Abstract:This research presents a thorough evaluation of an integrated system comprising a Solid Oxide Fuel Cell (SOFC), Organic Rankine Cycle (ORC), and Absorption Chiller (AC). The study employs ASPEN PLUS V10 to assess the system's energy, exergy, economic, and environmental performance. The Integrated SOFC-ORC-AC system offers trigeneration capabilities, generating electricity, cooling, and heating from a single fuel source. It demonstrates potential as an efficient and environmentally friendly energy generation method. The system can be fuelled by steam-reformed natural gas or renewable fuels like biogas or syngas. The SOFC, employing a solid electrolyte, facilitates an electrochemical reaction with hydrogen, producing electricity and heat. The exhaust gas further powers the ORC and AC units. The study builds a mathematical model, assuming steady-state, isothermal, and chemically equilibrated conditions. The SOFC and ORC simulations utilize the Peng Robinson model, while the LiBr absorption chiller employs the ELECNRTL property method for fluid thermodynamic properties. The SOFC electrical model was validated against real-world data, ensuring accuracy. The study also tested a single-effect LiBr absorption chiller, comparing results with experimental data. The operating pressure's effect on SOFC performance was evaluated, demonstrating reduced voltage losses and increased cell voltage and power density at higher pressures. Operating temperature elevation enhanced electrochemical reactions, resulting in higher cell voltage and power density, despite increased voltage losses. Augmenting the fuel utilization factor reduced voltage losses, leading to increased cell voltage and power density. The SOFC-ORC system efficiency peaked at 58.9% at the highest operating pressure, influenced by factors like compressor consumption and high fuel flow rate. Redirecting exhaust gas for waste heat recovery produced hot water, influencing the Coefficient of Performance (COP) of the LiBr absorption chiller. Mass flow rate had a smaller impact compared to hot water temperature. Exergy analysis revealed the SOFC's high efficiency (83.92%), while the steam turbine and LiBr absorption chiller demonstrated lower exergy efficiencies (70% and 32.6% respectively). Cost analysis indicated that the SOFC power plant was the most significant investment at 130,715 $, highlighting the long-term benefits of the integrated system in terms of high efficiency, low emissions, and fuel flexibility. This research offers a comprehensive assessment of the integrated SOFC-ORC-AC system, shedding light on its potential as an efficient and environmentally friendly energy generation solution. The study's findings contribute to the advancement of sustainable energy technologies, emphasizing the importance of trigeneration systems for future energy landscapes.

Evaluation of novel integrated combined cycle based on gas turbine-SOFC-geothermal-steam and organic Rankine cycles for gas turbo compressor station

Thermoeconomic analysis and multiobjective optimization of a combined gas turbine, steam, and organic Rankine cycle

Energy and Exergy Analyses of a Solid Oxide Fuel Cell-Gas Turbine-Organic Rankine Cycle Power Plant with Liquefied Natural Gas As Heat Sink

A 3E analysis of a multi‐power generation system employing CO2, LNG, and Organic Rankine cycles

Exergoeconomic Evaluation of a Cogeneration System Driven by a Natural Gas and Biomass Co-Firing Gas Turbine Combined with a Steam Rankine Cycle, Organic Rankine Cycle, and Absorption Chiller

An integrated energy storage system consisting of Compressed Carbon dioxide energy storage and Organic Rankine Cycle: Exergoeconomic evaluation and multi-objective optimization

Exergetic and economic evaluation of a novel integrated system for trigeneration of power, refrigeration and freshwater using energy recovery in natural gas pressure reduction stations

Working-fluid selection and thermoeconomic optimisation of a combined cycle cogeneration dual-loop organic Rankine cycle (ORC) system for solid oxide fuel cell (SOFC) waste-heat recovery

Exergy-economic Study and Multi-Objective Optimization of a Geothermal-Based Combined Organic Flash Cycle and PEMFC for Poly-Generation Purpose

Thermoeconomic Analysis of a Gas Turbine and Cascaded CO2 Combined Cycle Using Thermal Oil As an Intermediate Heat-Transfer Fluid

Exergoeconomic analysis of a novel trigeneration system containing supercritical CO2 Brayton cycle, organic Rankine cycle and absorption refrigeration cycle for gas turbine waste heat recovery

Comprehensive Energy Exergy Economic and Environmental Assessment of an Integrated Organic Rankine Cycle Solid Oxide Fuel Cell and Absorption Chiller System Fueled by Steam Reformed Natural Gas

An innovative hybrid system for the polygeneration of power, heat, and liquid carbon dioxide using solid oxide fuel cell/electrolyzer technology and oxyfuel power generation cycle

Exergo–Economic and Parametric Analysis of Waste Heat Recovery from Taji Gas Turbines Power Plant Using Rankine Cycle and Organic Rankine Cycle

Waste heat from a biomass fueled gas turbine for power generation via an ORC or compressor inlet cooling via an absorption refrigeration cycle: A thermoeconomic comparison

Exergoeconomic Analysis and Optimization of a Biomass Integrated Gasification Combined Cycle Based on Externally Fired Gas Turbine, Steam Rankine Cycle, Organic Rankine Cycle, and Absorption Refrigeration Cycle

Energy analysis and economic evaluation of a new developed integrated process configuration to produce power, hydrogen, and heat

Thermal Energy Recovery from a Brayton Cycle Nuclear Power Plant for Efficiency Improvement Via Compressor Inlet Cooling: Thermoeconomic Optimization

Exergo-Economic Study of SOFC-Intercooled and Reheat type GT-VARS-ORC Combined Power and Cooling System

Optimum Design and Thermodynamic Analysis of A Gas Turbine and Orc Combined Cycle with Recuperators

Off-design Behavior Investigation of the Combined Supercritical CO2 and Organic Rankine Cycle