Abstract:The objective of this study was to investigate the extraction of lipids, for example, mono‐ and polyunsaturated fatty acids (PUFA) as well as carotenoids, from wet microalgae biomass using pressurized subcritical extraction solvents, which meet the requirements of food and feed applications. To demonstrate the effect of the solvent and temperature on the lipid yield, we chose two microalgae species, viz. Chlorella vulgaris and Phaeodactylum tricornutum, differing in their biochemical composition fundamentally. In case of P. tricornutum, ethanol showed the highest fatty acid yield of 85.9% w/w. In addition to eicosapentaenoic acid (EPA), the ethanolic extracts contained exceptional amounts of fucoxanthin (up to 26.1 mg/g d. w.), which can be beneficial to protect unsaturated fatty acids from oxidation processes and in terms of human nutrition. For C. vulgaris, a fatty acid yield of 76.5% w/w was achieved from wet biomass using ethyl acetate at 150°C. In general, an increase in the extraction temperature up to 150°C was found to be important in terms of fatty acid yield when extracting wet microalgae biomass. The results suggest that it is possible to efficiently extract both fatty acids and carotenoids from wet microalgae by selecting suitable solvents and thus circumvent energy‐intensive drying of the biomass. Pressurized subcritical solvents offer the possibility to extract lipids, for example, mono‐ and polyunsaturated fatty acids (PUFA) as well as carotenoids like fucoxanthin, from different types of wet microalgae biomass while using comparatively small amounts of organic solvent. The results of our study suggest that it is possible to efficiently extract both fatty acids and carotenoids from Chlorella vulgaris and Phaeodactylum tricornutum by selecting suitable solvents and thus circumvent energy‐intensive drying of the biomass.

Solvent Extraction of Fucoxanthin from Phaeodactylum tricornutum

A simple and efficient strategy for fucoxanthin extraction from the microalga Phaeodactylum tricornutum

Rapid Purification of Fucoxanthin from Phaeodactylum tricornutum

Supercritical CO2 Extraction of Total Anthraquinones from Rheum Palmatum L.

Supercritical CO2 Extraction of Free Anthraquinones from Rheum Palmatum L.

A Potential Commercial Source of Fucoxanthin Extracted from the Microalga Phaeodactylum tricornutum

Supercritical Fluid Extraction of Fucoxanthin from the Diatom Phaeodactylum tricornutum and Biogas Production through Anaerobic Digestion

Elucidating supercritical fluid extraction of fucoxanthin from algae to enable the integrated biorefinery

Fucoxanthin and Polyunsaturated Fatty Acids Co-Extraction by a Green Process

Fucoxanthin from marine microalga Isochrysis galbana: optimization of extraction methods with organic solvents

Extraction of Fucoidan Using Multienzyme Enzymolysis and Their Structural Analysis, Antioxidation Research

Valorization of Phaeodactylum tricornutum for integrated preparation of diadinoxanthin and fucoxanthin

Current advances in recovery and biorefinery of fucoxanthin from Phaeodactylum tricornutum

Development of new green processes for the recovery of bioactives from Phaeodactylum tricornutum

Pressurized extraction of unsaturated fatty acids and carotenoids from wet Chlorella vulgaris and Phaeodactylum tricornutum biomass using subcritical liquids

Laminaria japonica hydrolysate promotes fucoxanthin accumulation in Phaeodactylum tricornutum

Fucoxanthin biosynthesis has a positive correlation with the specific growth rate in the culture of microalga Phaeodactylum tricornutum

Combined Production of Fucoxanthin and EPA from Two Diatom Strains Phaeodactylum Tricornutum and Cylindrotheca Fusiformis Cultures

Fucoxanthin's Optimization from Undaria pinnatifida Using Conventional Heat Extraction, Bioactivity Assays and In Silico Studies

Study on Extraction of Photosynthetic Pigments from Phytoplankton by Organic Solvents

Variability of Omega-3/6 Fatty Acid Obtained Through Extraction-Transesterification Processes from Phaeodactylum tricornutum