Abstract:Increasing global waste generation is not only a threat but also an opportunity to address energy insecurity and pollution using green valorization techniques. However, this requires pretreatment of waste and byproducts and optimization of drying to obtain high‐quality biofuels. Hence, this study aims to analyze the performance of currently used drying models, the influence of different drying temperatures, drying time, and seed pretreatment on the drying kinetics of two varieties of mango seed. Accordingly, whole seeds and crushed seeds were exposed to five drying temperatures (313–353 K) in a heating furnace. Weight loss was recorded systematically, converted into moisture ratio, and then fitted to four semitheoretical mathematical models, namely: (i) Lewis, (ii) Henderson and Pabis, (iii) Page, and (iv) Avhad and Marchetti models. The fitness of these models was compared using statistical parameters, such as R2, X2, root mean square error (RMSE), mean bias error (MBE), and mean absolute error (MAE). The results showed that seed pretreatment and increasing the drying temperature led to an increase in the rate of moisture evaporation and reduced the time required for drying. Among all models, the Avhad and Marchetti model provided higher R2 values of 0.9994 and 0.9991 for local and hybrid mango at 313 K, and 0.9977, and 0.9970 for local and hybrid crushed mango seeds at 353 K and 313 K, respectively; hence, it showed the best performance. The activation energy (Ea) showed a slight differences for both varieties of mango seed and among pretreatments in all mathematical models. The mean Ea values for local and hybrid mango seeds were 41.18 kJ mol−1 and 46.21 kJ mol−1, respectively. For whole and crushed local and hybrid mango varieties, the mean Ea values were 31.37 kJ mol−1, 40.80 kJ mol−1, 50.99 kJ mol−1, and 51.61 kJ mol−1. The likely reason for this variation might be differences in variety, chemical composition, growing conditions, and cellular structure of the seed varieties.

Drying Kinetics of Pretreated Drumstick (Moringa oleifera) Leaves During Lyophillization

Mathematical Modeling of Thin Layer Drying Kinetics and Moisture Diffusivity Study of Pretreated Moringa oleifera Leaves Using Fluidized Bed Dryer

Mathematical Modeling of Drying Kinetics and Technological and Chemical Properties of Pereskia sp. Leaf Powders

A comparative assessment of drying kinetics, energy consumption, mathematical modeling, and multivariate analysis of Indian borage (Plectranthus amboinicus) leaves

Thin Layer Drying Process of Some Leafy Vegetables under Open Sun

Determination of the drying kinetics and energy efficiency of purple basil (Ocimum basilicum L.) leaves using different drying methods

Effect of drying methods on drying kinetics, energy features, thermophysical and microstructural properties of Stevia rebaudiana leaves

Experimental study and mathematical modeling of drying kinetics of mint leaves under forced convection

Semi-Empirical Mathematical Modeling, Energy and Exergy Analysis, and Textural Characteristics of Convectively Dried Plantain Banana Slices

Drying kinetics and thermal energy evaluation of Moringa oleifera leaves drying using dehumidification with zeolite

Heat and Mass Transfer, Quality, Performance Analysis, and Modeling of Thin Layer Drying Kinetics of Banana Slices

Drying kinetics and mathematical modeling of seeds of two mango varieties at different temperatures and with different pretreatments

Experimental Investigations of Thin-layer Drying of Leaves in a Heat-Pump Assisted Tray-type Batch Drying Chamber

Effect of Drying on Insulin Plant Leaves for Its Sustainability and Modeling the Drying Kinetics by Mathematical Models and Artificial Neural Network

Analysis of red chilli drying kinetics affected by low-temperature long time blanching

Drying kinetics, mass transfer parameters, and specific energy consumption analysis of watermelon seeds dried using the convective dryer

ESTIMATION OF THIN-LAYER DRYING KINETICS OF UNDERUTILIZED PEA PODS USING PAGE’S MODEL

Effect of drying techniques, conditions and feed types on the quality of dried curry leaf powder

Integrated drying model of lychee as a function of temperature and relative humidity

Effect of ANN and semi-empirical models on dried Annona muricata leaves

Investigation on drying kinetics analysis of gooseberry slices dried under open sun