Abstract:Background: Microalgae have attracted considerable interest due to their ability to produce a wide range of valuable compounds. Pulsed Electric Fields (PEF) has been demonstrated to effectively disrupt the microalgae cells and facilitate intracellular extraction. To increase the commercial viability of microalgae, the entire biomass should be exploited with different products extracted and valorized according to the biorefinery scheme. However, demonstrations of multiple component extraction in series are very limited in literature. This study aimed to develop an effective lipid extraction protocol from wet Scenedesmus almeriensis after PEF-treatment with 1.5 MJ·kgDW-1. A cascade process, i.e., the valorization of several products in row, was tested with firstly the collection of the released carbohydrates in the water fraction, then protein enzymatic hydrolysis and finally lipid extraction. Biomass processed with high pressure homogenization (HPH) on parallel, served as benchmark. Results: Lipid extraction with ethanol:hexane (1:0.41 vol/vol) offered the highest yields from the different protocols tested. PEF-treatment promoted extraction with almost 70% of total lipids extracted against 43% from untreated biomass. An incubation step after PEF-treatment, further improved the yields, up to 83% of total lipids. Increasing the solvent volume by factor 2 offered no improvement. In comparison, extraction with two other systems utilizing only ethanol at room temperature or elevated at 60 °C were ineffective with less than 30% of total lipids extracted. Regarding cascade extraction, carbohydrate release after PEF was detected albeit in low concentrations. PEF-treated samples displayed slightly better kinetics during the enzymatic protein hydrolysis compared to untreated or HPH-treated biomass. The yields from a subsequent lipid extraction were not affected after PEF but were significantly increased for untreated samples (66% of total lipids), while HPH displayed the lowest yields (~ 49% of total lipids). Conclusions: PEF-treatment successfully promoted lipid extraction from S. almeriensis but only in combination with a polar:neutral co-solvent (ethanol:hexane). After enzymatic protein hydrolysis in cascade processing; however, untreated biomass displayed equal lipid yields due to the disruptive effect of the proteolytic enzymes. Therefore, the positive impact of PEF in this scheme is limited on the improved reaction kinetics exhibited during the enzymatic hydrolysis step.

High Yields of Shrimp Oil Rich in Omega-3 and Carotenoids: Extending to Shrimp Waste the Circular Economy Approach to Fish Oil Extraction

High Yields of Shrimp Oil Rich in Omega-3 and Natural Astaxanthin from Shrimp Waste

High Pressure Extraction of Astaxanthin from Shrimp Waste (penaeus Vannamei Boone): Effect on Yield and Antioxidant Activity

Astaxanthin Extracts from Shrimp (litopenaeus Vannamei) Discards Assisted by High Pressure Processing

In Vitro Bioactivity of Astaxanthin and Peptides from Hydrolisates of Shrimp (Parapenaeus longirostris) By-Products: From the Extraction Process to Biological Effect Evaluation, as Pilot Actions for the Strategy “From Waste to Profit”

A step to shell biorefinery—Extraction of astaxanthin-rich oil, protein, chitin, and chitosan from shrimp processing waste

The LimoFish Circular Economy Process for the Marine Bioeconomy

The LimoFish Green Chemistry Process for the Marine Bioeconomy

Oil and pigments from shrimp processing by-products: Extraction, composition, bioactivities and its application- A review

Shrimp Waste Upcycling: Unveiling the Potential of Polysaccharides, Proteins, Carotenoids, and Fatty Acids with Emphasis on Extraction Techniques and Bioactive Properties

Omega-3-Rich Oils from Marine Side Streams and Their Potential Application in Food

Eco-friendly extraction, optimization, and characterization of carotenoprotein from shrimp waste biomass using a novel alkaline protease, Ecoenzyme (ECOENZYME–ALKP)

Extraction of lipids and astaxanthin from crustacean by-products: A review on supercritical CO2 extraction

Sustainable Enzymatic Production of Omega-3 Oil from Squid Viscera

Analysis of the lipid extraction performance in a cascade process for Scenedesmus almeriensis biorefinery

Physical and Oxidative Water-in-Oil Emulsion Stability by the Addition of Liposomes from Shrimp Waste Oil with Antioxidant and Anti-Inflammatory Properties

Upcycling Fish By-Products into Bioactive Fish Oil: The Suitability of Microwave-Assisted Extraction

Biochemical and physicochemical properties of shrimp (Pandalus borealis) compounds after compact filter press process

Recovery of Omega-3-Rich Lipids: Toward the Sustainable Valorization of Sea-Bass Industry Side Streams

Optimization of Extraction and Refining Parameters of Oil from Dotted Gizzard Shad (Konosirus punctatus)

Ultrasonic-Assisted Extraction of Astaxanthin from Shrimp By-Products Using Vegetable Oils