Abstract:Four wild "red" yeast strains (Rhodosporidium kratochvilovae FMCC Y70, R. toruloides NRRL Y-27013, R. toruloides NRRL Y-17902 and R. toruloides NRRL Y-6985) were cultured in shake flasks on industrial glycerol at an initial substrate (Gly0) concentration ≈ 50 g/L under nitrogen limitation. Strains NRRL Y-27013, NRRL Y-17902 and NRRL Y-6985 presented appreciable dry cell weight (DCW) and lipid synthesis (DCW up to 18–19 g/L containing lipids in quantities ≈ 47%, w/w). Strains NRRL Y-27013 and NRRL Y-6985 were further tested in higher Gly0 concentrations (≈90 g/L and ≈110 g/L) with the same initial nitrogen quantity as in the first ("screening") experiment. Both strains, despite the high Gly0 concentrations and C/N ratios (up to 120 moles/moles) imposed, presented significant DCW production (up to c. 29.0–29.5 g/L). Yeast biomass contained significant lipid (42–43%, w/w) and endopolysaccharide (up to 42%, w/w) quantities. Both lipids and endopolysaccharide quantities (in % w/w) noticeably increased as a response to the imposed nitrogen limitation. Lipids containing mainly oleic and palmitic acids constituted ideal candidates for biodiesel synthesis. Thereafter, the wastewaters derived from the lipid production process (lipid fermentation wastewaters—LFWs) were used as maceration waters in cultivations of edible and medicinal fungi, where novel (non-conventional) substrates were used in the performed cultures. CW (coffee residue + wheat straw), CB (coffee residue + beech wood shavings), OW (olive crop + wheat straw), OB (olive crop + beech wood shavings), RW (rice husk + wheat straw) and RB (rice husk + beech wood shavings) were soaked/sprayed with LFWs or tap water and utilized in the cultivation of Pleurotus, Ganoderma and Lentinula mushrooms. The impact of LFWs on the mycelial growth rate (mm/d) and biomass production was evaluated. The results show that regardless of the wetting method, the highest growth rates (6.2–6.6 mm/d) were noticed on RW and RB for Pleurotus eryngii and Ganoderma resinaceum, on OW, OB and RW for Ganoderma applanatum and on RW, OW and OB for Lentinula edodes. Nevertheless, high biomass production was obtained on substrates soaked with LFWs for Pleurotus ostreatus (RW: 443 mg/g d.w.), L. edodes (RB: 238 mg/g d.w.) and Ganoderma lucidum (RW: 450 mg/g d.w.). Overall, this study demonstrates the possibility of the industrial conversion of low-value agro-waste to mycelial mass and eventually to important food products.

Conversion of banana peel into diverse valuable metabolites using an autochthonous Rhodotorula mucilaginosa strain

Optimization of agro-industrial coproducts (molasses and cassava wastewater) for the simultaneous production of lipids and carotenoids by Rhodotorula mucilaginosa

Β-Carotene Production from Sugarcane Molasses by a Newly Isolated Rhodotorula Toruloides L/24-26-1

Application of Extractive Fermentation on the Recuperation of Exopolysaccharide from Rhodotorula mucilaginosa UANL-001L

Valorization Parameters to Determine the Fermentative Applicability of Selected Fruit Peels for Xylanase Production

Optimization of Total Carotenoid Production by Rhodotorula mucilaginosa from Artichoke Agroindustrial Waste Using Response Surface Methodology

Concentrated Manipueira as an Alternative Low-Cost Substrate to Rhodotorula glutinis for Biotechnological Production of High Contents of Carotenoids

Optimization of the biotechnological process using Rhodotorula mucilaginosa and acerola (Malpighia emarginata L.) seeds for the production of bioactive compounds

Valorization of orange peels exploiting fungal solid-state and lacto-fermentation

Selective recovery and purification of carotenoids and fatty acids from Rhodotorula glutinis using mixtures of biosolvents

Using strain Rhodotorula mucilaginosa to produce carotenoids using food wastes

Supplementation of watermelon peels as an enhancer of lipase and esterase production by Yarrowia lipolytica in solid-state fermentation and their potential use as biocatalysts in poly(ethylene terephthalate) (PET) depolymerization reactions

Valorization of unripe banana peel (Robusta) powder for the production of tannase using Bacillus xiamenensis in submerged fermentation

PHB production by Bacillus megaterium strain MNSH1-9K-1 using low-cost media

Enhancement of Biomass and Protein Production of Chlorella protothecoides in Heterotrophic Cultivation Using Expired Juices as Alternative Source of Nutrients for an Added-Value Biorefinery Scheme

Xylose Metabolism and the Effect of Oxidative Stress on Lipid and Carotenoid Production in Rhodotorula toruloides: Insights for Future Biorefinery

Culture Strategies for Lipid Production Using Low-cost Carbon Sources by Rhodosporidium Toruloides

New Biotechnological Production of EPA by Pythium irregulare Using Alternative Sustainable Media Obtained from Food Industry By-Products and Waste

Yeast Lipids from Crude Glycerol Media and Utilization of Lipid Fermentation Wastewater as Maceration Water in Cultures of Edible and Medicinal Mushrooms

Bioprocesses with Reduced Ecological Footprint by Marine Debaryomyces hansenii Strain for Potential Applications in Circular Economy

Efficient simultaneous production of extracellular polyol esters of fatty acids and intracellular lipids from inulin by a deep-sea yeast Rhodotorula paludigena P4R5