Modeling of Simultaneous Partial Nitrification, Anammox and Denitrification Process In a Single Reactor

Xiao Yang,Xiao Qiang,Xiang Shi,Qiang Xiao Shi Xiang

DOI: https://doi.org/10.4172/2161-0525.1000204

2013-01-01

Abstract:One sequencing batch reactor (SBR) seeded with anaerobic granular sludge was started-up to enrich simultaneous

What problem does this paper attempt to address?

Evaluation of mainstream nitrogen removal by simultaneous partial nitrification, anammox and denitrification (SNAD) process in a granule-based reactor

Tao Liu,Bin Ma,Xueming Chen,Bing-Jie Ni,Yongzhen Peng,Jianhua Guo

DOI: https://doi.org/10.1016/j.cej.2017.06.173

IF: 15.1

2017-01-01

Chemical Engineering Journal

Abstract:•A granular model of Partial Nitrification, Anammox & Denitrification was established.•The optimal operational conditions for high-level nitrogen performance were proposed.•Granule size distribution significantly affects performance and microbial communities.
Granulation of Simultaneous Partial Nitrification and Anammox Biomass in One Single SBR System

Xiaoming Li,Yang Xiao,Dexiang Liao,Wei Zheng,Ting Yi,Qi Yang,Guangming Zeng

DOI: https://doi.org/10.1007/s12010-010-9108-8

2010-10-31

Applied Biochemistry and Biotechnology

Abstract:The granulation of simultaneous partial nitrification and anaerobic ammonium oxidation (Anammox) was investigated in a single, oxygen-limited, sequencing batch reactor. In this research, the reactor was started anaerobically and fed using the synthetic medium described by Van de Graaf et al. to cultivate Anammox biomass after inoculation with methanogenic granular sludge. Subsequently, mixture gas (air and nitrogen gas) was supplied to the reactor and a nitrifying population developed. Research results indicated that autotrophic granules was cultivated successfully by controlling the dissolved oxygen in the reactor between 0.3 and 0.5 mg/L, and a total inorganic nitrogen removal efficiency of 63.7% was obtained with a higher nitrogen load increased by reducing HRT to 3 days. It was also seen that the Ca and P concentrations of the feeding medium are important factors that influence the autotrophic granules from process running. When the Ca and P concentrations were exceeded the necessary quantity, salt precipitation was observed, interfered with microbial activity, and caused a decrease of the nitrogen removal rate of the system. After diminishing adequately the Ca and P concentrations, salt precipitation was avoided and the activity of the system restored quickly. Moreover, visual indication and scanning election microscopy observation revealed the process of sludge evolution and inner structure of the granules.

biotechnology & applied microbiology,biochemistry & molecular biology
Simultaneous Ammonia and Nitrate Removal in an Airlift Reactor Using Poly(butylene Succinate) As Carbon Source and Biofilm Carrier.

Yun-Jie Ruan,Ya-Le Deng,Xi-Shan Guo,Michael B. Timmons,Hui-Feng Lu,Zhi-Ying Han,Zhang-Ying Ye,Ming-Ming Shi,Song-Ming Zhu

DOI: https://doi.org/10.1016/j.biortech.2016.06.056

IF: 11.4

2016-01-01

Bioresource Technology

Abstract:In this study, an airlift inner-loop sequencing batch reactor using poly(butylene succinate) as the biofilm carrier and carbon source was operated under an alternant aerobic/anoxic strategy for nitrogen removal in recirculating aquaculture system. The average TAN and nitrate removal rates of 47.35±15.62gNH4-Nm(-3)d(-1) and 0.64±0.14kgNO3-Nm(-3)d(-1) were achieved with no obvious nitrite accumulation (0.70±0.76mg/L) and the dissolved organic carbon in effluents was maintained at 148.38±39.06mg/L. Besides, the activities of dissimilatory nitrate reduction to ammonium and sulfate reduction activities were successfully inhibited. The proteome KEGG analysis illustrated that ammonia might be removed through heterotrophic nitrification, while the activities of nitrate and nitrite reductases were enhanced through aeration treatment. The microbial community analysis revealed that denitrifiers of Azoarcus and Simplicispira occupied the dominate abundance which accounted for the high nitrate removal performance. Overall, this study broadened our understanding of simultaneous nitrification and denitrification using biodegradable material as biofilm carrier.
Simultaneous Nitrification–denitrification and Microbial Community Profile in an Oxygen-Limiting Intermittent Aeration SBBR with Biodegradable Carriers

