Insights into stability of silica nanofluids in brine solution coupled with rock wettability alteration: An enhanced oil recovery study in oil-wet carbonates

Amin Keykhosravi,Mohammad Simjoo
DOI: https://doi.org/10.1016/j.colsurfa.2019.124008
2019-12-01
Abstract:<p>Stability of nanoparticle dispersion in brine solution is a key parameter for a successful nanofluid- based enhanced oil recovery processes. This paper aims to provide a systematic laboratory study to investigate the stability of silica nanoparticles (NPs) in presence of mono and divalent salts, namely NaCl and MgCl<sub>2</sub>, coupled with their potential to alter wettability of low-permeable, oil-wet carbonates at 80 °C. First, silica nanofluids with different salt concentrations were prepared using sonication process. Results showed that presence of divalent cations significantly hinders the stability of silica nanofluids as compared to monovalent ones. It was found that most of silica NPs was precipitated in presence MgCl<sub>2</sub> even at a low concentration of 2000 ppm while no particle precipitation was observed with 10000 ppm NaCl over a two- week period. This was in line with a smaller particle size of silica NPs with 10000 ppm NaCl (73 nm) as compared to MgCl<sub>2</sub>, 388 nm. Also, we found a noticeable reduction in zeta potential of silica nanofluids with MgCl<sub>2</sub>, −8 mV, as compared to NaCl, −25 mV. This reveals that the negative surface charge of silica NPs became more neutralized in presence of MgCl<sub>2</sub> and thus more chance for agglomeration of silica NPs through the aqueous phase. As to rock- nanofluid interaction, silica nanofluids in presence of NaCl exhibited a higher potential to alter rock wettability to more water-wetness than MgCl<sub>2</sub>. Such wettability alteration was discussed in terms of adsorption of silica NPs on the carbonate rock followed by a generation of thin layer of silica NPs on the rock surface, leading to an extra pressure on oil droplet. This was in line with SEM- EDX analyses indicting that silica NPs covers the carbonate rock surface. In terms of oil recovery, imbibition of silica nanofluid containing 10000 ppm NaCl provided 14% incremental oil while the lowest oil recovery was obtained for silica nanofluids containing MgCl<sub>2</sub> due to their less stability. These results showed that there could be a correlation between the stability of silica nanofluids and their EOR potential, which is strongly dependent on the salt type and concentration.</p>
What problem does this paper attempt to address?