Biosorption of Chitosan-Biochar Microsphere for Methyl Red and Biosorption Enhancing Effect of Microsphere-Microbe Complex
Du Jingting,Sun Pengfei,Zhao Yuhua,Zhang Xin
DOI: https://doi.org/10.3785/j.issn.1008-9209.2015.05.018
2015-01-01
Abstract:Summary Dyes are widely and intensively used in leather , textile , paper , printing , cosmetic , plastic , food and pharmaceutical industries . Most of them pose serious threats to the environment because of their carcinogenic potential and cytotoxicity . Hence , effluents containing dye molecule must be treated to minimize the threat to the ecosystem . Adsorption has been found to be one of the prominent techniques for dye wastewater treatment considering cost and efficiency . While the main disadvantage of physical adsorption is its simple transfer of the dye molecules to another phase rather than complete destruction . Therefore , it is meaningful to find an efficient adsorbent and explore the synergistic effect of the prepared adsorbent by combining adsorption material with dye‐biodegrading microorganisms . Methyl red was selected as model azo dyes in this study to investigate the biosorption behavior of newly produced chitosan‐biochar microsphere , and meanwhile the enhancing effect of microsphere‐microbe complex on removal of the dye was evaluted . To study the biosorption mechanism and capacity of chitosan‐biochar microsphere for methyl red , the Langmuir and Freundlich adsorption isotherms were used to examine the system of methyl red and microsphere . The pesudo‐first‐order and pesudo‐second‐order models were used to describe the biosorption kinetics . Elovich equation and inter‐diffusion model were applied to interpret the process of adsorption . In this work , artificial neural network (ANN) model was selected to analyze the parameters that affecting adsorption . The input layer had four neurons such as pH , initial dye concentration , temperature and adsorption time . The output layer had one neuron as adsorption capacity . Finally , degrading strain Bacillus sp . UN2 was immobilized by the microspheres to remove the methyl red in solutions , and the enhancing removal effect of microsphere‐microbe complex for the dye was explored . The results showed that the chitosan‐biochar microsphere was an efficient adsorbent , and the maximum biosorption capacity of 460 mg/g for methy red was observed under the initial dye concentration of 500 mg/L , pH 3 .0 and 20 °C conditions . The data of biosorption were fitted with Freundlich isotherm and the pseudo‐second‐order kinetic model successfully . The data based on Elovich equation and inter‐diffusion mode proved the dominant status of adsorption against desorption . The values of thermo‐dynamic parameters ΔG0 , ΔH0 and ΔS0 were-24 .35 kJ/mol (30 ℃) , -21 .36 kJ/mol and 8 .45 J/(mol. K) respectively . Therefore , the adsorption was a spontaneous , exothermic process , with inter‐diffusion as the limiting step for biosorption of methyl red onto biosorbent . Artificial neural network model analysis indicated that the temperature appeared to be the most influential parameter for biosorption process with a relative importance of 32 .76% , followed by adsorption time (25 .56% ) , pH ( 23 .36% ) and initial dye concentration ( 18 .32% ) . Immobilization with microsphere could improve the tolerance level of degrading strain Bacillus sp . UN2 in methyl red solution with high concentration , and the removal rate for methyl red was increased by 29% and 76% respectively by chitosan‐biochar‐microbe complex compared with chitosan‐biochar microsphere and free strains alone . In conclusion , the newly produced chitosan‐biochar microsphere is an efficient adsorption material for methyl red . The maximum biosorption capacity is better than ever reported . The adsorption is a spontaneous , exothermic process , with the inter‐diffusion as the limiting step for biosorption of methyl red onto biosorbent . Temperature is the most influential parameter for biosorption process . Significantly enhancing adsorption effect is achieved when the chitosan‐biochar microsphere immobilized the degrading strain Bacillus sp . UN2 , which offers an environment‐friendly and cost‐competitive method to treat the dye pollution .