Abstract:Materials, such as electrical wire, used in spacecraft must pass stringent fire safety standards. Tests for such standards are typically performed under normal gravity conditions and then extended to applications under microgravity conditions. The experiments reported here used polyethylene (PE)-insulated (thickness of 0.15mm) Nichrome (NiCr)-core (diameter of 0.5mm) electrical wires. Limiting oxygen concentrations (LOC) at extinction were measured for upward spreading flame at various forced opposed-flow (downward) speeds (0−25cm/s) at several inclination angles (0−75°) under normal gravity conditions. The differences from those previously obtained under microgravity conditions were quantified and correlated to provide a reference for the development of fire safety test standards for electrical wires to be used in space exploration. It was found that as the opposed-flow speed increased for a specified inclination angle (except the horizontal case), LOC first increased, then decreased and finally increased again. The first local maximum of this LOC variation corresponded to a critical forced flow speed resulted from the change in flame spread pattern from concurrent to counter-current type. This critical forced flow speed correlated well with the buoyancy-induced flow speed component in the wire's direction when the flame base width along the wire was used as a characteristic length scale. LOC was generally higher under the normal gravity than under the microgravity and the difference between the two decreased as the opposed-flow speed increases, following a reasonably linear trend at relatively higher flow speeds (over 10cm/s). The decrease in the difference in LOC under normal- and microgravity conditions as the opposed-flow speed increases correlated well with the gravity acceleration component in the wire's direction, providing a measure to extend LOC determined by the tests under normal gravity conditions (at various inclination angles and opposed-flow speeds) to LOC under microgravity conditions.

A113 Ignition of Electric Wire Insulation Caused by Continuous Excess Current Supply in Microgravity

Identifying two ignition modes of polymer insulated wires with continuous excess current in microgravity

T0501-4-7 A Study on Wire Insulation Ignition Induced by Short-term Excess Electric Current Application by using Microgravity Condition

Effect of Ignition Condition on the Extinction Limit for Opposed Flame Spread Over Electrical Wires in Microgravity

Effect of pyrolysis kinetic parameters on the overload ignition of polymer insulated wires in microgravity

Study on the pre-ignition temperature variations of wire insulation under overload conditions in microgravity by the functional simulation method

Ignition Delay of Fluorinated Ethylene Propylene Wire Insulation in a Forced Flow Field in Microgravity

Study on Fire Initiation of Wire Insulations on Board the Satellite

Limiting Oxygen Concentration for Extinction of Upward Spreading Flames over Inclined Thin Polyethylene-Insulated NiCr Electrical Wires with Opposed-Flow under Normal- and Micro-Gravity

STUDY ON FIRE PRECURSOR OF WIRE INSULATION IN LOW-PRESSURE ENVIRONMENTS

Study on Wire Insulation Flammability at Microgravity by Functional Simulation Method

Downward Flame Spread over Thin Electrical Wires in Quiescent Normal- and Hypergravity Environments: Effects of Gravity Level, Applied Current and Wire Configuration

Experimental Study of Spontaneous Ignition of Overloaded Electrical Wires under Transverse Wind

Dripping and Fire Extinction Limits of Thin Wire: Effect of Pressure and Oxygen

Downward Flame Spread over Electrical Wires in Quiescent Low Pressures: Similarity Analysis and Comparison with Partial-Gravity Experiments

Ignition and Flame Propagation of Externally Heated Electrical Wires with Electric Currents

Influence of Insulating Coating on Aluminum Wire Explosions

Sub-atmospheric Bursting Ignition of Fluorinated Ethylene Propylene Wire Insulation

Morphology and Concentration of Smoke from Fluorinated Ethylene Propylene Wire Insulation in Microgravity under Forced Airflow.

Experimental Investigation on the Energy Deposition and Expansion Rate under the Electrical Explosion of Aluminum Wire in Vacuum

Experimental Investigation on the Electrical Explosion of Single Aluminum Wire in Vacuum