Microencapsulation of Bovine Vaginal Lactobacilli in Alginate Using Emulsion-gelation: Freeze-drying, Storage and Antimicrobial Activity

Ale CE,Torres Luque A,Gonzalez Moreno C

DOI: https://doi.org/10.4172/2155-9821.1000262

2015-01-01

Abstract:Microencapsulation of Bovine Vaginal Lactobacilli in Alginate UsingEmulsion-gelation: Freeze-drying, Storage and Antimicrobial Activity, Journal of Bioprocessing & Biotechniques.

What problem does this paper attempt to address?

Microencapsulation of Lactobacillus salivarious Li01 for enhanced storage viability and targeted delivery to gut microbiota

Mingfei Yao,Jiong Wu,Bo Li,Hang Xiao,David Julian McClements,Lanjuan Li

DOI: https://doi.org/10.1016/j.foodhyd.2017.05.033

IF: 10.7

2017-11-01

Food Hydrocolloids

Abstract:Probiotics are used in food products, dietary supplements and pharmaceutical products because they may provide health-promoting effects in humans. To be efficacious, probiotics need to be viable at sufficient abundance within the large intestine. However, many commercial products containing probiotics suffer from a substantial loss of bacterial viability during shelf storage and during gastrointestinal transit. In this study, a probiotic (Lactobacillus salivarious Li01) was incorporated into either alginate or alginate-gelatin microgels. The morphology of the microgels was characterized by scanning electron microscopy, which indicated that they had a spherical shape and that almost all of the bacterial cells were encapsulated inside them. Probiotic viability was determined under aerobic conditions, heat treatment, and simulated gastrointestinal conditions. Encapsulation significantly enhanced the viability of the probiotic during aerobic storage. The microgels maintained their structures under simulated gastric conditions, but either eroded or swelled under simulated small intestine conditions. The alginate-gelatin microgels were the most effective at protecting the bacteria under simulated gastrointestinal conditions when compared to the alginate microgels and non-encapsulated bacteria. In conclusion, alginate-gelatin microgels have great potential for the protection and delivery of probiotics in food, supplement, and pharmaceutical products.

food science & technology,chemistry, applied
Microencapsulated Lactobacillus acidophilus FNCC 0051 and Streptococcus thermophilus FNCC 0040 Technique Emulsion Using Gelatin and Sodium Alginate

Devia Wulandasari,Khothibul Umam Al Awwaly,Abdul Manab

DOI: https://doi.org/10.9734/afsj/2022/v21i430420

2022-04-08

Asian Food Science Journal

Abstract:The research was held from September 2021 until January 2022 in Laboratory Livestock Product Technology Universitas Brawijaya, Malang, Indonesia. Microencapsulation is a technique used to protect bacteria from harmful (extreme) environmental factors such as heating, freezing and low pH through a coating process or coating a core substance in this case LAB with a polymer wall layer. The purpose of this study was to obtain a combination of the use of gelatin and sodium alginate as a coating material in the encapsulation of Lactobacillus acidophilus FNCC 0051 and Streptococcus thermophilus FNCC 0040 using the emulsion technique based on its physical and microbiological properties. The research method used is a laboratory experiment using a completely randomized design (CRD) pattern with 3 treatments and 3 replications. The treatment using a combination of gelatin and sodium alginate consisted of T1 (1:1); T2 (1:2); T3 (1:3). Data were processed by Analysis of Variance (ANOVA); If the analysis happens to show a significant difference (P<0.05) or a very highly significant difference (P<0.01), then the Duncan's Multiple Range Test was applied. Data from the results of microstructure testing using Scanning Electron Microscopy which were qualitative were analyzed descriptively. The results of the analysis show that encapsulation using a combination of gelatin and sodium alginate gives a very significant difference (P 0.05) on microcapsule particle size and microcapsule particle size distribution, with percentages T1 97.43±0.31%, T2 98.50±0.48%, T3 99.00±0.44 %; T1 1.08±0.07 μm; T2 1.18±0.11 μm; T3 0.95±0.11μm; and T1 4.79±1.04; T2 2.53±2.16; T3 4.15±3.13 and microcapsules using SEM showed the microcapsules were round and smooth. The combination of gelatin and sodium alginate T3 (1:3) as a microcapsule material is a good alternative to protect lactic acid bacteria so that it can be applied in food products functional.
Extending viability of Lactobacillus plantarum and Lactobacillus johnsonii by microencapsulation in alginate microgels