Lijuan Feng,Rong Jia,Zhen Zeng,Guangfeng Yang,Xiangyang Xu

DOI: https://doi.org/10.1007/s10532-018-9845-x

2018-01-01

Biodegradation

Abstract:To enhance the startup and efficient simultaneous nitrification and denitrification for sewage treatment, sequencing batch biofilm reactors (SBBRs) partially coupled with rice husk were established and operated under various intermittent micro-aeration cycles (IMCs) and COD/N ratios under oxygen-limiting intermittent aeration conditions. Experimental results showed that the increase of IMCs with non-aeration/micro-aeration mode of (8 h/4 h)1 to (2 h/1 h)4 in a 12 h-cycle accelerated the startup performance and improved NH4+–N and COD removal. NH4+–N, TN and COD removal efficiencies were 98.7 ± 0.9, 89.2 ± 5.2 and 82.9 ± 6.7% at COD/N ratio of 7.6 with the highest IMCs in SBBR, respectively. Higher TN removal efficiencies of 87.2 ± 4.0 and 58.1 ± 3.5% were also achieved at lower COD/N ratio of 5.6 and 2.8, respectively. In SBBRs with various IMCs, facultative denitrifier like genus Acinetobacter and solid-phase denitrifier belonging to Comamonadaceae family were enriched. However, aerobic denitrifiers with function of heterotrophic nitrification like Paracoccus were favored to enrich under higher IMCs condition, and more anoxic denitrifiers like sulfur-based autotrophic denitrifier Thiothrix and heterotrophic denitrifiers like Pseudomonas and Methyloversatilis were observed at lower IMCs condition. Autotrophic nitrifier (Nitrosomonas and Nitrosipra) and heterotrophic nitrifiers both contributed to the efficient nitrification.
Characterization and Quantification of Anammox Start-Up in UASB Reactors Seeded with Conventional Activated Sludge

Chong-Jian Tang,Ping Zheng,Li-Yuan Chai,Xiao-Bo Min

DOI: https://doi.org/10.1016/j.ibiod.2013.02.014

IF: 4.907

2013-01-01

International Biodeterioration & Biodegradation

Abstract:The start-up of anammox process inoculated with anaerobic granular sludge and nitritation sludge were carefully investigated in two upflow anaerobic sludge blanket (UASB) reactors. Three major bioprocesses related in anammox start-up i.e. anammox, denitrification and cell lysis, were quantified in both reaction and microbial growth aspects in the four consecutive phases namely cell lysis phase, lag phase, activity elevation phase and stationary phase. The results showed that anammox was negligible when cell lysis was predominant in the reactors; however, the density of anammox bacteria objectively increased in this phase due to the biomass reduction caused by hydrolysis. During lag phase, poor anammox was detected; while denitrification and cell lysis were the two leading reactions. Anammox performance of the reactors was significantly enhanced in activity elevation phase. Denitrification continuously weakened in stationary phase and anammox gradually became the dominant reaction. Nevertheless, heterotrophic denitrification still predominated throughout the start-up course due to the extremely low growth rate of anammox bacteria. Results also suggested that the inoculation strategy using nitritation sludge as the main inoculum commixing with anaerobic granular sludge could contribute to the relatively shorter start-up time and better reactor performance. Such an alternative may prove effective strategy for full-scale application of anammox process.
Achieving single‐stage partial nitritation and anammox (PN/A) using a submerged dynamic membrane sequencing batch reactor (DM‐SBR)

