Abstract:Nanofiltration (NF) has been proven to be with great potential for the separation of morpholines with molecular weight less than 200 Da in refining reverse osmosis concentrate (ROC), but its application is significantly restricted by the membrane fouling, which can reduce the rejection and service time. To enable the long-term operation stability of nanofiltration, this work focuses on the fouling behavior of each substance in the hydrosaline organic solution on nanofiltration membrane, aiming to give insight into the fouling mechanism. To this end, in this work, the effects of salts (i.e NaCl and Na2SO4), organic substances (including N-(2-hydroxypropyl)morpholine(NMH) and 4-morpholineacetate(MHA)) and representative divalent ions (Ca2+ and Mg2+) on the performance and physicochemical properties of DK membrane were systematically investigated. The results show that both salts and organics can induce DK membrane swelling, leading to an increase of the mean effective pore size. After the filtration of Na2SO4-NaCl-H2O, the mean pore size increased by 0.002 nm, resulting in the decrease of the removal ratio of NMH and MHA for 3.82% and 13.10%, respectively. With static adsorption of NMH and MHA, the mean pore size of DK membrane increased by 0.005 and 0.003 nm. The swelling slowed the entrance of more organic molecules into membrane pores. Among them, MHA led to the terrible irreversible pore blocking. As the concentration of Ca2+ increased, gypsum scaling was formed on the membrane surface. During this process, NMH and MHA played different roles, i.e. NMH accelerated the CaSO4 crystallization while MHA inhibited. As a conclusion, the fouling behavior of substances in the high saline organic wastewater on DK membrane were systematically revealed with the fouling mechanisms proposed, which could provide an insightful guidance for membrane fouling control and cleaning in the treatment of high salinity and organic wastewater.

Fouling of nanofiltration membranes used for separation of fermented glycerol solutions

Fouling of the Nanofiltration Membrane NF270 Used for Separation of Fermentation Broths: Impact of Feed Pretreatment Process

The electrocoagulation pretreatment of biogas digestion slurry from swine farm prior to nanofiltration concentration

The application of ultrafiltration for separation of glycerol solution fermented by bacteria

The Application of the Nanofiltration Membrane NF270 for Separation of Fermentation Broths

Characterization of membrane foulants in an anaerobic non-woven fabric membrane bioreactor for municipal wastewater treatment

Fouling Behaviours of Two Membranes in a Submerged Membrane Bioreactor for Municipal Wastewater Treatment

Separation of Biobased Carboxylic Acids by Aqueous Phase Nanofiltration

Influence of Ceramic Membrane Surface Characteristics on the Flux Behavior of a Complex Fermentation Broth

Analysis of Membrane Fouling by Proteins During Nanofiltration of Chitin Alkali Wastewater

Membrane fouling in engineering nanofiltration process for drinking water treatment: The spatial and chemical aspects

Removal of Organic Compounds with an Amino Group during the Nanofiltration Process

Solution blow-spun polyacrylonitrile–polyamide thin-film nanofibrous composite membrane for the removal of fermentation inhibitors

Transport properties and fouling issues of membranes utilized for the concentration of dairy products by air-gap membrane distillation and microfiltration

Separation Of (L)-Glutamine From Fermentation Broth By Nanofiltration

Fouling behavior of nanofiltration membrane during the refining treatment of morphlines-dominant reverse osmosis concentrate

Nanofiltration in Pilot Scale for Wastewater Reclamation: Long-term Performance and Membrane Biofouling Characteristics

Fractionation and Flux Decline Studies of Surface-Patterned Nanofiltration Membranes Using NaCl-glycerol-BSA Solutions

Biofouling Mitigation Approaches during Water Recovery from Fermented Broth via Forward Osmosis

Separation of ?-glutamine from fermentation broth by nanofiltration

Facile Preparation of Anti-Biofouling Nanofiltration Membrane Using Safety Inhibitor with High Separation Performances