Kendra A Tiani,Timothy W Yeung,D Julian McClements,David A Sela

DOI: https://doi.org/10.1080/09637486.2017.1343285

Abstract:Aim: To investigate whether microencapsulation of Lactobacillus in alginate microbeads will lead to increased longevity during refrigerated storage or simulated digestion. Materials and methods: Microscopy was used to confirm that Lactobacillus plantarum ATCC BAA-793 and Lactobacillus johnsonii ATCC 33200 were immobilised within the microbeads and laser scattering analysis was used to determine the mean diameter of the microbeads. The number of viable cells were enumerated throughout refrigerated storage and simulated digestion experiments. Results: Microencapsulation was shown to have differing effects on viability depending on the species, but led to extended viability during refrigerated storage and simulated digestion in L. johnsonii and L. plantarum respectively. Conclusion: Fermented functional foods contain microbes beneficial to human health. However, extended shelf storage and the harsh environment of the GI tract significantly reduces the number of viable microbes reaching the consumer. Microencapsulation allows beneficial microbes to reach the gut of the consumer in higher numbers, and thus confer greater health benefits.
Solving the delivery of Lactococcus lactis: Improved survival and storage stability through the bioencapsulation with different carriers

Diego Dusso,Claudio J Salomon

DOI: https://doi.org/10.1111/1750-3841.16538

Abstract:Probiotics are live microorganisms that confer beneficial effects on the health of the host if administered in adequate amounts (106 CFU viable microorganisms/g of food). As the most frequent route of administration of these microorganisms is oral, the number of them that remains viable through the gastrointestinal tract decreases substantially. Thus, in this research work, we developed a series of alginate-based microparticles using different adjuvants such as methylcellulose, carboxymethylcellulose, chitosan, carbopol, β-cyclodextrin, starch, carrageenan, and Eudragit® RS 100 as carriers for improving the survival of Lactococcus lactis. The alginate-based formulations exhibited very good drug encapsulation efficiency, up to 90%. Release studies from selected microparticles revealed that almost 100% of bacteria were in solution at 30 min. By scanning electron microscopy, irregular nonporous particles with a size between 200 and 500 µm were seen. In particular, microparticles formulated with alginate-carboxymethylcellulose and alginate-methylcellulose exhibited the best protection for the bacterial cells against both simulated gastric juice and simulated intestinal juice. In addition, those microparticulate systems were able to maintain the viability of the encapsulated bacteria in large numbers for at least 24 weeks. Thus, the present study confirmed that these alginate-based microparticles are a valuable approach for keeping the viability and storage stability of L. lactis.
Viability dataset on microencapsulated probiotics: Sodium alginate viscosity effect

Araceli Olivares,Paulina Silva

DOI: https://doi.org/10.1016/j.dib.2019.104735

2019-11-02

Abstract:Probiotics must be delivered alive to exert a positive health effects in site of action. But, they must survive different extreme condition through intestinal tract. Microencapsulation techniques have received considerable attention and facilitate a suitable carrier system to reach the target site. The encapsulation techniques applied to probiotics can be classified into two groups, depending on the method used to form the beads: extrusion (droplet method) and emulsion or two-phase system [1], where extrusion is evolved in the vibration technology and in particular, when the wavelength of an asymmetric disturbance exceeds the jet circumference, the break-up occurs. Droplet size depends on nozzle (jet) diameter, viscosity of fluid, surface tension, jet velocity and frequency of disturbance [2,3]. The data presented in this article evaluated the performance of microencapsulated Lactobacillus casei (probiotic bacteria) using vibration technology and using two kinds of sodium alginate gel matrix (low and medium viscosity) and compare the effect over viability. The best conditions for higher viability of probiotics were at a concentration of sodium alginate (medium viscosity) at 2%, with a nozzle of 450 μm and a frequency of 1000 Hz. The data are related to the research article entitled "Microencapsulation of probiotics by efficient vibration technology" [3], where Microencapsulator provide by BÜCHI (Encapsulated B-390) was used.
Properties and stability of Lactiplantibacillus plantarum AB6-25 and Saccharomyces boulardii T8-3C single and double-layered microcapsules containing Na-alginate and/or demineralized whey powder with lactobionic acid

