-Heptane/air Premixed Turbulent Flames

Regimes of Premixed Turbulent Spontaneous Ignition and Deflagration under Gas-Turbine Reheat Combustion Conditions

Premixed Flames Subjected to Extreme Turbulence: Some Questions and Recent Answers

Experimental Investigation of Low-Temperature Autoignition in Turbulent Premixed Swirling Flames

Turbulence, Evaporation and Combustion Interactions in N-Heptane Droplets under High Pressure Conditions Using DNS

The Effect of Droplet Size on Boundary Migration of Burning Modes for Autoignition of N-Heptane Droplets

Simulation of Low-Temperature Oxidation and Combustion of N-Dodecane Droplets under Microgravity Conditions

Effect of Droplet Diameter and Global Equivalence Ratio on N-Heptane Spray Auto-Ignition

A Cell Model Analysis for Droplets Inside Non-Dilute N-Heptane Droplet Clouds Near Autoignition Limit

Analysis of Evaporation and Autoignition of Droplet Clouds with a Unit Cell Model Considering Transient Evaporating Boundary Layer

Comprehensive Study of Initial Diameter Effects and Other Observations on Convection-Free Droplet Combustion in the Standard Atmosphere for N-Heptane, N-Octane, and N-Decane

Studies of Flame Structure in Microgravity

Low Temperature n-Dodecane Droplet Combustion Experiments Aboard the International Space Station

On the transition modes and mechanisms for laminar to turbulent lifted jet diffusion flames at normal- and micro-gravity

Microgravity Burner-Generated Spherical Diffusion Flames: Experiment and Computation

DNS of the Ignition Process of N-Heptane/air Premixed Combustion with Low-Temperature Chemistry in Turbulent Boundary Layer

Numerical analysis on combustion characteristics of diffusion jet flame under different gravity environments

Atomic-level insights into transition mechanism of dominant mixing modes of multi-component fuel droplets: From evaporation to diffusion

Apparatus to investigate liquid oxygen droplet combustion in hydrogen under microgravity conditions