Abstract:It is important to reveal the mechanism and law of oil vapor leakage and diffusion of external floating-roof tank (EFRT) to ensure the tank farm safety and reduce the environmental pollution. In present paper, numerical simulation and experimental verification were carried out for the oil vapor leakage and diffusion of large and small EFRT at different leak locations and pore sizes. The results were as follows. ① When the wind blows to the EFRT, a large scale eddy will form above the floating deck and form a symmetrical distribution of air flow from the downwind side to the upper wind side. ② When a pore leak occurs above the floating deck, oil vapor is closely attached to the floating deck and moves from the downwind to the upwind side. Oil vapor is easy to spread out when the leakage positions of the floating deck are located in the middle or the downwind side, but it is easy to accumulate when the positions are on upwind side or both sides of the floating deck, and there is a great potential safety hazard. The increase of wind speed is beneficial to the diffusion of oil vapor, but it will enlarge the scope of pollution. ③ when there was a rim leakage between the floating deck and tank wall, oil vapor diffuses along the tank wall to the upper space of the floating deck, and the extent of diffusion is: the sides of the floating deck> the upper wind side> the downwind side. ④ For the central leakage pore of the floating deck, when the pore diameter is 20 mm, the volume fraction of n-heptane is between 0.1％ and 1.7％, which is within the corresponding explosion limit range; however, when the pore diameter is 6 mm, the volume fraction of nheptane is between 0.02％ and 0.26％ and the volume fraction of gasoline vapor is between 0.05％ and0.65％, which all are not up to the explosion limit range. Thus, the possibility of explosion danger increases with the enlargement of the pore diameter. The research results will further reveal the migration law of the mixture gas of the vapor-air above the floating deck and the mass transfer mechanism of oil vapor diffusion, which can provide theoretical guidance for field practice and oil tank management and improve the theoretical system for evaluating the EFRT evaporation loss.

Analysis of oil vapor diffusion after oil spill from tank group based on wind tunnel experiment and numerical simulation

Fractal Simulation of Oil Spill Trajectory in the Northern Port Area of the Yueqing Bay

Oil Spill Spreading Simulation Based on an Enhanced Multi-phase Consistent Particle Method

CFD study of huge oil depot fires - Generation of fire merging and fire whirl in arrayed oil tanks

Research on the Calculation Method and Diffusion Pattern of VCE Injury Probability in Oil Tank Group Based on SLAB-TNO Method

Numerical Simulation of Spill Oil Diffusion in Offshore Oil Pipeline

Leakage diffusion of underwater crude oil in wind fields

Experimental Study on the Synergistic Effect between Evaporation Weathering and Emulsification of Oil Spills

Experimental Study on Characteristics of Oil Tank Fire Before Boilover

Numerical Study of Leakage and Diffusion of Underwater Oil Spill by Using Volume-of-Fluid (VOF) Technique and Remediation Strategies for Clean-Up

Numerical simulation study on drift and diffusion of Dalian Oil Spill

Numerical simulation of oil vapor leakage and diffusion from different pores of external floating-roof tank

Numerical simulation and environmental impact assessment of oil vapor diffusion in surrounding residential areas before/after vapor recovery at petrol stations

Experimental investigation and modeling of the spread and burning behaviors of continuous spill fires on a water surface

Numerical simulations on the oil plume evolutions and the two critical aspects of emergent oil containment for ship collision-incurred oil spills

Influence and Prediction of Oil Film Migration in Submarine Pipeline Spills under Multiple Factors

An Experimental and Modeling Study of Continuous Liquid Fuel Spill Fires on Water

An experimental study on the spreading characteristics and burning behaviors of continuous spill fires under cross flow

Numerical Simulation of Leakage and Diffusion Process of LNG Storage Tanks

NUMERICAL SIMULATION STUDY OF OIL SPILL DIFFUSION IN THE QUANZHOU BAY AREA BASED ON AN OIL PARTICLE MODEL

Experimental investigation on flame characteristics in a linear array of dual spill fire