Oğuzhan Gedik,Aynur Gül Karahan

DOI: https://doi.org/10.1016/j.ijbiomac.2024.132406

Abstract:The present study aimed to enhance the survivability of the encapsulated biocomposites of Lactiplantibacillus plantarum AB6-25 and Saccharomyces boulardii T8-3C within the gastrointestinal system (GIS) and during storage period. AB6-25 and T8-3C were individually co-encapsulated using either lactobionic acid (LBA) in Na-alginate (ALG)/demineralized whey powder (DWP) or solely potential probiotics in ALG microcapsules. Free probiotic cells were utilized as the control group. Both microcapsules and free cells underwent freeze-drying. The encapsulation and freeze-drying efficiency of core materials were evaluated. The protective effect of encapsulation on the probiotics was examined under simulated GIS conditions and during storage at either 25 °C or 4 °C. Additionally, the microcapsules underwent analysis using fourier transform infrared (FTIR) spectroscopy, X-ray diffraction (XRD), and scanning electron microscope (SEM). Encapsulation and freeze-drying processes were carried out efficiently in all groups (88.46 %-99.13 %). SEM revealed that the microcapsules possessed a spherical and homogeneous structure, with sizes ranging from 3 to 10 μm. ALG/DWP and LBA presence in the microcapsule structure was confirmed through FTIR, XRD analysis indicated the formation of a new composite. Over 180 days, all microcapsule groups stored at 4 °C maintained their therapeutic dosage viability. However, after four months, microcapsules stored at 25 °C exhibited a decline in yeast survivability below the therapeutic threshold. Experimental groups demonstrated better viability under simulated GIS conditions compared to the control. These findings suggest the potential use of microencapsulated probiotics as a food supplement and indicate that microcapsule groups containing AB6-25 and T8-3C stored at 4 °C can be preserved for six months.
Encapsulation of Lactobacillus plantarum ATCC 8014 and Pediococcus acidilactici ATCC 8042 in a freeze-dried alginate-gum arabic system and its in vitro testing under gastrointestinal conditions

I Sandoval-Mosqueda,A Llorente-Bousquets,J F Montiel-Sosa,L Corona,Z Guadarrama-Álvarez

DOI: https://doi.org/10.1080/02652048.2019.1660729

Abstract:The aim of this study was to investigate the viability of Pediococcus acidilactici ATCC 8042 and Lactobacillus plantarum ATCC 8014 in a freeze-dried capsules system prepared with sodium alginate and gum arabic using the extrusion technique. The capsules made with alginate 2% (w/v)/gum arabic 2% (w/v) showed higher hardness (7.12 ± 0.71 N), with highly cohesive (0.81 ± 0.02) and elastic (0.99 ± 0.00) features on the Texture Profile Analysis (TPA), as well as higher sphericity with 1.75 ± 0.12 mm y 1.73 ± 0.13 mm diameter axes and regularity in their surface by Scanning Electron Microscopy (SEM). The use of skimmed milk at 10% as a cryoprotector in the freeze-drying process allowed the obtention of high viability percentages (88% a 96%) for both strains. Best results of viability for P. acidilactici encapsulated was with the use of alginate 2% (w/v)/gum arabic 2% (w/v) (92%±2.65), and L. plantarum with the use of alginate 2% (w/v) (84.71%±10.33) during the gastrointestinal environment challenge.
Membrane Emulsification as an Emerging Method for Lacticaseibacillus rhamnosus GG® Encapsulation

Callebe Camelo-Silva,Lais Leite Figueredo,Karina Cesca,Silvani Verruck,Alan Ambrosi,Marco Di Luccio

DOI: https://doi.org/10.1007/s11947-023-03099-w

2023-04-21

Abstract:Techniques capable of producing small-sized probiotic microcapsules with high encapsulation yields are of industrial and scientific interest. In this study, an innovative membrane emulsification system was investigated in the production of microcapsules containing Lacticaseibacillus rhamnosus GG® (Lr), sodium alginate (ALG), and whey protein (WPI), rice protein (RPC), or pea protein (PPC) as encapsulating agents. The microcapsules were characterized by particle size distribution, optical microscopy, encapsulation yield, morphology, water activity, hygroscopicity, thermal properties, Fourier-transform infrared spectroscopy (FTIR), and probiotic survival during in vitro simulation of gastrointestinal conditions. The innovative encapsulation technique resulted in microcapsules with diameters varying between 18 and 29 μm, and encapsulation yields > 93%. Combining alginate and whey, rice, or pea protein improved encapsulation efficiency and thermal properties. The encapsulation provided resistance to gastrointestinal fluids, resulting in high probiotic viability at the end of the intestinal phase (> 7.18 log CFU g-1). The proposed encapsulation technology represents an attractive alternative to developing probiotic microcapsules for future food applications. Supplementary information: The online version contains supplementary material available at 10.1007/s11947-023-03099-w.
Alginate/Fish Gelatin-Encapsulated Lactobacillus acidophilus: A Study on Viability and Technological Quality of Bread during Baking and Storage

Milad Hadidi,Nava Majidiyan,Aniseh Zarei Jelyani,Andrés Moreno,Zahra Hadian,Amin Mousavi Khanegah

