Abstract:The inhomogeneity between cells is the main cause of failure and thermal runaway in Lithium-ion battery packs. Electrochemical Impedance Spectroscopy (EIS) is a non-destructive testing technique that can map the complex reaction processes inside the battery. It can detect and characterise battery anomalies and inconsistencies. This study proposes a method for detecting impedance inconsistencies in Lithium-ion batteries. The method involves conducting a battery EIS test and Distribution of Relaxation Times (DRT) analysis to extract characteristic frequency points in the full frequency band. These points are less affected by the State of Charge (SOC) and have a strong correlation with temperature, charge/discharge rate, and cycles. An anomaly detection characteristic impedance frequency of 136.2644 Hz was determined for a cell in a Lithium-ion battery pack. Single-frequency point impedance acquisition solves the problem of lengthy measurements and identification of anomalies throughout the frequency band. The experiment demonstrates a significant reduction in impedance measurement time, from 1.05 h to just 54 s. The LOF was used to identify anomalies in the EIS data at this characteristic frequency. The detection results were consistent with the actual conditions of the battery pack in the laboratory, which verifies the feasibility of this detection method. The LOF algorithm was chosen due to its superior performance in terms of FAR (False Alarm Rate), MAR (Missing Alarm Rate), and its fast anomaly identification time of only 0.1518 ms. The method does not involve complex mathematical models or parameter identification. This helps to achieve efficient anomaly identification and timely warning of single cells in the battery pack.

Discrete Wavelet Transform-Based Feature Extraction of Experimental Voltage Signal for Li-Ion Cell Consistency

SOC Estimation of Lithium-ion Battery Based on Dual Time Scale SVD-UKF Algorithm

Wavelet Based Denoising for the Estimation of the State of Charge for Lithium-Ion Batteries

SOH Estimation of Li-Ion Battery Using Discrete Wavelet Transform and Long Short-Term Memory Neural Network

A Kalman Filter SOC Estimation Method for Lithium-ion Batteries Based on Discrete Wavelet Transform Denoising

Wavelet Based Relative State of Health Estimation for Lithium-Ion Batteries

Fault Detection, Diagnosis, and Isolation Strategy in Li-Ion Battery Management Systems of HEVs Using 1-D Wavelet Signal Analysis

A Novel Intelligent Method for the State of Charge Estimation of Lithium-Ion Batteries Using a Discrete Wavelet Transform-Based Wavelet Neural Network

Remaining Useful Life Prediction of Lithium-ion Battery Based on Discrete Wavelet Transform

Health Factor Extraction of Lithium-Ion Batteries Based on Discrete Wavelet Transform and SOH Prediction Based on CatBoost

Bayesian impedance deconvolution using timescale distribution for lithium-ion battery state estimation

Enhanced Wavelet Transform Dynamic Attention Transformer Model for Recycled Lithium-Ion Battery Anomaly Detection

Intelligent Extraction of Salient Feature From Electroencephalogram Using Redundant Discrete Wavelet Transform

A Data‐Driven Method based on Discrete Wavelet Transform for online Li‐ion Battery State‐of‐Health Prediction and Monitoring

Convolutional autoencoder-based SOH estimation of lithium-ion batteries using electrochemical impedance spectroscopy

A new diagnostic indicator for lithium-ion batteries via electrochemical impedance spectroscopy: Harnessing the highest frequency peak in distribution of relaxation times

A Relative State of Health Estimation Method Based on Wavelet Analysis for Lithium-Ion Battery Cells.

A robust ultrasonic characterization methodology for lithium-ion batteries on frequency-domain damping analysis

Detection of Impedance Inhomogeneity in Lithium-Ion Battery Packs Based on Local Outlier Factor

Differential Voltage Analysis and Patterns in Parallel-Connected Pairs of Imbalanced Cells

Lithium-Ion Battery State of Health Estimation Using a Hybrid Model with Electrochemical Impedance Spectroscopy