Abstract:As a biomass-based renewable fuel, n-butanol has many superior properties, such as better miscibility in diesel, higher energy content and higher cetane number, which make it an attractive alternative or blending component to diesel fuel compared with its alcohol competitors, methanol and ethanol. Although n-butanol has so many advantages, literature on the effects of its addition on diesel engines are still not sufficient. In this study, the influences of n-butanol addition on the performance and emissions of a turbocharged common-rail diesel engine are investigated under different speed and load conditions. The fuel consumption rate and the gaseous emissions (CO, CO 2, HC, and NOx) are measured. Moreover, an electrical low pressure impactor (ELPI) is utilized to study the particulate matter (PM) number-size distributions under different conditions. The results show that as more n-butanol is added, the brake fuel specific consumption is increased while only a slight variation of the fuel conversion efficiency is found. As for the gaseous emissions, the concentration of CO and CO2 remain almost unchanged, the HC emission increases obviously, and the NOx emission is slightly reduced except for the high-speed-high-load condition. Under a specific speed-load condition, the peak number concentration of PM decreases apparently with the increase of the n-butanol blending ratio. Moreover, the peak number size of PM becomes smaller when n-butanol is added under the high load conditions. The results indicate that n-butanol has the merits to reduce the PM emission without significantly affecting the performance and the other emission characteristics of a diesel engine. However, further investigations are still required to evaluate and address the potential problems that may be caused by the use of n-butanol, such as the emissions of toxic oxygenated compounds, the unacceptable in-tank flammability limit and the lower fuel lubricity. Copyright © 2012 SAE International.

Effect of Combustion Boundary Conditions and n-Butanol on Surrogate Diesel Fuel HCCI Combustion and Emission Based on Two-Stroke Diesel Engine

Investigation of Butanol-Fuelled HCCI Combustion on a High Efficiency Diesel Engine

Comparative Analysis of Effect of Diesel and N-Butanol Blend Properties on Combustion Process and Hydrocarbon Emission at Various Oxygen-Intake Concentrations

Experimental Study Of The Effect Of Intake Oxygen Concentration On Engine Combustion Process And Hydrocarbon Emissions With N-Butanol-Diesel Blended Fuel

Synergic effect of hydrogen and n-butanol on combustion and emission characteristics of a hydrogen direct injection SI engine fueled with n-butanol/gasoline

Effects of Combustion Parameters on Emissions of Diesel Diesel/n-Butanol, and Diesel/n-Butanol/2-Ethylhexyl Nitrate Fuels at Different Intake-Oxygen Concentrations in a Diesel Engine

Effects of Intake Components on Combustion and Emission Characteristics in an n -Butanol/Diesel Blend Fueled Engine

Effect of Premixed N-Butanol Ratio on the Initial Stage of Combustion in a Light-Duty Butanol/Diesel Dual-Fuel Engine

EFFECTS OF N-BUTANOL CONTENT ON THE DUAL-FUEL COMBUSTION MODE WITH CNG AT TWO ENGINE SPEEDS

N-Butanol Reactivity Modulation with Early Fuel Injections for Low NOx Compression Ignition Combustion

An Experimental Study on Combustion and Cycle-by-Cycle Variations of an N-Butanol Engine with Hydrogen Direct Injection under Lean Burn Conditions

Study on Combustion and Emission Characteristics of a N-Butanol Engine with Hydrogen Direct Injection under Lean Burn Conditions

Emission, efficiency, and influence in a diesel n-butanol dual-injection engine

Combustion, performance and emission caracteristics of a HCCI engine fuelled with n-butanol/n-heptane blends

Combustion and Emissions of Isomeric Butanol/gasoline Surrogates Blends on an Optical GDI Engine

A Comparative Study of Combustion and Emission Characteristics of Butanol Isomers on a Diesel Engine with Dual Fuel Butanol Isomers/diesel Compound Combustion

Effects of n-butanol addition on the performance and emissions of a turbocharged common-rail diesel engine

Temperature, Combustion, and Emissions on a Diesel Engine Using N-Butanol/Diesel Compound Combustion Mode

Effect of gasoline additive on combustion and emission characteristics of an n-butanol Partially Premixed Compression Ignition engine under different parameters

Experimental Study on the Effects of Injection Timing and N-Butanol Energy Ratio on Combustion and Emissions of N-Butanol/diesel DFDI Engine

Experimental investigation on the combustion and emissions characteristics of an N-butanol/CTL dual fuel engine