Abstract:Ultrasonic treatment has attracted much attention because of its physical and chemical effects that are distinct from those of chemical agents. In particularly, high-frequency ultrasound is known as an effective method because the theoretical resonance frequency of the gas vesicles in Microcystis aeruginosa is in the high frequency range (>100 kHz), which causes gas vesicles collapse and changes the settleability of the algal cells. In this work, the effects of the ultrasonic frequency, acoustic power density and duration on enhancing coagulation to remove turbidity in algae-laden water were studied. In order to explain the mechanism, the morphology of algae cells, the changes in extracellular organic substances, the zeta potential and the formation of hydroxyl radicals were analyzed systematically. Finally, Zeta potentials and flocs morphology after adding PAC were investigated to verify the mechanism. The results showed that the frequency exhibited fewer effects than power and duration on coagulation. SEM images showed that there were more severe cellular damages at 430 and 740 kHz than other frequencies. Sonication could cause the collapse of gas vesicle inside the cell, which was due to the instantaneous high pressure generated by the ultrasonic cavitation instead of the resonance. Furthermore, sonication would result in an increase in proteins in extracellular organic matter (EOM) with continuous ultrasonic irradiation, indicating that a small amount of proteins could promote coagulation and that the accumulation of proteins would inhibit coagulation. Free radical content testing showed that the production of excessive free radicals was often accompanied by a deterioration of the coagulation. The proper mechanical effects were the main mechanism of ultrasonic enhanced coagulation. Thus, it was recommended that the appropriate ultrasonic condition was the one that resulted in a small amount of protein leakage and little generation of free radicals, which occurred at 740 kHz and 0.02 W/mL in approximately 5 min, and would significantly enhance the turbidity removal rate in algae-containing water from approximately 80-90%.

Microalgae Chlorella sp. cell disruption efficiency utilising ultrasonication and ultrahomogenisation methods

Cell Disruption of Chaetoceros calcitrans by Microwave and Ultrasound in Lipid Extraction

Effect of cell disruption methods on the extraction of bioactive metabolites from microalgal biomass

Cell disruption for microalgae biorefineries

Combination of cell disruption method and pH variation as pre-treatment for lipid extraction of Nannochloropsis sp.

Combined Enzymatic and Mechanical Cell Disruption and Lipid Extraction of Green Alga Neochloris oleoabundans

Effect of Ultrasonic Irradiation on the Coagulation and Inactivation of Microcystis

Effectiveness of Parachlorella kessleri cell disruption evaluated with the use of laser light scattering methods

Ultrasound-assisted processing of Chlorella vulgaris for enhanced protein extraction

Using wet microalgae for direct biodiesel production via microwave irradiation

Resuspended freeze-dried Nannochloropsis as a model laboratory system for concentrated fresh Nannochloropsis in ultrasound cell disruption experiments

New Approaches for the Use of Non-conventional Cell Disruption Technologies to Extract Potential Food Additives and Nutraceuticals from Microalgae

Application of high shear-assisted liquid biphasic system for protein extraction from Chlorella sp

Hydrothermal microwave processing of microalgae as a pre-treatment and extraction technique for bio-fuels and bio-products

Enhancing microalgal cell wall permeability by microbubble streaming flow

Fractal Microstructure Characterization of Wet Microalgal Cells Disrupted with Ultrasonic Cavitation for Lipid Extraction.

Enhanced VFAs production from microalgal hydrolytic acidification with ultrasonic-alkali pretreatment

Cell Disruption and Pressurized Liquid Extraction of Carotenoids from Microalgae

Enhanced coagulation by high-frequency ultrasound in Microcystis aeruginosa-laden water: Strategies and mechanisms

Dynamic Microstructures and Fractal Characterization of Cell Wall Disruption for Microwave Irradiation-Assisted Lipid Extraction from Wet Microalgae

Optimization of cell disruption methods for efficient recovery of bioactive metabolites via NMR of three freshwater microalgae (chlorophyta)