Abstract:Atmospheric freeze drying (AFD) yields products of a similar quality to the conventional vacuum freeze-drying technique, but reduces the operating cost. However, it involves very low drying rates. The sample surface/mass ratio is one of the process variables that can be taken into account to reduce drying time. Moreover, power ultrasound (US) can also be used to intensify this process because of its effects on external and internal mass transfer resistance. However, both factors may affect not only the drying time but also the final product quality. Therefore, the aim of this study was to address the influence of both ultrasound application and the sample surface/mass ratio on the drying process and the antioxidant potential of atmospheric freeze-dried apple. For that purpose, two sample geometries with different surface/mass ratio were considered: slabs (30 × 30 × 10 mm3) and cylinders (diameter: 9 mm and height: 30 mm). The samples were freeze dried (−10°C) with ultrasound application (21.7 kHz) at different power levels (0, 10.3, 20.5, and 30.8 kW/m3). The total phenolic content (TPC), antioxidant capacity (AC), and ascorbic acid content (AA) were measured in the dried apple. The drying time was significantly shorter for cylindrical samples than for slabs, probably due to their higher surface/mass ratio. The application of US increased the drying rate, this increase being greater for the slab than for the cylindrical particles used in this study. In general, AFD reduced the TPC, AC, and AA, the final content being significantly greater for slabs than for cylinders. This fact can also be related to the lower surface/mass ratio in the case of slabs. US application further reduced TPC, AC, and AA content, probably due to some cellular damage produced by the acoustic waves and to the oxygen transfer improvement. Nevertheless, the bigger particles (slabs) dried with ultrasound needed a 10% of drying time than the smaller ones (cylinders) dried without ultrasound. Moreover both kind of samples presented similar antioxidant potential.

Ultrasound-assisted drying of orange peel in atmospheric freeze-dryer and convective dryer operated at moderate temperature

Effect of freeze-thaw and PEF pretreatments on the kinetics and microstructure of convective and ultrasound-assisted drying of orange peel

Antioxidant potential of atmospheric freeze-dried apples as affected by ultrasound application and sample surface

Effect of Ultrasonic Treatment on the Total Phenolic and Antioxidant Activity of Extracts from Citrus Peel

On the investigation into the kinetics of the ultrasound-assisted atmospheric freeze drying of eggplant

Energy and environmental analysis of ultrasound-assisted atmospheric freeze-drying of food

Effect of ultrasound-assisted osmotic dehydration pretreatment on the convective drying of strawberry

The effect of microwave vacuum drying process on citrus: drying kinetics, physicochemical composition and antioxidant activity of dried citrus (Citrus reticulata Blanco) peel

Impact of Ultrasound Pre-Treatment on the Drying Kinetics and Quality of Chicken Breast-A Comparative Study of Convective and Freeze-Drying Methods

On the effects of freeze-drying processes on the nutritional properties of foodstuff: A review

Stability parameters during refrigerated storage and changes on the microstructure of orange-carrot blend juice processed by high-power ultrasound

Microwave and Ultrasound Pre-Treatments for Drying of the “Rocha” Pear: Impact on Phytochemical Parameters, Color Changes and Drying Kinetics

Effects of contact ultrasound coupled with infrared radiation on drying kinetics, water migration and physical properties of beef during hot air drying

Hot air-assisted radio frequency drying of orange slices: Drying behavior and product quality

Drying kinetics, antioxidants, and physicochemical properties of litchi fruits by ultrasound-assisted hot air-drying

Influence of Ultrasound-Assisted Vacuum Drying on Physicochemical Characteristics, Antioxidant Activity, and α-Glucosidase Inhibition Activity of Flos Sophorae Immaturus

Comparison of different drying technologies for brocade orange (Citrus sinensis) peels: Changes in color, phytochemical profile, volatile, and biological availability and activity of bioactive compounds

Effects of drying temperature on the drying characteristics and volatile profiles of Citrus reticulata Blanco peels under two stages of maturity

Orange slice drying enhancement by intervention of control atmosphere coupled with vacuum condition—A new design and optimization strategy

Hawthorn Drying: An Exploration of Ultrasound Treatment and Microwave–Hot Air Drying

The Impact of Freeze-Drying Conditions on the Physico-Chemical Properties and Bioactive Compounds of a Freeze-Dried Orange Puree