Abstract:In situ methane enrichment method can increase the methane content in biogas, which is a cost-effective technology used for producing bio-methane compared with conventional biogas upgrading technologies. During the in situ methane enrichment process, liquid stream from the anaerobic digester is circulated through a CO2-desorption unit and then returned back to the digester. The most important step in this process is CO2 desorption. In this study we evaluated the effects of different CO2 desorption techniques. Three CO2 desorption methods including air stripping, vacuum extraction and ultrasonic-auxiliary air stripping were studied through experiments. The experiments were conducted under mesophilic (38℃) anaerobic digestion by using synthetic wastewater with glucose and supplemental nutrients. The experimental apparatus included one anaerobic digester with volume of 1 500 mL and two CO2-desorption bottles with volume of 500 mL used for air stripping and vacuum extraction respectively. The results showed that the average volume fraction of methane in biogas reached 76.4%and 78.3%for the air stripping groups (aeration fluxes of 205 mL/min and daily stripping time of 30min), and increased by 17%and 20%compared to the control (65.4%) with the daily recycle rates of liquid stream (DRR) at 0.2 L/(L·d) and 0.4 L/(L·d), respectively. The cumulative methane production is similar to controlled one for the group with DRR of 0.2 L/(L·d). But the cumulative methane production decreased by 15%compared with control one for the group with DRR of 0.4 L/(L·d). In situ methane enrichment effect of the group of CO2 vacuum extraction with 0.1 MPa vacuum maintaining 5 min was slightly lower than that of the air stripping group with aeration flux at 205 mL/min, daily stripping time 20min and DDR 0.2 L/(L·d). The methane volume fraction of biogas in the first group was decreased by 4.6% compared to that of the second group. However, the difference is not significant (P>0.05). The results of experiment of ultrasonic-auxiliary air stripping, with aeration flux of 100 mL/min, daily stripping time of 21 min and ultrasonic frequency of 40 kHz, show that ultrasonic wave can accelerate CO2 air stripping, especially when the concentration of CO2 in the liquid was high. During the initial 3 min of stripping the CO2 removing rate of ultrasonic-auxiliary air stripping group was advanced by 32%compared to air stripping group. The total free CO2 removal amount from the liquid stream was increased by 29.8% compared to air stripping group during the whole stripping time of 21 min. Furthermore, ultrasonic wave has potential advantages on CO2 removing by lowering pH of liquid and increasing anaerobic digestion efficiency through decomposing many complex organic compounds. Therefore, the effect of air stripping and vacuum extraction on methane enrichment has no significance difference, but vacuum extraction has no problem of oxygen inhibition, the control of which is vital for successful running of in situ methane enrichment process of air stripping. Ultrasonic-auxiliary air stripping method has advantages for CO2 desorption due to its unique characteristics of lowering pH, degrading complex compounds and increasing CO2 removal.

Effects of H2:CO2 ratio and H2 supply fluctuation on methane content and microbial community composition during in-situ biological biogas upgrading

Effect of Ammonia Concentration on Hythane (H2 and CH4) Production in Two-Phase Anaerobic Digestion

Power to biogas upgrading: Effects of different H 2 /CO 2 ratios on products and microbial communities in anaerobic fermentation system

Integrated biogas upgrading and hydrogen utilization in an anaerobic reactor containing enriched hydrogenotrophic methanogenic culture.

Biological upgrading of biogas assisted with membrane supplied hydrogen gas in a three-phase upflow reactor

Simultaneous Hydrogen Utilization and in Situ Biogas Upgrading in an Anaerobic Reactor.

Application of In-Situ H2-assisted Biogas Upgrading in High-Rate Anaerobic Wastewater Treatment.

Co-digestion of Manure and Whey for in Situ Biogas Upgrading by the Addition of H2: Process Performance and Microbial Insights

Microbial Community Response to Ammonia Levels in Hydrogen Assisted Biogas Production and Upgrading Process.

Upgrading biogas produced in anaerobic digestion: Biological removal and bioconversion of CO2 in biogas

The intriguing effect of CO 2 enrichment in anaerobic digestion

Simultaneous biogas upgrading and single cell protein production using hydrogen oxidizing bacteria

Biomethanation processes: new insights on the effect of a high H2 partial pressure on microbial communities

Bioelectrochemical Removal of Carbon Dioxide (CO2): an Innovative Method for Biogas Upgrading.

Microbial Electrochemical CO2 Reduction and In-Situ Biogas Upgrading at Various pH Conditions

Hollow Fiber Membrane Based H 2 Diffusion for Efficient in Situ Biogas Upgrading in an Anaerobic Reactor

Effects of Iron-Loaded Biochar on the Anaerobic Co-Digestion of Food Waste and Sewage Sludge and Elucidating the Mechanism Thereof

Microbial Consortiums of Hydrogenotrophic Methanogenic Mixed Cultures in Lab-Scale Ex-Situ Biogas Upgrading Systems under Different Conditions of Temperature, Ph and CO

Simultaneous Biogas Upgrading and Valuable Chemical Production Using Homoacetogens in a Membrane Biofilm Reactor

Exogenous hydrogen supply improves in-situ biogas upgrading of sewage sludge: Performance and mechanisms

Influence of Techniques for Desorption of Carbon Dioxide on in Situ Methane Enrichment During Biogas Fermentation