DOI: https://doi.org/10.3390/foods10092215

IF: 5.2

2021-09-18

Foods

Abstract:In the present study, Lactobacillus acidophilus LA-5 was microencapsulated in sodium alginate, followed by fish gelatin coating (0.5, 1.5, and 3%). The survival of L. acidophilus in bread before and after encapsulation in alginate/fish gelatin during the baking and 7-day storage was investigated. Moreover, the effect of alginate/fish gelatin-encapsulated L. acidophilus on the technological properties of bread (hardness, staling rate, water content, oven spring, specific volume, and internal texture structure) was evaluated. Compared with control (free bacteria), encapsulated L. acidophilus in alginate/fish gelatin showed an increase in the viability of bread until 2.49 and 3.07 log CFU/g during baking and storage, respectively. Good viability of (106 CFU/g) for probiotic in encapsulated L. acidophilus in alginate/fish gelatin (1.5 and 3%, respectively) after 4-day storage was achieved. Fish gelatin as a second-layer carrier of the bacteria had a positive effect on improving the technical quality of bread. Furthermore, the staling rate of bread containing encapsulated L. acidophilus alginate/fish gelatin 0.5, 1.5, and 3% decreased by 19.5, 25.8, and 31.7%, respectively. Overall, the findings suggested encapsulation of L. acidophilus in alginate/fish gelatin capsule had great potential to improve probiotic bacteria’s survival during baking and storage and to serve as an effective bread enhancer.

food science & technology
Microencapsulation of Lactobacillus acidophilus LA‐5 and Bifidobacterium animalis BB‐12 in pectin and sodium alginate: A comparative study on viability, stability, and structure

Zahra Motalebi Moghanjougi,Mahmoud Rezazadeh Bari,Mohammad Alizadeh Khaledabad,Saber Amiri,Hadi Almasi

DOI: https://doi.org/10.1002/fsn3.2470

2021-07-20

Abstract:The present study aimed at examining whether the microencapsulation of Lactobacillus acidophilus LA-5 and Bifidobacterium animalis BB-12 inside hydrogels could prolong their survival in freeze-drying conditions, stored at 4℃ and in the gastrointestinal medium. Microencapsulation was performed by emulsion with a syringe, while sodium alginate and high methoxyl pectin were used as a carrier material. A relatively high efficiency of encapsulation was obtained (>92%). Z-Average and pdI in samples were not significant (p < .05). In different treatments, changes in the number of bacteria after freeze-drying, 30 days of storage, and gastrointestinal conditions, compared to each other, were significant (p < .05). However, the survival rate after a reduction during storage was higher than 106 cfu/g, indicating the suitability of the microencapsulation process. The surface of microcapsules observed by a scanning electron microscope (SEM) confirmed the success of encapsulation. Finally, a lower decrease in the count of microencapsulated was observed in comparison to the free cells.

food science & technology
Preparation and Properties of a Novel Sodium Alginate Microcapsule

Zhenyan Liu,Xue Chen,Hao Guo

DOI: https://doi.org/10.1088/1742-6596/1893/1/012005

2021-04-01

Journal of Physics: Conference Series

Abstract:Abstract In this study, sodium alginate was used as the main embedding material, and sodium polyacrylate had been immobilized on sodium alginate with calcium ions as crosslinking agent for preparing a new type of lactic acid bacteria entrapment material. The aim of this study was to investigate the viability of Lactococcus lactis NCU1315 under simulated gastrointestinal conditions and the physical properties of the microcapsules and their protective effects on Lactobacillusto develop a feasible and stable method for preparing microbial particles. The hardness of Alg-1 and Alg-2 microcapsules varied with time in simulated gastric juice and showed significant difference at the second and third hour (P < 0.05, P < 0.01). The particle size of Alg-1 and Alg-2 microcapsules varied with time in simulated gastric juice and showed significant difference at the second and third hour (P < 0.05, P < 0.01). Alg-1 had no significant effect on the growth of NCU1315 , but Alg-2 had inhibitory effect on the growth of Lactococcus lactis NCU1315 . The survival rate of Lactococcus lactis in Alg-1 and Alg-2 microencapsulated groups was significantly higher than that in Free cell group at 24h, 48h and 72h (P < 0.05, P < 0.01). However, the survival rate of Lactococcus lactis in Alg-1 and Alg-2 microencapsulated groups decreased with time (P<0.05, P<0.01).
The Viability of Lactobacillus rhamnosus GG and Lactobacillus acidophilus NCFM Following Double Encapsulation in Alginate and Maltodextrin

