Abstract:For the existing tracking control schemes of flexible-joint robots, precise sensor measurement is an implicit premise. However, idealized sensors are difficult to achieve due to manufacturing technology or other external factors. To this end, this paper further investigates the tracking control problem for flexible-joint robots with unknown measurement sensitivity. Specifically, for such multi-input multi-output Euler-Lagrange systems with completely unknown system dynamics, a novel measurement values-based adaptive control method is proposed by fusing sensitivity information and system variables into Lyapunov function candidates, where the restriction on system states in other the approximation lemma-based results is removed, since unknown nonlinearities are scaled by the structural characteristics of system variables. Above all, even if there are measurement errors, satisfactory tracking performance can be obtained by adjusting the design parameters, which is proved by rigorous theoretical analysis. Finally, hardware experiments further verify the effectiveness of the proposed method. Note to Practitioners—This work is motivated by the trajectory tracking control problem for flexible-joint robots under imprecise sensor measurements. Due to manufacturing technology limitations and component aging, there is inevitably a deviation between the measured values of sensors and real values, and this problem may become more prominent as the working environment of flexible-joint robots tends to become more complex. To our knowledge, most of the existing solutions for flexible-joint robots are developed based on precise sensor measurements, and they may fail to achieve satisfactory performance when real state information is not available. Moreover, the prior knowledge about model parameters and measurement sensitivity is difficult or impossible to exactly obtain in practice, which seriously hinders the further application of control methods that are dependent on system dynamics. To this end, this paper proposes a novel tracking control scheme based on measurement information for flexible-joint robots with unknown measurement sensitivity, where the dependence on model information is eliminated with the elaborately constructed Lyapunov function candidates, and the real tracking error is still adjusted to an acceptable range even if there are measurement errors. Preliminary experiments on a flexible-joint robot developed by Quanser company demonstrate the feasibility and effectiveness of the proposed method. In future studies, designing an effective scheme to achieve direct preset tracking control is the focus of the work.

Tracking control via switching and learning for a class of uncertain flexible joint robots with variable stiffness actuators

Continuous Robust Tracking Controllers for a Class of Uncertain Nonlinear Dynamical Systems

Tracking Control Simulation of Pneumatic Muscle Actuator Joint Using Saturated Adaptive Robust Controller

Variable Stiffness Control of a Soft Rehabilitation Robot with Sliding Mode Method

Trajectory Tracking Control of A Hydraulic Parallel Robot Manipulator with Lumped Disturbance Observer

Variable Structure Control for a Class of Systems with Mismatched Uncertainties

Tracking control via time-varying feedback for an uncertain robotic system with both output constraint and dead-zone input

Robust tracking control for two classes of variable stiffness actuators based on linear extended state observer with estimation error compensation

Event-triggered practical tracking control for an uncertain free-flying flexible-joint space robot with dead-zone input

Robust switching adaptive tracking control for uncertain high-order fully actuated systems

Extended State Observer Based Adaptive Backstepping Nonsingular Fast Terminal Sliding-mode Control for Robotic Manipulators with Uncertainties

Decentralized Robust Tracking Control for Robots with Uncertain Parameters

Tracking control of a flexible‐link manipulator based on an improved barrier function adaptive sliding mode

Command Filtered Adaptive Asymptotic Tracking Control of Nonlinear Systems With Unknown Control Directions via Logic-Based Switching

Fixed-Time Fuzzy Adaptive Tracking Control of Full-State Constrained Nonlinear Systems with Unknown Virtual Control Coefficients

Reinforcement learning-based adaptive tracking control for flexible-joint robotic manipulators

Event‐triggered practical tracking control via switching for a class of uncertain high‐order nonlinear systems with unknown input powers and control directions

Switched LPV resilient tracking control for rigid-body with defective actuators and sensors

Adaptive Neural Trajectory Tracking Control for Flexible-Joint Robots with Online Learning

Decentralized Robust Tracking Control for Uncertain Robots

Novel Adaptive Control for Flexible-Joint Robots With Unknown Measurement Sensitivity