Xiaohuan Yang,Ziwen Jia,Jingwei Fu,Qian Li,Rong Chen

DOI: https://doi.org/10.1002/wer.1468

2020-12-22

Water Environment Research

Abstract:Single‐stage partial nitration and anammox (PN/A) process was achieved in a sequencing batch reactor (SBR) using a submerged dynamic membrane (DM) in this study. The reactor was stably operated for 200 days, and the nitrogen removal efficiency (NRE) was sustained at 70.3±7.2% at a nitrogen loading rate (NLR) ranging from 0.1 to 0.3 kgN/m3/d with a hydraulic retention time (HRT) of 24 h. When the NLR was 0.2 kgN/m3/d, the NRE achieved was high as 80% with a low concentration of dissolved oxygen (DO) of 0.13 mg/L. In addition, the specific activity of anammox bacteria and ammonia‐oxidizing bacteria (AOB) reached was 2.72 and 16.80 gN/gVSS/d, respectively. The DM intercepted the biomass due to the lamellar, intact, dense biofilm self‐generated on the surface of the supporting material, which had an effluent turbidity of 10 NTU. The enriched anammox functional bacteria were Candidatus Jettenia (11.06%) and the AOB‐like functional bacteria consisted primarily of Nitrosomonas, with a relative abundance of 2.76%, which ensured the PN/A process proceeding. This study provides a novel reactor configuration of the single‐stage PN/A process in the view of practical applications.

environmental sciences,engineering, environmental,water resources,limnology
Cultivation, Granulation and Characteristics of Anaerobic Ammonium-Oxidizing Sludge in Sequencing Batch Reactor

B. L. Hu,P. Zheng,Q. Mahmood,H. F. Qian,D. L. Wu

DOI: https://doi.org/10.2166/ws.2006.967

2006-01-01

Water Science & Technology Water Supply

Abstract:Anaerobic sequencing batch reactor (SBR) was started-up by inoculating the nitrifying activated sludge. After an operation of 72 d, the bioreactor reached at steady state with ammonia and nitrite removal percentages higher than 95%. During operation, the sludge granulated in the reactor. The morphology and internal structure of sludge granules changed conspicuously, the density increased while the color changed from khaki to red. The average granular diameter grew from 1.2 to 3.69 mm, and its settling velocity accelerated from 107.68 to 118.49 m/h. Sludge granulation improved the tolerance to hydraulic shock loading, and reduced sludge washout (TSS < 0.028 g/L). The dominant bacterial communities (filamentous and cocci) in nitrifying activated sludge were replaced by irregular shaped ANAMMOX bacterial species gradually. An increase of ANAMMOX rate was achieved with the increasing granular diameter. SBR is a useful reactor to cultivate ANAMMOX granular sludge, while granular ANAMMOX sludge thus developed can be used as seeding sludge in a pilot-scale or full scale wastewater treatment plant.
Achieving advanced nitrogen removal and excess sludge treatment via single nitritation/anammox-fermentation combined system

Jianhua Zhang,Guocheng Ma,Xuejun Bi,Xinchao Zhao,Jiawen Li,Yu Zhang,Zhongxiu Gao,Yitong Li,Yuanyuan Miao

DOI: https://doi.org/10.1016/j.biortech.2023.129550

IF: 11.4

2023-07-31

Bioresource Technology

Abstract:The feasibility of treating wastewater and excess sludge via simultaneous nitritation, anammox, denitrification and fermentation (SNADF) was investigated in three parallel sequencing batch reactors (SBRs). SBR2 and SBR3 received exogenous nitrification–denitrification sludge and thermal hydrolysis sludge, respectively. Nitrogen removal efficiencies of 92.8 ± 5.9%, 94.6 ± 4.1%, 93.4 ± 4.8% were achieved in SBR1, SBR2, and SBR3, respectively (influent ammonium: 56.0–74.0 mg N/L), with low observed sludge yield of 0.02–0.15, −0.06–0.11, −0.17–0.05 kg mixed liquor suspended solids (MLSS)/kg chemical oxygen demand (COD). Anammox bacterial abundances increased from 3.6 × 10 9 ± 2.8 × 10 8 to 8.1 × 10 9 ± 2.3 × 10 8 , 1.5 × 10 10 ± 1.1 × 10 8 , and 1.4 × 10 10 ± 2.9 × 10 8 copies/L in SBR1-SBR3, respectively. The abundances of Nitrosomonas , genes ( amo , hao ) for partial nitrification, and narGHI genes (nitrate → nitrite) in dominant partial denitrifying bacteria ( Candidatus Competibacter ) were higher in SBR2 and SBR3 than that in SBR1. These results suggested that adding excess sludge promoted sludge reduction, nitrite production and anammox bacterial enrichment. The SNADF system could treat excess sludge, meanwhile, achieve advanced nitrogen removal.

energy & fuels,biotechnology & applied microbiology,agricultural engineering
Granulation of nitritation sludges in sequencing batch reactor