Asma Sohail,Mark S. Turner,Allan Coombes,Bhesh Bhandari

DOI: https://doi.org/10.1007/s11947-012-0938-y

2012-07-25

Food and Bioprocess Technology

Abstract:Lactobacillus rhamnosus GG (LGG) and Lactobacillus acidophilus NCFM (LNCFM) were encapsulated in alginate microgel particles (microbeads) by a novel dual aerosols method. The encapsulated probiotics in microbead gel matrix were further stabilized in maltodextrin solids by either spray or freeze-drying to form probiotic microcapsule powders. The free cells of probiotics were also sprayed and freeze-dried in maltodextrin only without microgel encapsulation. After rehydration of microgel-encapsulated powder, gel particles regained their shape. There was no difference in the loss of viability between encapsulated and unencapsulated probiotics during spray drying or freeze-drying. For LNCFM, spray-dried bacteria with or without gel encapsulation exhibited less death (3.03 and 3.07 log CFU/g reduction, respectively) than those of freeze-dried bacteria (4.36 and 4.89 log CFU/g reduction, respectively) after 6 months storage at 4 °C. The same trend was also observed in spray-dried LGG without gel encapsulation which showed 5.87 log CFU/g reduction in viability after 6 months at 4 °C; however, freeze-dried LGG without gel encapsulation exhibited a rapid reduction in viability of 5.91 log CFU/g within just 2 months. Gel-encapsulated LGG which was freeze-dried exhibited less death (3.32 log CFU/g reduction) after 6 months at 4 °C. This work shows that spray drying results in improved subsequent probiotic survivability compared to freeze-drying and that alginate gel encapsulation can improve the survivability following freeze-drying in a probiotic-dependent manner.

food science & technology
Co-encapsulation of lactic acid bacteria and prebiotic with alginate-fenugreek gum-locust bean gum matrix: Viability of encapsulated bacteria under simulated gastrointestinal condition and during storage time

Karthiyaini Damodharan,Sasikumar Arunachalam Palaniyandi,Seung Hwan Yang,Joo Won Suh

DOI: https://doi.org/10.1007/s12257-017-0096-1

IF: 3.386

2017-06-01

Biotechnology and Bioprocess Engineering

Abstract:The aim of this study was to enhance the viability of probiotic strains Pediococcus pentosaceus KID7, Lactobacillus plantarum KII2, Lactobacillus fermentum KLAB6 and Lactobacillus helveticus KII13 in gastrointestinal transit, freeze-drying condition and during storage time by microencapsulation using a combination of alginate, fenugreek gum and locust bean gum. The microcapsules were prepared using various ratio of alginate to fenugreek gum to locust bean gum and tested for its dissolution in colonic fluid. The combination that efficiently dissolved in colonic fluid was selected for co-encapsulation of the probiotic strains and prebiotics to produce synbiotic microcapsules. Further, we observed that the bacteria encapsulated with alginate-fenugreek gum-locust bean gum (AFL) matrix tolerated gastrointestinal condition efficiently compared to non-encapsulated bacteria. The encapsulated bacterial cells retained higher viability than non-encapsulated cells during freeze-drying condition and subsequent storage for 3 months at 4°C. These results show the utility of AFL matrix in microencapsulation of probiotics for use in food industry.

biotechnology & applied microbiology
Microencapsulation of Lacticaseibacillus rhamnosus GG for Oral Delivery of Bovine Lactoferrin: Study of Encapsulation Stability, Cell Viability, and Drug Release

Yasir Anwar,Ihsan Ullah,Tahseen Kamal,Muhammad Wajid Ullah

DOI: https://doi.org/10.3390/biomimetics7040152

2022-10-04

Biomimetics

Abstract:Probiotics are delivered orally for treating gastrointestinal tract (GIT) infections; thus, they should be protected from the harsh environment of the GIT, such as through microencapsulation. Here, we microencapsulated cells of the probiotic Lacticaseibacillus rhamnosus GG via the liquid-droplet-forming method and evaluated them for oral delivery of bovine lactoferrin (bLf). Briefly, sodium alginate capsules (G-capsules) were first prepared, crosslinked with calcium chloride (C-capsules), and then modified with disodium hydrogen phosphate (M-capsules). All capsules showed good swelling behavior in the order of G-capsules > C-capsules > M-capsules in simulated gastric fluid (SGF, pH 2) and simulated intestinal fluid (SIF, pH 7.2). FE-SEM observations showed the formation of porous surfaces and successful microencapsulation of L. rhamnosus GG cells. The microencapsulated probiotics showed 85% and 77% viability in SGF and SIF, respectively, after 300 min. Compared to the 65% and 70% viability of gelation-encapsulated and crosslinking-encapsulated L. rhamnosus GG cells, respectively, the mineralization-encapsulated cells showed up to 85% viability after 300 min in SIF. The entrapment of bLf in the mineralization-encapsulated L. rhamnosus GG cells did not show any toxicity to the cells. FTIR spectroscopy confirmed the successful surface modification of L. rhamnosus GG cells via gelation, crosslinking, and mineralization, along with the entrapment of bLf on the surface of microencapsulated cells. The findings of these studies show that the microencapsulated L. rhamnosus GG cells with natural polyelectrolytes could be used as stable carriers for the oral and sustainable delivery of beneficial biotherapeutics without compromising their viability and the activity of probiotics.
An in vitro gastrointestinal model to evaluate the tolerance of encapsulated Lactobacillus and Lactococcus strains with synbiotic containing lactobionic acid via lyophilization technique to harsh gastric conditions during storage time

