Abstract:Trucking is a key industry in Canada with around 180 000 professional drivers. As an industry it has a disproportionately high injury claim rate, particularly for back injuries. Whole-body vibration (WBV) can contribute to the onset and development of low back disorders, and is a well-documented exposure among driving professions. A widely adopted WBV mitigation measure focuses on hydraulic and/or pneumatic passive suspension systems both in the driver's seat and underneath the vehicle cab. Passive suspension 'air-ride' seats are the current industry standard but new technologies such as the electromagnetic active vibration cancelling (EAVC) seats offer potentially substantial improvements in WBV reduction. In this paper, we evaluate and compare four commonly used truck seats (three air-ride, one EAVC) for their vibration damping characteristics and WBV exposure attenuation in on- and off-road conditions. We recruited 24 professional truck drivers who drove 280 km (mixed on-road and off-road) in ore-haul trucks under four different seating conditions. Following the ISO 2631-1 WBV standard, vibration measurements were made on the cab floor and seat pad, and 8-h average weighted vibration (A(8)) and 8-h vibration dose values (VDV(8)) were calculated, as well as the Seat Effective Amplitude Transmissibility (SEAT), and daily vibration action limits (DVALs). These measures were compared between seat types, as well as road conditions. The EAVC seat gave best performance for both A(8) (0.27 m s-2) and VDV(8) (6.6 m s-1.75). The EVAC seat had the lowest SEAT tested (36.2%) and the longest DVAL. However, among the three passive air-suspension seats, two showed significantly reduced A(8) (0.43 and 0.44 m s-2) and VDV(8) (9.1 and 9.3 m s-1.75) exposures relative to the third passive air-suspension seats [A(8) (0.54 m s-2) and VDV(8) (11.1 m s-1.75)]. These differences in exposures among the three passive air-suspension seats resulted in varying DVAL times, with the worst performing seat reaching the DVAL after only 6.3 h of driving. There was also a seat by road type interaction; there were performance differences between the passive air-suspension seats on-road, but not off-road. The observed reduction of the WBV exposures measured from the EAVC seat was consistent with previous results. But we showed that there can also be substantive differences among seats that are the current industry standard. These differences were more evident on-road than off-road, which suggests that more work needs to be done to understand seat performance characteristics, and in matching the correct seat technology to the driving task. We demonstrated that WBV exposures in current industry conditions may exceed health-based exposure limits; this has policy relevance because WBV exposures are linked to prevalent and costly adverse health conditions in a working population that is ageing. Increased WBV measurement collection is recommended to ensure the anticipated exposure attenuations are achieved when seats are relied upon as an engineered control against WBV.

A Randomized Controlled Trial of a Truck Seat Intervention: Part 1—Assessment of Whole Body Vibration Exposures

A Randomized Controlled Trial of a Truck Seat Intervention: Part 2-Associations Between Whole-Body Vibration Exposures and Health Outcomes

The effects of a new seat suspension system on whole body vibration exposure and driver low back pain and disability: Results from a randomized controlled trial in truck drivers

Exposure to Whole-Body Vibration in Commercial Heavy-Truck Driving in On- and Off-Road Conditions: Effect of Seat Choice

Whole-body Vibration Exposure Intervention among Professional Bus and Truck Drivers: A Laboratory Evaluation of Seat-suspension Designs

The impact of different seats and whole-body vibration exposures on truck driver vigilance and discomfort

The effects of different seat suspension types on occupants' physiologic responses and task performance: implications for autonomous and conventional vehicles

Vertical-dominant and multi-axial vibration associated with heavy vehicle operation: Effects on dynamic postural control

Evaluation of vertical and multi-axial suspension seats for reducing vertical-dominant and multi-axial whole body vibration and associated neck and low back joint torque and muscle activity

Study on the Effect of Semi-Active Control Method Matching for Truck Cab and Seat Suspension on Driver Comfort

Experiment and optimisation analysis of whole-body vibration among tractor drivers: a comprehensive study

Low Back Pain and Whole Body Vibration

Vehicle design influences whole body vibration exposures: effect of the location of the front axle relative to the cab

Evaluation of an occupational health intervention programme on whole-body vibration in forklift truck drivers: a controlled trial

Combined Effects of Long-Term Sitting and Whole-Body Vibration on Discomfort Onset for Vehicle Occupants

Biomechanical Response of the Musculoskeletal System to Whole Body Vibration Using a Seated Driver Model

Advancing the Safety, Health, and Well-Being of Commercial Driving Teams Who Sleep in Moving Semi-Trucks: The Tech4Rest Pilot Study

Effects of a seat-integrated mobilization system on long-haul truck drivers motion activity, muscle stiffness and discomfort during a 4.5-h simulated driving task

Three-axial evaluation of whole-body vibration in agricultural telehandlers: The effects of an active cab-suspension system

Smart whole-body vibration attenuation, cushion for heavy equipment seating: Model and simulation

Effects of seat back height and posture on 3D vibration transmission to pelvis, trunk and head