Jie LIU,Jian-e ZUO,Shu-quan ZHU

2011-01-01

Abstract:Rapid start-up of nitritation process in an aerobic sequencing batch reactor (SBR) and granulation of the nitritation sludge were investigated. The SBR was operated at room temperature, with 4 electrotimesrs controlling the alternation of the influent, effluent, settling and discharging time. The results show that, 6 days after start-up under the condition of settling time 2 min, influent ammonium concentration 300 mg/L and surficial gas velocity 1.3 cm/s, the ammonium removal efficiency and the ratio of NO2 - N to NOx - N in effluent both reached over 90%, suggesting a success of the rapid start-up. At the 32nd day, the average diameter of sludge reached 0.34 mm, indicating the successful cultivation of kernels. Then, by adjusting the operational parameters and the influent ammonium loading rate, granulation of the nitritation sludge was apparently developed, with an average diameter of 0.48 mm after operation for 78 days. Further more, the settling property of the sludge was substantially improved, with the Sludge Volume Index: SVI10 and SVI30 of 29 mL/g and 25 mL/g, respectively. At the end of the operation, the ammonium removal efficiency and the ratio of NO2 - N to NOx - N in the effluent were above 90% and 97%, respectively, with the influent ammonium loading rate of 1.2 kg/(m3 · d), suggesting the stable operation of the nitritation process.
Anammox start-up in sequencing batch biofilm reactors using different inoculating sludge

Ying-Cui Yu,Da-Wen Gao,Yu Tao

DOI: https://doi.org/10.1007/s00253-012-4427-z

IF: 5

2012-09-25

Applied Microbiology and Biotechnology

Abstract:In this study, anammox bacteria were rapidly enriched in sequencing batch biofilm reactors (SBBRs) with different inoculations. The activated sludge taken from a sequencing batch reactor was used and inoculated to SBBR1, while SBBR2 was seeded with stored anaerobic sludge from an upflow anaerobic fixed bed (2-year stored at 5–15 °C). Nitrogen removal performance, anammox activity, biofilm characteristics and variation of the microbial community were evaluated. The maximum total nitrogen loading rate (NLR) of SBBR1 gradually reached to 1.62 kg N/(m3/day) with a removal efficiency higher than 88 % and the NLR of SBBR2 reached to 1.43 kg N/(m3/day) with a removal efficiency of 86 %. SBBR2 was more stable compared to SBBR1. These results, combined with molecular techniques such as scanning electron microscope, fluorescence in situ hybridization, and terminal restriction fragment length polymorphism, indicated that different genera of anammox bacteria became dominant. This research also demonstrates that SBBR is a promising bioreactor for starting up and enriching anammox bacteria.

biotechnology & applied microbiology
Operation of a Sequencing Batch Reactor for Cultivating Autotrophic Nitrifying Granules.

Xian-Yang Shi,Guo-Ping Sheng,Xiao-Yan Li,Han-Qing Yu

DOI: https://doi.org/10.1016/j.biortech.2009.11.099

IF: 11.4

2010-01-01

Bioresource Technology

Abstract:The granulation of nitrifying sludge in a sequencing batch reactor (SBR) fed with NH4+-N-laden inorganic wastewater was investigated. After 120-day operation spherical and elliptical granules with an average diameter of 0.32mm were observed. The hydrophobicity surface, settling velocity and specific gravity of the matured granules increased with the processing of sludge granulation. Spatial distribution of bacterial species within the autotrophic granules was analyzed with fluorescence in situ hybridization. Both ammonia- and nitrite-oxidizing bacteria were observed in the granular sludge. The Michaelis–Menten equation was used to describe their NH4+-N utilization rate, and the kinetic coefficients were calculated to be vm=18.0mg/g-VSS/h and Km=36.7mg/l. Taking into account the NH4+-N utilization rate and removal efficiency together, an NH4+-N concentration range of 100–250mg/l was found to be favourable for the operation of the SBR to cultivate nitrifying granules.
Modeling the partial nitrification in sequencing batch reactor for biomass adapted to high ammonia concentrations

