Abstract:The effects of the cobalt particle size in the range of 6.5–26.3 nm on the catalyst structural transformation and methane selectivity evolution in Fischer–Tropsch synthesis (FTS) have been investigated. In situ X-ray diffraction experiments revealed that cobalt was maintained as CoO under a reaction environment when initial Co3O4 particles on SiO2 were below 8.4 nm. The large metallic Co particles can keep a stable size and phase state, indicating almost unchanged catalytic activity and methane selectivity. In contrast, small metallic Co or CoO particles show a gradual increase in methane selectivity with time on stream. Stable large metallic Co particles can be explained as the dominant surface high-coordinated Co atoms having a weak binding ability for H2O molecules, which are more difficult to be oxidized into CoO. It is believed that CoO rather than metallic Co atoms could interact with Si-OH groups to form inactive cobalt silicate (Co2SiO4), which leads to a higher methane selectivity and drives a decrease in the particle size during the FTS reaction. ZrO2 as a structural promoter highly dispersed on SiO2 was found to give a milder increase in methane selectivity due to fewer chances of Si-OH interacting with CoO species. Density functional theory (DFT) calculations combined with CO temperature-programmed desorption (CO-TPD), NH3-TPD, CO2-TPD, and Py-IR demonstrate that Co/ZrO2 interfacial sites play a crucial role in enhancing the catalytic activity as the electron accumulation in the interface region not only increases the CO adsorption amount but also promotes the CO dissociation on cobalt sites. At the same time, a higher surface C*/H concentration benefits a lower methane selectivity. ZrO2, which acts as a Lewis acid, can adsorb CO molecules abundantly but weakly by the interaction between Zr4+ cations and O atoms in CO. Especially, for the 15Co(C)/Q15 catalyst with initial CoO particles on SiO2, methane selectivity rapidly increases at an early reaction stage, which originates from easier accessible CoO reacting with Si-OH groups. In addition, both 15Co(C)/Q15 and 15Co(C)/10Zr(I)-Q15 catalysts show the dominant CoO phase, which is active in the FTS reaction. Indeed, the DFT calculations demonstrate that CO activation on the CoO(200) surface via the H-assisted CH2O dissociation pathway exhibits a lower activation energy of 1.21 eV compared to that on the face-centered cubic (fcc) Co(111) surface with an activation energy of 1.42 eV, despite that direct CO dissociation, CHO dissociation, and CHOH dissociation on CoO(200) show higher activation energies. This study provides a prime scientific understanding about regulating catalytic activity and methane selectivity.

Crystal-Plane-Dependent Fischer–Tropsch Performance of Cobalt Catalysts

Crystal-Plane-Dependent Fischer–Tropsch Performance of Cobalt Catalysts

Role of well-defined cobalt crystal facets in Fischer-Tropsch synthesis: a combination of experimental and theoretical studies.

Crystal plane effects of CeO2 on supported cobalt and its catalytic performance for Fischer-Tropsch synthesis

Crystal facet dependence of carbon chain growth mechanism over the Hcp and Fcc Co catalysts in the Fischer-Tropsch synthesis

Visualizing Phase Evolution of Co2C for Efficient Fischer‐Tropsch to Olefins

Crystallographic dependence of carbon deposition in the Fischer-Tropsch synthesis over cobalt catalysts: HCP versus FCC

Supported Cobalt Nanoparticles with a Single Active Phase for Fischer–Tropsch Synthesis

Crystal Plane Effect of Fe2o3 with Various Morphologies on Co Catalytic Oxidation

Facet sensitivity of iron carbides in Fischer-Tropsch synthesis

Atomic-scale understanding of the impact of CoO phase in cobalt-catalyzed fischer-tropsch synthesis: A combined computational and experimental study

Crystallographic Dependence of Co Activation on Cobalt Catalysts: Hcp Versus Fcc

Fischer–Tropsch Synthesis: ZIF-8@ZIF-67-Derived Cobalt Nanoparticle-Embedded Nanocage Catalysts

Crystal plane-dependent electrocatalytic activity of Co 3 O 4 toward oxygen evolution reaction

Tuning Interaction Between Cobalt Catalysts and Nitrogen Dopants in Carbon Nanospheres to Promote Fischer-Tropsch Synthesis

Fischer–Tropsch Synthesis: Oxidation of a Fraction of Cobalt Crystallites in Research Catalysts at the Onset of FT at Partial Pressures Mimicking 50 % CO Conversion

Microstructure Evolution of a Co/MnO Catalyst for Fischer‐Tropsch Synthesis Revealed by In Situ XAFS Studies

Particle-Size-Dependent Methane Selectivity Evolution in Cobalt-Based Fischer–Tropsch Synthesis

In Situ XRD Study on Stability and Performance of Co3C Catalyst in Fischer–Tropsch Synthesis

Boosting the Fischer-Tropsch Synthesis Performances of Cobalt-Based Catalysts Via Geometric and Electronic Engineering: Construction of Hollow Structures