Kamila Goderska,Sonia Agudo Pena

DOI: https://doi.org/10.1016/j.ejpb.2023.11.012

Abstract:Probiotics are living microorganisms that have potential health benefits for the host when administered in the correct proportions. However, for these beneficial effects to be produced, viable probiotic cells need to reach the human intestine. This study used a gastrointestinal model to represent the pH variation and gastric enzymes that are involved in the digestion process. Eight Lactobacillus strains and one Lactococcus strain were encapsulated using sodium alginate. The aim of this study was to compare free probiotic bacteria with encapsulated probiotic bacteria and determine the number of viable probiotic cells that might reach the human intestine. Microencapsulation of probiotic organisms followed the extrusion method with an alginate compound. Microencapsulated and free probiotic bacteria were inoculated into 200 ml of MRS (Man, Rogosa, Sharpe) broth. Simulated gastric juice and bile and pancreatic salt were used to test the tolerance of free Lactobacillus and Lactococcus species and microencapsulated bacteria to acid pH and enzymes. To enumerate the microencapsulated probiotic organisms, the bacteria were released from the capsules after total digestion with sodium citrate solution. The number of live bacteria (as CFU/g) was determined using the plate count method on MRS plates incubated at 37 °C for 48 h. Bacterial cell viability was determined on MRS agar duplicate plates at different dilutions. The results indicated that microencapsulation of probiotic bacteria showed improved viability over free cells when given 2 h of exposure to acidic conditions, and also for 2 h of exposure to bile and pancreatic salt. Encapsulation with alginate can protect probiotic bacteria from acidic conditions and bile salts. This study attempted also to produce synbiotic preparations with lactobionic acid using nontoxic encapsulating substances. The microorganisms used were stabilized with protective substances, and their stability during storage was checked under room temperature conditions. The final modification of the method, involving placing the capsules in a solution of skimmed milk with 5 % sucrose and 0.35 % ascorbic acid, resulted in an increase in the survival rate of some strains of microorganisms during microencapsulation and lyophilization and demonstrated stability during storage at room temperature.
Encapsulation of bifidobacterium in alginate microgels improves viability and targeted gut release

Zipei Zhang,Min Gu,Xiaomeng You,David A. Sela,Hang Xiao,David Julian McClements

DOI: https://doi.org/10.1016/j.foodhyd.2021.106634

IF: 10.7

2021-07-01

Food Hydrocolloids

Abstract:Biopolymer microgels were designed to encapsulate and protect probiotics during storage and passage through the upper human gastrointestinal tract (GIT), but then release them in the colon. An anaerobic probiotic strain (Bifidobacterium pseudocatenulatum G7; BPG7) was encapsulated within calcium alginate microgels. In some cases, either colloidal antacid (CaCO3) or colloidal antacid and nanoemulsion (nE) lipid droplets were co-encapsulated with the probiotics. These additives were used to control the porosity and/or internal pH of the microgels. Initially, the viability of free and encapsulated probiotics was evaluated when they.Encapsulation greatly improved the stability of the probiotics, with the effectiveness depending on the formulation: antacid-microgels > control microgels > antacid-nE-microgels. These effects were mainly attributed to the ability of the colloidal CaCO3 particles to inhibit molecular diffusion processes. The ability of the microgels to protect the probiotics under simulated gastrointestinal tract (GIT) conditions was then assessed. The free probiotics were completely inactivated when exposed to gastric and small intestine conditions. In contrast, the antacid- and antacid-nE-microgels were highly effective at improving the viability of the probiotics during passage through the upper GIT. Moreover, these microgels were fermented under simulated colonic conditions, thereby releasing the probiotics. These results suggest that antacid-loaded calcium alginate microgels can be used for the encapsulation, protection, and colonic delivery of probiotics. Nevertheless, further studies are required using in vivo models.

food science & technology,chemistry, applied
Extending Viability of Bifidobacterium longum in Chitosan-Coated Alginate Microcapsules Using Emulsification and Internal Gelation Encapsulation Technology