V. Pambrun,E. Paul,M. Spérandio

DOI: https://doi.org/10.1002/bit.21008

IF: 3.8

2006-01-01

Biotechnology and Bioengineering

Abstract:Partial nitrification has proven to be an economic way for treatment of industrial N-rich effluent, reducing oxygen and external COD requirements during nitrification/denitrification process. One of the key issues of this system is the intermediate nitrite accumulation stability. This work presents a control strategy and a modeling tool for maintaining nitrite build-up. Partial nitrification process has been carried out in a sequencing batch reactor at 30 degrees C, maintaining strong changing ammonia concentration in the reactor (sequencing feed). Stable nitrite accumulation has been obtained with the help of an on-line oxygen uptake rate (OUR)-based control system, with removal rate of 2 kg NH4 (+)-N x m(-3)/day and 90%-95% of conversion of ammonium into nitrite. A mathematical model, identified through the occurring biological reactions, is proposed to optimize the process (preventing nitrate production). Most of the kinetic parameters have been estimated from specific respirometric tests on biomass and validated on pilot-scale experiments of one-cycle duration. Comparison of dynamic data at different pH confirms that NH3 and NO2- should be considered as the true substrate of nitritation and nitratation, respectively. The proposed model represents major features: the inhibition of ammonia-oxidizing bacteria by its substrate (NH3) and product (HNO2), the inhibition of nitrite-oxidizing bacteria by free ammonia (NH3), the INFluence of pH. It appears that the model correctly describes the short-term dynamics of nitrogenous compounds in SBR, when both ammonia oxidizers and nitrite oxidizers are present and active in the reactor. The model proposed represents a useful tool for process design and optimization.

biotechnology & applied microbiology
The development of simultaneous partial nitrification, ANAMMOX and denitrification (SNAD) process in a single reactor for nitrogen removal.

Huihui Chen,Sitong Liu,Fenglin Yang,Yuan Xue,Tao Wang

DOI: https://doi.org/10.1016/j.biortech.2008.09.003

IF: 11.4

2009-01-01

Bioresource Technology

Abstract:The simultaneous partial nitrification, ANAMMOX and denitrification (SNAD) process was validated to potentially remove ammonium and COD from wastewater in a single, oxygen-limited, non-woven rotating biological contactor (NRBC) reactor. An ammonium conversion efficiency of 79%, TN removal efficiency of 70% and COD removal efficiency of 94% were obtained with the nitrogen and COD loading rate of 0.69kgN/m3d and 0.34kg/m3d, respectively. Scanning electron microscopy (SEM) observation and fluorescence in situ hybridizations (FISH) analysis revealed the existence of the dominant groups of bacteria. As a result, the aerobic ammonia-oxidizing bacteria (AOB), with a spot of aerobic heterotrophic bacteria were mainly distributed in the aerobic outer part of the biofilm. However, ANAMMOX bacteria with denitrifying bacteria were present and active in the anaerobic inner part of the SNAD biofilm. These bacteria were found to exist in a dynamic equilibrium to achieve simultaneous nitrogen and COD removal in NRBC system.
Start-up of the Simultaneous Nitrification, Anammox, and Denitrification (SNAD) Reactor and Efficacy of a Small Amount of Organic Carbon

Wei Liu,Allama Al Naim Bin Nasry,Jianqiang Zhao,Huexay Laoyongxay,Wei Dai,Qian Zhao

DOI: https://doi.org/10.1007/s11270-019-4318-3

2019-11-01

Abstract:In perspective of the issue of how to begin simultaneous nitrification, anammox, and denitrification (SNAD) rapidly, the sequencing batch biofilm reactor (SBBR) was adopted to enrich ammonia-oxidizing bacteria (AOB) and anammox bacteria (AnAOB) rapidly and to inhibit nitrite-oxidizing bacteria (NOB) after three phases (67 days) of culture, and the impacts of different low carbon-nitrogen ratios (COD/N) on denitrification performance of the process were investigated. The results showed that preventing the accumulation of nitrite (NO2−-N) was the key to start SNAD successfully. The removal efficiencies of ammonia nitrogen (NH4+-N) and total nitrogen (TN) in the system can reach more than 99% and 90%, respectively. Corresponding to COD/N = 0, 1 and 2, removal efficiencies of NH4+-N were 99.6%, 99.5%, and 98.5% respectively and removal efficiencies of TN were 93.8%, 97.2%, and 98.1%, respectively; the total nitrogen removal rate (TNRR) was greater than 0.29 kg N m−3 day−1. It indicates that the presence of a small amount of COD is beneficial to the denitrification of NO3−-N without affecting the effect of simultaneous nitrification and anaerobic ammonium oxidation, which further improves the efficiency of nitrogen removal. High-throughput sequencing analysis showed that the ratios of AOB, AnAOB, and denitrifying bacteria were 7.3%, 20.1%, and 7.66%, respectively. Candidatus Kuenenia was the only genus of the SNAD reactor with anaerobic ammonium oxidation. AOB, Anammox, and heterotrophic denitrifying bacteria were present in the system, while ammonia oxidation and anaerobic ammonium oxidation played a dominant role in the denitrification process.
Simultaneous partial nitritation, anammox, and denitrification process for the treatment of simulated municipal sewage in a single-stage biofilter reactor

