Abstract:In order to solve the problem of gas over limit near the return air trough of W-type ventilated working face, a method combining numerical simulation and on-site measurement was used to study the spatial and temporal distribution characteristics of gas in the goaf under the W-type ventilated mode, and the reliability of the model was verified. Delineate the gas-rich area and suitable pumping area in the goaf, by analyzing the pumping of the top plate high-level directional borehole in the area, optimize the best layout of the top plate high-level directional borehole. The results show: The gas concentration in the goaf gradually increases from shallow to deep in the direction, and increases rapidly in the range of 0–75 m; in the direction of inclination, it is approximately symmetrically distributed along the axis of the return air trough, and gradually decreases toward the air inlets on both sides. The gas concentration in the middle area of the working face is higher than 0.85%; in the vertical direction, the further away from the coal seam roof, the higher the gas concentration, but the growth rate decreases, and the range of high gas concentration gradually expands. The gas concentration of the goaf reflected by the changes in the concentration of the working face has gradually increased in the early stages of mining. and then changes periodically with the cycle of roof pressure in the later stage. There is a strong correlation between the amount of gas emission the goaf and the mining speed of the working face. The regularity of the simulation result is the same as the regularity of the measured results, and the absolute value of the relative error is within 10%, that the concentration of extraction from high-level directional borehole increases with the height of the arrangement, mixed and pure volume decreases with the height of the arrangement. Comparison of the average mixed volume, concentration, pure volume and total extraction volume of each high-level directional borehole, it can be seen that the average pure volume from 3#holes is 3.9 times higher than that from 1#holes, and the total extraction volume accounts for 29% of the total extraction volume from the drill site, it is obtained that the best layout of the high-level directional boreholes of the 3203 working face is between 25 and 35 m above the top board. During the high-level drilling period, the gas concentration in the return air trough was between 0.42% and 0.75%, which effectively prevented the occurrence of gas over limit accidents.

Measuring Technology of Ventilation Leakage in the Goaf of False-inclined Flexible Shield Support Working face by Using Multi- element Tracer Gas

Numerical analysis and control technology of gas accumulation in a large-scale specially-shaped tunnel passing through coal bearing strata

Research on complex air leakage method to prevent coal spontaneous combustion in longwall goaf

Study on air leakage and gas distribution in goaf of Y-type ventilation system

Distribution and Prevention of CO in a Goaf of a Working Face with Y-Type Ventilation

Study on the air leakage characteristics of a goaf in a shallow coal seam and spontaneous combustion prevention and control strategies for residual coal.

Measurement and Numerical Simulation of Coal Spontaneous Combustion in Goaf under Y-type Ventilation Mode

Numerical simulation and investigation of methane gas distribution and extraction in goaf with U-type ventilation of working face

A Novel Failure Control Technology of Cross-Measure Borehole for Gas Drainage: A Case Study

Prevention and Control Technology for Harmful Toxic Gas Intrusion in High-Fire-Hazard-Risk Areas of Close-Distance Coal Seams

Tracer Test Method to Confirm Hydraulic Connectivity Between Goafs in a Coal Mine

Research on Simulation Technology of Surface Air Leakage of Shallow-Buried Goaf Based on Network Calculation

Investigation on the potential hazard zone of gas explosion in the goaf under longwall top caving coal mining condition

Analyzing on Air-Leakage Condition of Gate in Fully-Mechanized Long-Wall Top-Coal Caving Mining Face

Performance analysis of vertical goaf gas drainage holes using gas indicators in Australian coal mines

A method for identifying the fire status through ventilation systems using tracer gas for improved rescue effectiveness in roadway drivage of coal mines

Comprehensive Gas Prevention and Control Technique for Mining the First Seam in Short-Distance Outburst Coal Seam Groups

Study on the Application of Comprehensive Gas Control Technology for Source-Separated Three-Dimensional Gas Extraction in Large Mining Faces

Detection of Underground Geological Structure by Radio-wave Laneway Penetration Technology

Characterization of spatiotemporal distribution of gas in the goaf of W-type ventilated working face

Porosity model and air leakage flow field simulation of goaf based on DEM-CFD