Abstract:The growth of Yarrowia lipolytica yeast as well the biosynthesis of citric acid on rapeseed oil were studied. It was indicated that the initial step of assimilation of rapeseed oil in the yeast Y. lipolytica is their hydrolysis by extracellular lipases with the formation of glycerol and fatty acids, which appear in the medium in the phase of active growth. The concentrations of these metabolites change insignificantly upon further cultivation. Lipase and the key enzymes of glycerol metabolism (glycerol kinase) and the glyoxylate cycle responsible for the metabolism of fatty acids (isocitrate lyase and malate synthase) are induced just at the beginning of the growth phase and remain active in the course of further cultivation. These results, taken together, suggest that glycerol and fatty acids according in the medium do not suppress the metabolism of each other. The fact that glycerol and fatty acids can be consumed simultaneously is of special importance for the development of the efficient regime of oil feeding, Y. lipolytica produced citric acid (175 g/L) with a yield of 150%. It should be noted that the simultaneous utilization of two different substrates is not typical of micro-organisms, which first assimilate one of the two available substrates (commonly, a carbohydrate), whereas the assimilation of the other substrate starts only after the first substrate is fully consumed from the medium. Indeed, upon the cultivation of Y. lipolytica on the mixture of glucose and oleic acid, the latter substrate began to be utilized only when the concentration of glucose decreased. The glycolytic enzyme pyruvate dehydrogenase was induced from the first hours of cultivation and remained at high levels until the exhaustion of glucose in the medium. At the same time, the activities of isocitrate lyase and malate synthase were very low during the metabolism of glucose, but were rapidly induced (approximately in 10 times) after the exhaustion of glucose in the medium. When Y. lipolytica was grown on the mixture of glucose and hexadecane, the dynamics of growth and substrate consumption was typical of the diauxie phenomenon: the utilization of hexadecane began only in several hours after the time when glucose was completely exhausted in the cultivation medium. In this case, the exhaustion of glucose arrested growth and the culture resumed growth only after a lag period. The assay of enzymes showed that the glycolytic enzyme pyruvate dehydrogenase was active during the phase of growth on glucose, whereas the enzymes of the glyoxylate cycle, isocitrate lyase and malate synthase were active during the phase of growth on hexadecane. In recent years in the literature, there are data that the different sugars produce signals which modify the conformation of certain proteins that, in turn, directly or through a regulatory cascade affect the expression of the genes subject to catabolite repression. These genes are not all controlled by a single set of regulatory proteins (Cho et al. 2009), but there are different circuits of repression for different groups of genes (Gancedo 1990). We will discuss the possible metabolic regulation in the case of Y. lipolytica.

α-Ketoglutaric acid production from rapeseed oil by Yarrowia lipolytica yeast

Enhanced α-ketoglutaric acid production and recovery in Yarrowia lipolytica yeast by effective pH controlling

Alpha-Ketoglutaric Acid Production from a Mixture of Glycerol and Rapeseed Oil by Yarrowia lipolytica Using Different Substrate Feeding Strategies

Selection of Producer of α-Ketoglutaric Acid from Ethanol-Containing Wastes and Impact of Cultivation Conditions

Synthesis of α-ketoglutaric acid by Yarrowia lipolytica yeast grown on ethanol

Engineering the α-ketoglutarate overproduction from raw glycerol by overexpression of the genes encoding NADP+-dependent isocitrate dehydrogenase and pyruvate carboxylase in Yarrowia lipolytica

The peculiarities of succinic acid production from rapeseed oil by Yarrowia lipolytica yeast

Combinatorial metabolic engineering of industrial Gluconobacter oxydans DSM2343 for boosting 5-keto-D-gluconic acid accumulation

A Novel 2-Keto-d-gluconic Acid High-Producing Strain Arthrobacter Globiformis JUIM02.

Production of α-linolenic acid in Yarrowia lipolytica using low-temperature fermentation

Oil production from Yarrowia lipolytica Po1g using rice bran hydrolysate

Engineering Yarrowia lipolytica for the Synthesis of Glutathione from Organic By-Products

High-yield production of 5-keto-D-gluconic acid via regulated fermentation strategy of Gluconobacter oxydans and its conversion to L-(+)-tartaric acid

Valorization of Crude Glycerol into Citric Acid and Malic Acid by Yarrowia Lipolytica

190 The peculiarities of regulation of Yarrowia lipolytica yeast and citric acid overproduction

From molasses to purified α-ketoglutarate with engineered Corynebacterium glutamicum

Efficient production of α-ketoglutaric acid using an economical double-strain cultivation and catalysis system

The citric acid production from raw glycerol by Yarrowia lipolytica yeast and its regulation

State-of-the-art in the accumulation of lipids and other bioproducts from sustainable sources by Yarrowia lipolytica

An overview about the approaches used in the production of alpha-ketoglutaric acid with their applications

Biomass and microbial lipids production by Yarrowia lipolytica W29 from eucalyptus bark hydrolysate