Xiaozhong Huang,Yi Wang,Wenhuai Wang,Binjuan Li,Kexin Zhao,Xiaomei Kou,Shizhang Wu,Tian Shao

DOI: https://doi.org/10.1016/j.chemosphere.2021.131974

IF: 8.8

2022-01-01

Chemosphere

Abstract:This study provides a feasible scheme for the treatment of municipal sewage through simultaneous partial nitritation, anammox, and denitrification (SNAD) process, which was realized in a single-stage biofilter reactor (BFR). First, the BFR was started up to enrich the anaerobic ammonium-oxidizing bacteria (AnAOB) in the upper part of the reactor through the operation mode of the top influent and bottom effluent. Then, the BFR was inoculated with activated sludge and aerated continuously at the bottom to realize the coupling of SNAD, which was accompanied by a two-point influent from the bottom and top effluent. Results indicated that the high removal efficiency of NH4+-N (93.40%), total nitrogen (TN, 89.95%), and soluble chemical oxygen demand (SCOD, 92.68%) were achieved with an air–water ratio of 4.29 and hydraulic retention time (HRT) of 6 h. During the SNAD steady phase for the treatment of simulated municipal sewage with a soluble chemical organic demand to nitrogen (C/N) ratio of 2.31, low concentrations of NH4+-N (4.13 mg/L), TN (6.44 mg/L), and SCOD (11.29 mg/L) were attained in the effluent. High-throughput sequencing analysis indicated that the relative abundance of Nitrosomonas, Candidatus Brocadia, and Denitratisoma were 0.77%, 0.43%, and 4.07% in the biofilm at the 0–12.5 cm zone, respectively, suggesting successful implementation of the SNAD process.

environmental sciences
Partial nitrification granular sludge reactor as a pretreatment for anaerobic ammonium oxidation (Anammox): Achievement, performance and microbial community

Dong Wei,Huu Hao Ngo,Wenshan Guo,Weiying Xu,Bin Du,Qin Wei

DOI: https://doi.org/10.1016/j.biortech.2018.08.088

IF: 11.4

2018-12-01

Bioresource Technology

Abstract:Partial nitrification granular sludge was successfully cultivated in a sequencing batch reactor as a pretreatment for anaerobic ammonium oxidation (Anammox) through shortening settling time. After 250-days operation, the effluent NH4+-N and NO2--N concentrations were average at 277.5 and 280.5 mg/L with nitrite accumulation rate of 87.8%, making it as an ideal influent for Anammox. Simultaneous free ammonia (FA) and free nitrous acid (FNA) played major inhibitory roles on the activity of nitrite oxidizing bacteria (NOB). The MLSS and SVI30 of partial nitrification reactor were 14.6 g/L and 25.0 mL/g, respectively. Polysaccharide (PS) and protein (PN) amounts in extracellular polymeric substances (EPS) from granular sludge were about 1.3 and 2.8 times higher than from seed sludge. High-throughput pyrosequencing results indicated that Nitrosomonas affiliated to the ammonia oxidizing bacteria (AOB) was the predominant group with a proportion of 24.1% in the partial nitrification system.

energy & fuels,biotechnology & applied microbiology,agricultural engineering
Mathematical simulation and experimental verification of a novel control strategy for a single stage PN/A (partial nitrification/Anammox) SBR (sequencing batch reactor)

