Abstract:Nanoparticle Tracking Analysis (NTA) is an emerging analytical technique developed for detection, sizing, and counting of sub-micron particles in liquid media. Its feasibility for use in biopharmaceutical development was evaluated with particle standards and recombinant protein solutions. Measurements of aqueous suspensions of NIST-traceable polystyrene particle standards showed accurate particle concentration detection between 2 × 10(7) and 5 × 10(9) particles/mL. Sizing was accurate for particle standards up to 200 nm. Smaller than nominal value sizes were detected by NTA for the 300-900 nm particles. Measurements of protein solutions showed that NTA performance is solution-specific. Reduced sensitivity, especially in opalescent solutions, was observed. Measurements in such solutions may require sample dilution; however, common sample manipulations, such as dilution and filtration, may result in particle formation. Dilution and filtration case studies are presented to further illustrate such behavior. To benchmark general performance, NTA was compared against asymmetric flow field flow fractionation coupled with multi-angle light scattering (aF4-MALS) and dynamic light scattering, which are other techniques for sub-micron particles. Data shows that all three methods have limitations and may not work equally well under certain conditions. Nevertheless, the ability of NTA to directly detect and count sub-micron particles is a feature not matched by aF4-MALS or dynamic light scattering. Lay abstract: Thorough characterization of particulate matter present in protein therapeutics is limited by the lack of analytical methods for particles in the sub-micron size range. Emerging techniques are being developed to bridge this analytical gap. In this study, Nanoparticle Tracking Analysis is evaluated as a potential tool for biologics development. Our results indicate that method performance is molecule-specific and may not work as well under all solution conditions, especially when testing opalescent solutions. Advantages and disadvantages of Nanoparticle Tracking Analysis are discussed in comparison to other analytical techniques for particles in the sub-micron size range.

SNC‐TIRS: Label‐free Single Nanoparticle Characterization System Based on Total Internal Reflection Scattering Signal

An optical nanofibre-enabled on-chip single-nanoparticle sensor

Refractive Index Determination of Individual Viruses and Small Extracellular Vesicles in Aqueous Media Using Nano-Flow Cytometry

Characterization of extracellular vesicles and synthetic nanoparticles with four orthogonal single-particle analysis platforms

Combined Morpho-Chemical Profiling of Individual Extracellular Vesicles and Functional Nanoparticles without Labels

Development and Applications of A Highly Sensitive and Wide Dynamic Range Nano-Flow Cytometer

Single particle ICP-MS: a tool for the characterization of gold nanoparticles in nanotheranostics applications

Optofluidic restricted imaging, spectroscopy and counting of nanoparticles by evanescent wave using immiscible liquids

Nanoparticle Tracking Analysis-Based <i>In Vitro</i> Detection of Critical Biomarkers

Practical Considerations for Detection and Characterization of Sub-Micron Particles in Protein Solutions by Nanoparticle Tracking Analysis

Sensitive Single Particle Method for Characterizing Rapid Rotational and Translational Diffusion and Aspect Ratio of Anisotropic Nanoparticles and Its Application in Immunoassays.

Label-free single nanoparticle identification and characterization including infectious emergent virus

Spatially Resolved Scattering Correlation Spectroscopy Using A Total Internal Reflection Configuration

Label-Free Light Scattering Imaging with Purified Brownian Motion Differentiates Small Extracellular Vesicles in Cell Microenvironments.

Total internal reflection-based single-vesicle in situ quantitative and stoichiometric analysis of tumor-derived exosomal microRNAs for diagnosis and treatment monitoring.

Light-scattering detection below the level of single fluorescent molecules for high-resolution characterization of functional nanoparticles.

Current analytical approaches for characterizing nanoparticle sizes in pharmaceutical research

Critical Evaluation of Nanoparticle Tracking Analysis (NTA) by NanoSight for the Measurement of Nanoparticles and Protein Aggregates

Size and isotope analysis of individual nanoparticles by multi-collector ICP-MS using "event-triggered signal capture" with a high-speed oscilloscope

Gires-Tournois Immunoassay Platform for Label-Free Bright-Field Imaging and Facile Quantification of Bioparticles

Identification and Accurate Size Characterization of Nanoparticles in Complex Media.