Abstract:A power failure in the pump condition combined with the rejection of the guide vanes can cause the unit to runaway, which represents a dangerous transitional process for pumped storage power stations. This process is accompanied by intense oscillations in internal flow, pressure fluctuations, and changes runner forces. This study aims to clarify the unstable flow characteristics during the runaway process by focusing on the transient behaviour from the pump condition to the runaway condition in a high-head model pump turbine. The numerical calculation of the runaway speed and discharge are consistent with experimental test results. The results indicate that the dynamic curve is not continuously stable during the process but exhibits dynamic oscillations before reaching a relatively stable condition. Significant pressure fluctuations with high amplitudes are observed in the pump braking zone and close the runaway condition. Further analysis reveals low frequency, high amplitude pressure fluctuations within various flow components at frequencies smaller than the runner rotational frequency ( fn ). Axial forces demonstrate a linear correlation with the change rate of discharge. The dynamic evolution of the backflow vortex at the runner inlet is the main cause of significant fluctuations in the axial forces of the runner. The scale of the backflow vortex gradually increases as the discharge decreases, peaking in the pump braking zone. Entering the turbine operating condition, its intensity decreases to some extent but with a significantly expanded range. Near the optimal operating condition, the internal flow around the runner becomes smooth. As the discharge further decreases, the backflow vortex scale gradually increases, eventually forming a ring structure at the runner inlet. Further analysis indicates that the dynamic evolution of the backflow vortex at the runner inlet inevitably disrupts the flow, leading to a significant increase in pressure fluctuation amplitudes and more pronounced oscillations in axial forces.

Mechanism of Fast Transition of Pressure Pulsations in the Vaneless Space of a Model Pump-Turbine During Runaway

Distribution Features of Flow Patterns and Pressure Pulsations of Pump-Turbine in Five Operating Modes on the Four-Quadrant Plane

Dynamic and flow instability analysis during runaway process for a pump turbine

Differences of Flow Patterns and Pressure Pulsations in Four Prototype Pump-Turbines during Runaway Transient Processes

Pressure pulsation in small opening operating mode of pump turbine’s turbine mode

Pressure fluctuation characteristics of a model pump-turbine during runaway transient

Cavitation Mechanism in Turbine Runaway Process of a Pump-Turbine

Influence of Clearance Flow on Dynamic Hydraulic Forces of Pump-Turbine during Runaway Transient Process

Pressure pulsation of pump turbine at runaway condition based on Hilbert Huang transform

Evolution Mechanism of a Prototype Pump Turbine after Pump Power-off

Study on pressure fluctuation and rotating stall characteristics in the vaneless space of a pump-turbine in pump mode

Instability Flow Mechanism of Ultra-High Head Pumped-Storage Units During Turbine Runaway Process

Numerical investigation of hydraulic instability of pump-turbines in fast pump-to-turbine transition

Numerical simulation of the unstable flow phenomenon in a pump turbine at the load rejection conditions in turbine mode

Analysis of the Flow Behavior and Pressure Fluctuation of a Pump Turbine with Splitter Blades in Part-Load Pump Mode

Hydraulic Fluctuations During the Pump Power-off Runaway Transient Process of a Pump Turbine with Consideration of Cavitation Effects

Experimental Study of Pressure Fluctuations of A Pump-Turbine in Transient Period

Influence of Guide Vane Opening on the Runaway Stability of a Pump-Turbine Used for Hydropower and Ocean Power

Flow-induced Vibration Analysis of a Prototype Pump-Turbine Runner During Turbine Start-Stop Transient Process

Pressure fluctuations in the vaneless space of High-head pump-turbines—A review

Mechanism of High Amplitude Low Frequency Fluctuations in a Pump-Turbine in Pump Mode