Jun Wu,Wang Xinduan,Gao Qiufeng,Zhang Chi,Zhang Miao

DOI: https://doi.org/10.1016/j.jece.2022.109154

IF: 7.7

2022-12-29

Journal of Environmental Chemical Engineering

Abstract:The single reactor PN-A process offers a cost-effective solution for nitrogen removal. The successful startup and operation of the PN/A reactor requires the enrichment and balanced growth of AOB (Ammonium oxidizing bacteria) and AMX (AMAMMOX bacteria). The precise aeration supply or DO (dissolved oxygen) control was regarded to be the key for successful operation of the PN/A reactor. However, due to the low DO concentration requirement for the PN/A reactor, it is not practical to apply the precise aeration or DO concentration control. In this study, a new control strategy for the rapid startup and operation of the single stage PN/A (partial nitrification) SBR (sequencing batch reactor) was put forward. The control strategy relies on the periodic measurement of effluent NH 4 + , NO 2 - , and NO 3 - concentration to determine the nitrogen loading rate and aeration pump speed (i.e., not exact air supply volume). It does not require precise oxygen supply or DO (dissolved oxygen) control. This feature makes the control strategy easily applicable for practical application. A calibrated mathematical model was used to evaluate the control strategy, which was shown to be effective in achieving satisfactory nitrogen removal and NOB suppression. The control strategy was tested in a lab PN/A batch reactor, in which TN removal efficiency of 80% was achieved under low influent NH 4 + concentration of 100 mg N/L and nitrogen loading rate of 0.12 Kg N/(m 3 •d) within 60 days of the experiment.

engineering, chemical, environmental
Application of a Partial Nitrogen Lab-Scale Sequencing Batch Reactor for the Treatment of Organic Wastewater and Its N2O Production Pathways, and the Microbial Mechanism

Ying Liu,Boyan Ma,Zhipei Liu

DOI: https://doi.org/10.3390/su14031457

IF: 3.9

2022-01-27

Sustainability

Abstract:Partial nitrification (PN) is a widely used wastewater treatment process. Here a lab-scale sequencing batch reactor for PN (PN-SBR) was constructed and run with artificial organic wastewater for 225 days. Results showed that the SBR reached a stable PN state after 174 days of operation and >98% of NH4+-N was removed and >60% was converted to NO2−-N with low effluent NO3−-N content. In a PN-SBR cycle at stage IV, the release of N2O was accompanied by the production of hydroxylamine, occurring mainly in the conversion from anaerobic to aerobic phases, and the amount of N2O produced was about 6.3% of the total nitrogen. The N2O isotopic signature results suggested that hydroxylamine oxidation was the main pathway for N2O production. Illumina MiSeq sequencing results showed that Proteobacteria and Bacteroidetes were the dominant phyla throughout the operation period. Many heterotrophic nitrifiers were significantly enriched, leading to ammonia removal and nitrite accumulation, including Acidovorax, Paracoccus, Propionibacteriaceae_unclassified, Shinella, Comamonas and Brevundimonas. Representative strains were isolated from the reactor and they were capable of efficiently producing nitrite from ammonia. These results provide a guide for the direct running of PN reactors for treating organic wastewater and help to understand the microbial processes and N2O release pathways and the microbial mechanism of partial nitrification.

environmental sciences,environmental studies,green & sustainable science & technology
A novel simultaneous partial nitrification, anammox, denitrification and fermentation process: Enhancing nitrogen removal and sludge reduction in a single reactor

Guocheng Ma,Deshuang Yu,Jianhua Zhang,Yuanyuan Miao,Xinchao Zhao,Jiawen Li,Yu Zhang,Guoqing Dong,Jiaru Zhi

DOI: https://doi.org/10.1016/j.biortech.2022.128484

IF: 11.4

2022-12-22

Bioresource Technology

Abstract:This study verified the feasibility of simultaneous partial nitrification, anammox, denitrification and fermentation process under intermittent aeration in a single reactor, and explored the impact of dissolved oxygen (DO) on the synergy between fermentation and nitrogen removal. An advanced nitrogen removal efficiency of 92.8 % and a low observed sludge yield of 0.0268–0.1474 kgMLSS/kgCOD were achieved. In-situ test showed that nitrate and ammonium decreased synchronously in the absence of organic matter, indicating the possibility of simultaneous partial denitrification, anammox and fermentation. Additionally, the abundance of functional genes for acetate production was 66,894 hits, while the key genes relevant to methanogenesis were only 348 hits, which suggested that fermentation might stop at the acid-producing stage and promote partial denitrification-anammox reaction, achieving simultaneous sludge reduction and advanced nitrogen removal performance. When DO increased from 0.1–0.3 to 0.4–0.6 mg/L, the nitrogen removal efficiency was increased (63.9 %→92.8 %) while sludge reduction was negatively affected.

energy & fuels,biotechnology & applied microbiology,agricultural engineering
Modeling Simultaneous Autotrophic and Heterotrophic Growth in Aerobic Granules.

