Abstract:<p>Offshore oil production, which is a significant source of petroleum, has recently caused extensive concern. Produced water (PW) is the highest-volume byproduct of oil and gas production. The organic pollutants dominated by hydrocarbons, namely oil, in PW are the major concerns to researchers because of the adverse effects to the marine ecosystem. In industrial processes, the oil is needed to be separated by individual or cooperative use of separation technologies, such as gravity settlement, enhanced gravity settlement, and hydrocyclones. However, these conventional technologies cannot reach the separation requirements in a compact space under extreme conditions, such as emulsification and large volumes of PW. To improve the treatment efficiency, decrease the occupation of space, the practical use of a full-scale PW treatment process was proposed and investigated in the Bohai Sea, China. The oil content of PW after treatment with the full-scale process was less than 20 mg·L-1, alongside a reduction in the chemical dosage concentration (over 40% and 60% for reverse demulsifier and water clarifier, respectively) compared with the conventional process. Besides, an increase in the amount of produced liquid and PW of over 50% and 40% was achieved, respectively, generating a 30000 m<sup>3</sup>·a-1 growth in oil production in this single wellhead platform. The organic compounds and relative concentrations of these compounds were analyzed in this full-scale practical application. Hydrocarbons were the major organic pollutants in PW. Approximately 100 kinds of organic compounds that were detected in the influent of the process were reduced to 8 in the effluent with a separation efficiency over 90%, which made the PW cleaner to the marine environment. The simultaneous separation of alkanes and slightly soluble organics in PW can be explained by rotation and internal circulation, which provides a possible mechanism by which slightly soluble materials in major phase could be transferred from major phase to dispersed phased, in which the materials have a significantly higher solubility. This study provided an attractive strategy to answer the ecological menace caused by the hydrocarbon exploitation in offshore oilfields, to the benefit of both the economy and the environment.</p>

Treatment of oily wastewater from waste glycerol by acidification and the coalescer process

Co-liquefaction of swine manure and crude glycerol to bio-oil: model compound studies and reaction pathways.

Optimization of crude glycerol purification from grease trap waste biodiesel production: exploring the synergistic effect of mixed extraction alcohols on enhanced glycerol purity

Waste‐derived low‐grade glycerol purification and recovery from biorefineries: an experimental investigation

Sustainable treatment and recycling of oily sludge: Incorporation into gel -system to improve oil recovery.

Experimental Scale-Up and Technoeconomic Assessment of Low-Grade Glycerol Purification from Waste-Based Biorefinery

Factors Influencing the Liquefaction,separation,and Recovery of Solid Grease from Restaurant Garbage

Investigation of the Aging Effect of Bio-Coagulant for Oily Wastewater Treatment

Fabrication of a poly(N-isopropylacrylamide)-grafted alginate composite aerogel for efficient treatment of emulsified oily wastewater

Adsorptive purification of crude glycerol by sewage sludge-derived activated carbon prepared by chemical activation with H3PO4, K2CO3 and KOH

Enzymatic Hydrolysis of Waste Fats, Oils and Greases (fogs): Status, Prospective, and Process Intensification Alternatives

Surface synthesis of a polyethylene glutaraldehyde coating for improving the oil removal from wastewater of microfiltration carbon membranes

Anaerobic Biodegradation of Biodiesel Industry Wastewater in Mesophilic and Thermophilic Fluidized Bed Reactors: Enhancing Treatment and Methane Recovery

Insight into water-enhanced CO2 extraction in the treatment of oily sludge

Treatment of oily wastewater by using polysulfide polymer

Membrane-based simultaneous degumming and deacidification of vegetable oils

A full-scale process for produced water treatment on offshore oilfield: Reduction of organic pollutants dominated by hydrocarbons

Preparation of Newly Polymer-Coated Microbial Pellets and Their Adsorption and Degradation Properties for Oil-Containing Wastewater

A dual wastes-based aerogel with inverse beetles-like structure for enhanced oily wastewater treatment

Physico-chemical characterization, morphology and performance of polyethersulfone based membrane for glycerol removal from biodiesel produced through trans-esterification of waste cooking oils

Wastewater treatment of bottle oil washing water (BOWW) by hybrid coagulation–flocculation and biological process