Abstract:Abstract Background Recent studies have demonstrated that microalga has been widely regarded as one of the most promising raw materials of biofuels. However, lack of an economical, efficient and convenient method to harvest microalgae is a bottleneck to boost their full-scale application. Many methods of harvesting microalgae, including mechanical, electrical, biological and chemical based, have been studied to overcome this hurdle. Results A new flocculation method induced by decreasing pH value of growth medium was developed for harvesting freshwater microalgae. The flocculation efficiencies were as high as 90% for Chlorococcum nivale , Chlorococcum ellipsoideum and Scenedesmus sp. with high biomass concentrations (>1g/L). The optimum flocculation efficiency was achieved at pH 4.0 . The flocculation mechanism could be that the carboxylate ions of organic matters adhering on microalgal cells accepted protons when pH decreases and the negative charges were neutralized, resulting in disruption of the dispersing stability of cells and subsequent flocculation of cells. A linear correlation between biomass concentration and acid dosage was observed. Furthermore, viability of flocculated cells was determined by Evans Blue assay and few cells were found to be damaged with pH decrease. After neutralizing pH and adding nutrients to the flocculated medium, microalgae were proved to maintain a similar growth yield in the flocculated medium comparing with that in the fresh medium. The recycling of medium could contribute to the economical production from algae to biodiesel. Conclusions The study provided an economical, efficient and convenient method to harvest fresh microalgae. Advantages include capability of treating high cell biomass concentrations (>1g/L), excellent flocculation efficiencies (≥ 90%), operational simplicity, low cost and recycling of medium. It has shown the potential to overcome the hurdle of harvesting microalgae to promote full-scale application to biofuels from microalgae.

Harvesting Chlorella vulgaris by natural increase in pH: effect of medium composition

Study on Medium Composition of Microalgae Optimization for CO2 Removal from Air by A Membrane-Photobioreactor

Development of an effective flocculation method by utilizing the auto-flocculation capability of Phaeodactylum tricornutum

High pH-induced flocculation of marine Chlorella sp. for biofuel production

Pre-concentration of microalga Euglena gracilis by alkalescent pH treatment and flocculation mechanism of Ca3(PO4)2, Mg3(PO4)2, and derivatives

Freshwater microalgae harvested via flocculation induced by pH decrease

Flocculation of Chlamydomonas reinhardtii with Different Phenotypic Traits by Metal Cations and High pH

The shift in carbon source induces pH increase and autoflocculation in microalgal suspensions facilitating multi-approach biomass harvesting

Nutrient Optimization Strategy to Increase the Carbohydrate Content of Chlorella vulgaris and Evaluation of Hydrolysis and Fermentation Performance

Using ferric sulfate, sodium hydroxide, and chitosan to harvest marine microalgae Chlorella vulgaris and recycling the culture medium

Phosphorus removal in microalgal growth and harvesting using natural flocculant: Influence of microalgal characteristics and phosphorus forms

Selection and re-acclimation of bioprospected acid-tolerant green microalgae suitable for growth at low pH

Harvesting of Microalgae Chlorella pyrenoidosa by Bio-flocculation with Bacteria and Filamentous Fungi

Growth of Chlorella vulgaris and nutrient removal in the wastewater in response to intermittent carbon dioxide

Effect of pH, cationic inducer, and clam shells as bio-flocculant in the optimization of the flocculation process for enhanced microalgae harvesting using response surface methodology

Growth characteristics of acclimated strain of Chlorella vulgaris under high concentrations of ammonia nitrogen and phosphorus

Effects of Chlorella vulgaris on phosphorus release from ferric phosphate sediment by consecutive cultivations

Two-step cultivation of Neochloris oleoabundans in a novel horizontal thin-layer algal reactor: Interplay of pH and dissolved inorganic carbon

A step towards more eco-friendly and efficient microalgal harvesting: Inducing flocculation in the non-naturally flocculating strain Chlorella vulgaris (13-1) without chemical additives

Enhancing Lipid Production in Microalgae Chlorella PY-ZU1 with Phosphorus Excess and Nitrogen Starvation under 15% CO2 in a Continuous Two-Step Cultivation Process

The Effect of Environmental Factors on the Content of Fatty Acids Composites and Total Fatty Acids Yield of Heterotrophic Chlorella Vulgaris