Rui Ji,Jiahui Wu,Junliang Zhang,Tao Wang,Xudong Zhang,Lei Shao,Daijie Chen,Jian Wang

DOI: https://doi.org/10.3389/fmicb.2019.01389

2019-06-28

Abstract:Bifidobacteria are considered one of the most important intestinal probiotics because of their significant health impact. However, this ability is usually limited by gastrointestinal fluid and temperature sensitivity. Emulsification and internal gelation is an encapsulation technique with great potential for probiotic protection during storage and the gastrointestinal transit process. This study prepared microcapsules using an emulsification and internal gelation encapsulation method with sodium alginate, chitosan, and Bifidobacterium longum as wall material, coating material, and experimental strain, respectively. Optical, scanning electron, and focal microscopes were used to observe the microcapsule surface morphology and internal viable cell distribution, and a laser particle size analyzer and zeta potentiometer were used to evaluate the chitosan-coating characteristics. In addition, microcapsule probiotic viability after storage, heat treatment, and simulated gastrointestinal fluid treatment were examined. Alginate microcapsules and chitosan-coated alginate microcapsules both had balling properties and uniform bacterial distribution. The latter kept its balling properties after freeze-drying, verified by scanning electronic microscopy (SEM), and had a clear external coating, observed by an optical microscope. The particle size of chitosan-coated alginate microcapsules was slightly larger than the uncoated microcapsules. The zeta potential of alginate and chitosan-coated alginate microcapsules was negative and positive, respectively. Heat, acid and bile salt tolerance, and stability tests revealed that the decrease of viable cells in the chitosan-coated alginate microcapsule group was significantly lower than that in uncoated microcapsules. These experimental results indicate that the chitosan-coated alginate microcapsules protect B. longum from gastrointestinal fluid and high-temperature conditions.
Evaluation of Microencapsulation of The UFV-AREG1 Bacteriophage in Alginate-Ca Microcapsules using Microfluidic Devices

Delaine M. G. Boggionea,Laís S. Batalha,Marco T. P. Gontijo,Maryoris E. S. Lopez,Alvaro V. N. C. Teixeira,Igor J. B. Santos,Regina C. S. Mendonça

DOI: https://doi.org/10.48550/arXiv.1707.05621

2017-07-06

Other Quantitative Biology

Abstract:The indiscriminate use of antibiotics and the emergence of resistant microorganisms have become a major challenge for the food industry. The purpose of this work was to microencapsulate the bacteriophage UFV-AREG1 in a calcium alginate matrix using microfluidic devices and to study the viability and efficiency of retention. The microcapsules were added to gel of propylene glycol for use as an antimicrobial in the food industry. The technique showed the number of the phage encapsulation, yielding drops with an average 100-250 $\mu$m of diameter, 82.1 $\pm$ 2% retention efficiency and stability in the gel matrix for 21 days. The gel added to the microencapsulated phage showed efficiency (not detectable on the surface) in reducing bacterial contamination on the surface at a similar level to antimicrobial chemicals (alcohol 70%). Therefore, it was possible to microencapsulate bacteriophages in alginate-Ca and apply the microcapsules in gels for use as sanitizers in the food industry.
Enhancing Viability of Lactobacillus Plantarum Encapsulated by Alginate-Gelatin Hydrogel Beads During Gastrointestinal Digestion, Storage and in the Mimic Beverage Systems

Fangfang Ni,Xin Luo,Zhu Zhao,Jingwang Yuan,Yuling Song,Chengzhi Liu,Min Huang,Lijuan Dong,Hujun Xie,Lei Cai,Gerui Ren,Qing Gu

DOI: https://doi.org/10.1016/j.ijbiomac.2022.10.106

IF: 8.2

2022-01-01

International Journal of Biological Macromolecules

Abstract:To improve the viability of Lactobacillus plantarum (P) during digestion and storage, the probiotics were encapsulated by alginate (ALG) and alginate-gelatin (ALG-GE) hydrogels beads. ALG-P-GE showed much better physicochemical properties than ALG-P. The scanning electron microscopy (SEM) results validated the incor-poration of bacterial cells into the beads. ALG-P-GE exhibited good encapsulation efficiency of 97.7 %, and the storage and thermal stability of probiotic were increased by 15 % and 8 %, respectively, when comparing with ALG-P. ALG-P-GE beads could protect the probiotics from inactivation in simulated gastric fluid and then release it in simulated intestinal fluid. The protective mechanism of ALG-GE for probiotics was further studied by fourier transform infrared spectroscopy (FTIR), X-ray diffraction (XRD) and found that ALG and GE can form gel network through hydrogen bonding and electrostatic interactions. In the mimic beverage systems, ALG-P-GE beads could protect the encapsulated probiotics and increase its viability. The storage, thermal, and digestion stability of encapsulated probiotic were significantly increased and showed high viability in the mimic beverage systems. ALG-P-GE beads have great potential for the protection and delivery of probiotics in food systems.
Microencapsulation of probiotics by efficient vibration technology

