Abstract:Rapid and sensitive H2 detection is important because of its low threshold for the formation of explosive mixtures in air (∼4%). Palladium's unique interactions with H2 make it particularly useful in room-temperature H2 sensing, but the formation of water by reaction with O2 at the Pd surface can interfere with sensor response. Here, we report H2 sensors using networks of high aspect ratio and ultrathin reduced graphene oxide (rGO)-coated palladium nanowires (Pd ) with a coating of zeolite imidazole framework (ZIF-8) that serves as a nanofiltration layer. We first produced Pd NWs in high yield by a hydrothermal method, then sonicated them with GO and added a reducing agent to produce Pd Thin Pd NWs promote rapid response and high sensitivity, while rGO prevents the formation of additional conductive channels due to expansion of Pd NWs upon H2 exposure, ensuring monotonic sensor response. The coating of ZIF-8 reduces the transport of molecules like oxygen and nitrogen to the Pd NWs while allowing H2 to reach them and H2O to diffuse away from them. The optimized sensors showed a response (relative change in resistance) to 1% H2 in air of up to 2%, with a response time of 5 s and a lower limit of detection of 20 ppm. Relative to previously reported Pd-based H2 sensors with fast response, the Pd @ZIF-8 nanocomposite-based device provides a low-cost, high-performance sensor solution for fuel-cell vehicles and similar applications that require both rapid and sensitive H2 detection.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acsanm.1c01348.FTIR spectra of GO and Pd ; representative EDS spectrum of a bulk Pd nanocomposite material; EDS spectrum of an individual Pd as obtained from STEM imaging; SEM image of a Pd sensor, SEM image of a Pd @ZIF-8 sensor and corresponding elemental mapping of the sensor; XPS spectrum of Pd for (a) Ca 2P, (b) O 1s; Pd NWs (c) C 1s, (d) O 1s; hysteresis curve and the corresponding dynamic H2 sensing curve for Pd NWs; response vs H2 concentration curve of and @ZIF-8 sensors; TEM images, dynamic H2 sensing performance, and EDS spectra of 2 ; comparison of sensor response to repeated exposure to 1% H2; response, response time, and recovery time of Pd NWs, Pd , and Pd @ZIF-8 H2 sensor; the response of @ZIF-8 sensor to 100 ppm of H2, CO, CH4, and CO2; and comparison of dynamic H2 sensor performance of the Pd @ZIF-8 sensor on day 1 and on day 150 (PDF)This article has not yet been cited by other publications.

High performance H2 sensor based on rGO-wrapped SnO2–Pd porous hollow spheres

Ultralow detection limit and ultrafast response/recovery of the H2 gas sensor based on Pd-doped rGO/ZnO-SnO2 from hydrothermal synthesis

Sensitive H2 Gas Sensors Based on SnO2 Nanowires

Hydrothermal synthesis of Pd-doped rGO/ZnO-SnO2 nanocomposites for efficient hydrogen detection

Reduced Graphene Oxide-Wrapped Palladium Nanowires Coated with a Layer of Zeolitic Imidazolate Framework-8 for Hydrogen Sensing

Fabrication of Pd-loaded α-Fe2O3 decorated rGO hybrids for highly sensitive H2 sensing

Highly sensitive and stable H2 gas sensor based on p-PdO-n-WO3-heterostructure-homogeneously-dispersing thin film

Low Operating Temperature Hydrogen Sensor Based On Sno2 Hollow Nanospheres

Hydrogen Gas Sensor Based on SnO2 Nanospheres Modified with Sb2O3 Prepared by One-Step Solvothermal Route

Pd nanoparticles decorated SnO 2 ultrathin nanosheets for highly sensitive H 2 sensor: Experimental and theoretical studies

A room-temperature chemiresistive NO2 sensor based on one-step synthesized SnO2 nanospheres functionalized with Pd nanoparticles and rGO nanosheets

Low-temperature Hydrogen Detection Sensor Based on CeO2 -DOPED SnO2

Ultrasensitive and Wide-Range Flexible Hydrogen Sensor Based on Pd Nanoparticles Decorated Ultrathin SnO<sub>2</sub> Film

In-situ synthesis of needle-like PdO-decorated NiO thin films on Al2O3 substrates for high-performance H2 sensors

High performance H 2 sensors based on NiO-SnO 2 nanosheets in temperature-pulsed operation mode

One-step preparation of flexible rGO/ZnO gas sensors for ppm-level H2S detection

Two-Dimensional Dy2O3-Pd-PDA/rGO Heterojunction Nanocomposite: Synergistic Effects of Hybridisation, UV Illumination and Relative Humidity on Hydrogen Gas Sensing

A Highly Sensitivity and Selectivity Pt-SnO2 Nanoparticles for Sensing Applications at Extremely Low Level Hydrogen Gas Detection

Hollow Cu2O nanospheres loaded with MoS2/reduced graphene oxide nanosheets for ppb-level NO2 detection at room temperature

Cyanogel‐Transformed Porous Palladium and Iron Framework Intermixed with rGO for Wearable Hydrogen Sensing

Highly responsive and selective ppb-level NO<sub>2</sub> gas sensor based on porous Pd-functionalized CuO/rGO at room temperature