Bing-Jie Ni,Han-Qing Yu,Yu-Jiao Sun

DOI: https://doi.org/10.1016/j.watres.2007.11.010

IF: 12.8

2008-01-01

Water Research

Abstract:A mathematical model has been developed to describe the simultaneous autotrophic and heterotrophic growth in granule-based sequencing batch reactors (SBRs). Experimental results of a laboratory-scale granule-based SBR are used to calibrate and validate the model. The model is able to simulate the reactor performance and gain insight in autotrophic and heterotrophic growth in the granules. With the established model, the fractions of active biomass (autotrophs and heterotrophs) and inert biomass are predicted to be 55.6% and 44.4% of the total mixed liquid volatile suspended solid, respectively, at a solids retention time (SRT) of 20 days. Biomass content increases with increasing SRT, but active biomass ratio decreases. Autotrophs have no significant effect on the total biomass content, although they play an important role in nitrogen removal. Simulation results also demonstrate the key role of the influent substrate and NH(4)(+)-N in governing the composition of heterotrophic and autotrophic biomass in a granule-based SBR. The autotrophs are mainly located on the outer layer of granules, whereas the heterotrophs are present in the center of granules, or on the outer layer of granules.

Modeling of Simultaneous Partial Nitrification, Anammox and Denitrification Process In a Single Reactor

Evaluation of mainstream nitrogen removal by simultaneous partial nitrification, anammox and denitrification (SNAD) process in a granule-based reactor

Granulation of Simultaneous Partial Nitrification and Anammox Biomass in One Single SBR System

Simultaneous Ammonia and Nitrate Removal in an Airlift Reactor Using Poly(butylene Succinate) As Carbon Source and Biofilm Carrier.

Simultaneous Nitrification–denitrification and Microbial Community Profile in an Oxygen-Limiting Intermittent Aeration SBBR with Biodegradable Carriers

Characterization and Quantification of Anammox Start-Up in UASB Reactors Seeded with Conventional Activated Sludge

Achieving single‐stage partial nitritation and anammox (PN/A) using a submerged dynamic membrane sequencing batch reactor (DM‐SBR)

Cultivation, Granulation and Characteristics of Anaerobic Ammonium-Oxidizing Sludge in Sequencing Batch Reactor

Achieving advanced nitrogen removal and excess sludge treatment via single nitritation/anammox-fermentation combined system

Granulation of nitritation sludges in sequencing batch reactor

Anammox start-up in sequencing batch biofilm reactors using different inoculating sludge

Operation of a Sequencing Batch Reactor for Cultivating Autotrophic Nitrifying Granules.

Modeling the partial nitrification in sequencing batch reactor for biomass adapted to high ammonia concentrations

The development of simultaneous partial nitrification, ANAMMOX and denitrification (SNAD) process in a single reactor for nitrogen removal.

Start-up of the Simultaneous Nitrification, Anammox, and Denitrification (SNAD) Reactor and Efficacy of a Small Amount of Organic Carbon

Simultaneous partial nitritation, anammox, and denitrification process for the treatment of simulated municipal sewage in a single-stage biofilter reactor

Partial nitrification granular sludge reactor as a pretreatment for anaerobic ammonium oxidation (Anammox): Achievement, performance and microbial community

Mathematical simulation and experimental verification of a novel control strategy for a single stage PN/A (partial nitrification/Anammox) SBR (sequencing batch reactor)

Application of a Partial Nitrogen Lab-Scale Sequencing Batch Reactor for the Treatment of Organic Wastewater and Its N2O Production Pathways, and the Microbial Mechanism

A novel simultaneous partial nitrification, anammox, denitrification and fermentation process: Enhancing nitrogen removal and sludge reduction in a single reactor

Modeling Simultaneous Autotrophic and Heterotrophic Growth in Aerobic Granules.