Abstract:The addition of anti-agglomerants (AAs) is a promising solution for decreasing the risk of gas hydrate plugging in deepwater hydrocarbon flowlines or during drilling operations. AAs (usually surfactants) can adsorb on small hydrate particles and make them dispersing, thus leading to the prevention of agglomeration. However, it is not fully clear whether AAs promote or inhibit hydrate nucleation and growth during this process. Here, a series of AAs/surfactants (dodecyl benzene sulfonic acid, 1-naphthylacetic acid, tetramethyl ammonium bromide, Span80, rhamnolipid, and cocamidopropyl dimethylamine) with different types and concentrations were studied so as to clarify the effects of AAs/surfactants on formation kinetics of CH4 hydrate using a dynamic experimental system. In the experiments, 20%, 60%, 95%, 100% water-cut systems with or without 0.5 wt% and 1.0 wt% concentrations of AAs/surfactants were pressurized with CH4 at 3.0 °C and 6.0 MPa. The induction time, the amount of hydrate formation, and the average rate of hydrate growth in these systems were measured. The results show that AAs/surfactants can promote hydrate formation in pure water (100%) and high water cut (95%) systems. Only in these high water cut systems will the pressure decrease in a multi-step manner. The occurrence of this interesting phenomenon is related to the water cut and the type of AAs, which may be due to the rapid hydrate formation and large expansion of the hydrate volume. While in relatively low water cut (20% and 60%) systems, AAs/surfactants slow down or even completely prevent the hydrate nucleation and growth under our experimental conditions, which may mainly result from the mass transfer barrier of AAs/surfactants. This study will be conducive to revealing the kinetic inhibition mechanism of AAs on hydrate agglomeration, and can be of importance to the safe implementation of multiphase flow transportation and deepwater oil and gas exploration.

Influence of a nonionic surfactant on hydrate growth in an oil-water emulsion system

Formation of Methane Hydrate in Oil–Water Emulsion Governed by the Hydrophilic and Hydrophobic Properties of Non-Ionic Surfactants

Characterization of Hydrate Formation and Flow Influenced by Hydrophilic–Hydrophobic Components within a Fully Visual Rocking Cell

Experimental study of methane hydrate formation and agglomeration in waxy oil-in-water emulsions

Study on the Formation Characteristics of CO 2 Hydrate and the Rheological Properties of Slurry in a Flow System Containing Surfactants

Anti-agglomeration evaluation and Raman spectroscopic analysis on mixed biosurfactants for preventing CH4 hydrate blockage in n-octane + water systems

Influence of Asphaltenes on Hydrate Formation and Decomposition in Water-in-Waxy Oil Emulsions

Influence Mechanism of the Interaction Between Resins and Asphaltenes at Oil–water Interface on Hydrate Growth in a Low-Viscosity Model Oil

Effect of nonionic surfactants on the synergistic interaction between asphaltene and resin: Emulsion phase inversion and stability

Influence of Surfactant and Weak-Alkali Concentrations on the Stability of O/W Emulsion in an Alkali-Surfactant–Polymer Compound System

Effects of Combined Sorbitan Monolaurate Anti-Agglomerants on Viscosity of Water-in-Oil Emulsion and Natural Gas Hydrate Slurry

Microscopic Insights into the Effects of Anti-Agglomerant Surfactants on Surface Characteristics of Tetrahydrofuran Hydrate

Effect of Surfactants with Different Hydrophilic–Lipophilic Balance on the Cohesive Force between Cyclopentane Hydrate Particles

Investigation Of Gas Hydrate Formation And Inhibition In Oil-Water System Containing Model Asphaltene

Molecular Dynamics Simulation of the Effects of Complex Surfactants on Oil-Water Interaction and Aggregation Characteristics at the Interface.

Influence of Surfactant Structure on the Stability of Water-in-Oil Emulsions under High-Temperature High-Salinity Conditions

Interaction between polymer and anionic/nonionic surfactants and its mechanism of enhanced oil recovery

Molecular dynamics simulation study on interfacial behaviors of betaines and extended surfactants

Investigation on Hydrate Formation and Growth Characteristics in Dissolved Asphaltene-Containing Water-In-Oil Emulsion

The kinetic effects of hydrate anti-agglomerants/surfactants

The effect of surfactants on hydrate particle agglomeration in liquid hydrocarbon continuous systems: a molecular dynamics simulation study