Abstract:Summary Consolidated bioprocessing (CBP) is a convenient and cost‐efficient strategy to produce single cell oils ( SCOs ) from cellulose‐based substrates . In this study , Penicillium P‐2 having both effective cellulose degradation and lipid accumulation was isolated from 20 cellulolytic fungi . The SCOs of the strain P‐2 were mainly composed of palmitic acid ( C16 :0 , 21 .05% ) , oleic acid ( C18 :1 , 22 .43% ) and linoleic acid ( C18 :2 , 27 .78% ) . Fermentation experiments of the strain P‐2 showed that maximum lipid yields of 0 .65 g/L and 40 .13 mg/g ( per gram dry mass of initial solid substrate) could be obtained by submerged fermentation ( SmF) from cellulose and solid‐state fermentation (SSF) from wheat straw and bran mixture , respectively . The results from the two CBP indicated that the strain P‐2 had a potential to be a promising low‐cost oil producer using cellulose‐based substrates . The further analysis for lipid accumulation and cellulase secretion of the strain P‐2 suggested that the cellulase secretion of the strain P‐2 might play a key role in the lipid production . The submerged fermentation with exogenous cellulase addition by the strain P‐2 demonstrated that the higher exogenous cellulase dosages could lead to higher lipid production and the lipid yield would increase up to 0 .83 g/L with the addition of 24 IU /g cellulase . A highly significant positive correlation between the filter paper activity ( FPA) and the lipid yield in the strain P‐2 was further observed on the data pooled from the SSF parameter treatments ( P < 0 .01) . When the detected FPA in SSF system increased from 1 .0 IU /g to 3 .5 IU /g , the lipid yield was also increased from 26 .24 mg/g to 40 .13 mg/g with the increment of 52 .93% . All these analyses suggest that the weak cellulase secretion of the strain P‐2 is an important cause of the low lipid yield , so the regulation of endogenous cellulase secretion might be a feasible strategy for enhancing lipid production of the strain P‐2 .

Chitosan production by Penicillium citrinum using paper mill wastewater and rice straw hydrolysate as low-cost substrates in a continuous stirred tank reactor

Continuous degradation of chitosan in a convoluted fibrous bed bioreactor with immobilized trichoderma reesei

Studies on simultaneous production of chitosanase and chitosan degradation in situ with Trichoderma reesei in convoluted fibrous bed bioreactor]

[Chitosanase Production in Convoluted Fibrous Bed Bioreactor with Two-Step Process].

Extraction of Fungal Chitosan by Leveraging Pineapple Peel Substrate for Sustainable Biopolymer Production

Microbial extraction of chitin from seafood waste using sugars derived from fruit waste-stream

Key parameters optimization of chitosan production from Aspergillus terreus using apple waste extract as sole carbon source

Dual Extraction of Crustacean and Fungal Chitosan from a Single Mucor circinelloides Fermentation

Consolidated Bioprocessing Performance of Penicillium Sp P-2 in Cellulose-Based Substrates for Low-Cost Oil Production

Response Surface Methodology (RSM) Approach to Optimization of Coagulation-Flocculation of Aquaculture Wastewater Treatment Using Chitosan from Carapace of Giant Freshwater Prawn Macrobrachium rosenbergii

Extraction of chitin from flammulina velutipes waste: A low-concentration acid pretreatment and aspergillus Niger fermentation approach

Chitosan coagulant: coagulation/flocculation studies on turbidity removal from aquaculture wastewater by response surface methodology

Biodegradation kinetics of thin-stillage treatment by Aspergillus awamori and characterization of recovered chitosan

Green biorefinery of shrimp shell waste for α-chitin and high-value co-products through successive fermentation by co-lactic acid bacteria and proteolytic fungus

Sustainable and Effective Chitosan Production by Dimorphic Fungus Mucor rouxii via Replacing Yeast Extract with Fungal Extract

Isolation and screening of a chitin deacetylase producing Bacillus cereus and its potential for chitosan preparation

Pollutant removal from aquaculture wastewater using the biopolymer chitosan at different molecular weights.

Optimization of fungal chitosan production from Cunninghamella echinulata using statistical designs

Efficient Chitin Extraction from Shrimp Exoskeletons through Single-Step Fermentation by Pseudomonas aeruginosa QF50 and Serratia sp. QCS23

Optimization of lactic fermentation for extraction of chitin from freshwater shrimp waste

High Degree of Polymerization of Chitin Oligosaccharides Produced from Shrimp Shell Waste by Enrichment Microbiota Using Two-Stage Temperature-Controlled Technique of Inducing Enzyme Production and Metagenomic Analysis of Microbiota Succession