Araceli Olivares,Paulina Silva,Claudia Altamirano

DOI: https://doi.org/10.1080/02652048.2017.1390005

2017-10-03

Journal of Microencapsulation

Abstract:The target site of action of probiotics is the intestine. They must be surviving the stomach acidic condition before reaching the target site. Three probiotic bacteria were microencapsulated in sodium alginate beads using a sophisticated microencapsulation technology provided by BÜCHI B-390. This study reports the tolerance of the different microencapsulated Lactobacillus at low pH using simulated gastric juice, comparing it with the tolerance of free bacteria. The three microencapsulated strains displayed time-dependent acid sensitivity at pH values under 3.0. At pH 2.0, a dramatic reduction in bacterial survival occurred after 5 min, with only L. casei surviving after 30 min, with 75% survival. At pH 2.5 microencapsulated L. casei survived for 90 , L. reuteri survived for 60 and L. bulgaricus survived for only 30 min, respectively. The microencapsulation technology used in this study may effectively protect Lactobacillus from gastric conditions and permit comparisons between strains.

pharmacology & pharmacy,chemistry, applied,engineering, chemical

Microencapsulation of Bovine Vaginal Lactobacilli in Alginate Using Emulsion-gelation: Freeze-drying, Storage and Antimicrobial Activity

Microencapsulation of Lactobacillus salivarious Li01 for enhanced storage viability and targeted delivery to gut microbiota

Microencapsulated Lactobacillus acidophilus FNCC 0051 and Streptococcus thermophilus FNCC 0040 Technique Emulsion Using Gelatin and Sodium Alginate

Extending viability of Lactobacillus plantarum and Lactobacillus johnsonii by microencapsulation in alginate microgels

Solving the delivery of Lactococcus lactis: Improved survival and storage stability through the bioencapsulation with different carriers

Viability dataset on microencapsulated probiotics: Sodium alginate viscosity effect

Properties and stability of Lactiplantibacillus plantarum AB6-25 and Saccharomyces boulardii T8-3C single and double-layered microcapsules containing Na-alginate and/or demineralized whey powder with lactobionic acid

Encapsulation of Lactobacillus plantarum ATCC 8014 and Pediococcus acidilactici ATCC 8042 in a freeze-dried alginate-gum arabic system and its in vitro testing under gastrointestinal conditions

Membrane Emulsification as an Emerging Method for Lacticaseibacillus rhamnosus GG® Encapsulation

Alginate/Fish Gelatin-Encapsulated Lactobacillus acidophilus: A Study on Viability and Technological Quality of Bread during Baking and Storage

Microencapsulation of Lactobacillus acidophilus LA‐5 and Bifidobacterium animalis BB‐12 in pectin and sodium alginate: A comparative study on viability, stability, and structure

Preparation and Properties of a Novel Sodium Alginate Microcapsule

The Viability of Lactobacillus rhamnosus GG and Lactobacillus acidophilus NCFM Following Double Encapsulation in Alginate and Maltodextrin

Co-encapsulation of lactic acid bacteria and prebiotic with alginate-fenugreek gum-locust bean gum matrix: Viability of encapsulated bacteria under simulated gastrointestinal condition and during storage time

Microencapsulation of Lacticaseibacillus rhamnosus GG for Oral Delivery of Bovine Lactoferrin: Study of Encapsulation Stability, Cell Viability, and Drug Release

An in vitro gastrointestinal model to evaluate the tolerance of encapsulated Lactobacillus and Lactococcus strains with synbiotic containing lactobionic acid via lyophilization technique to harsh gastric conditions during storage time

Encapsulation of bifidobacterium in alginate microgels improves viability and targeted gut release

Extending Viability of Bifidobacterium longum in Chitosan-Coated Alginate Microcapsules Using Emulsification and Internal Gelation Encapsulation Technology

Evaluation of Microencapsulation of The UFV-AREG1 Bacteriophage in Alginate-Ca Microcapsules using Microfluidic Devices

Enhancing Viability of Lactobacillus Plantarum Encapsulated by Alginate-Gelatin Hydrogel Beads During Gastrointestinal Digestion, Storage and in the Mimic Beverage Systems

Microencapsulation of probiotics by efficient vibration technology