Abstract:The purpose of this research was to develop the technique of in situ freeze-drying in the sample chamber of an X-ray powder diffractometer (XRD) and to monitor the phase transitions during the freeze-drying of aqueous solutions of sodium nafcillin (I) and mannitol (II). Aqueous solutions of I and II were frozen under controlled conditions in the sample chamber of an XRD. This variable temperature XRD was modified so that the sample chamber could be evacuated and the samples dried under reduced pressures. Thus the entire freeze-drying cycle was carried out in the XRD holder and the solid-state was monitored during the various stages of the process. Frozen solutions of I when annealed at -4 degrees C, resulted in crystallization of the solute as 'sodium nafcillin hydrate' (unknown stoichiometry). Primary drying at -10 degrees C, resulted in partial dehydration to a poorly crystalline sodium nafcillin hemihydrate. There was no crystallization of mannitol when solutions of II were cooled and subjected to primary drying at -50 degrees C. During the drying, the intensities of the characteristic X-ray lines of ice (d-spacings of 3.94, 3.70 and 3.48 A) were quantified. This enabled real time monitoring of the complete sublimation of crystalline ice. When the secondary drying was carried out at -25 degrees C, mannitol crystallized as an anhydrous mixture of the delta- and beta-polymorphs. In a second set of experiments, the frozen solutions were warmed to -25 degrees C and subjected to primary drying. Mannitol crystallized and its XRD pattern matched that of mannitol hydrate reported recently (Yu et al., Pharm. Res., 14S (1997) S-445). When the secondary drying was carried out at -10 degrees C, there was no change in the XRD pattern suggesting the formation of a dehydrated hydrate. This in situ XRD technique enabled us to characterize the phase transitions during freeze-drying. It would be useful in developing a mechanistic understanding of the alterations in the solid-state during freeze-drying of complex, multi-component, pharmaceutical systems.

Structural origin of physicochemical properties differences upon dehydration and polymorphic transformation of ciprofloxacin hydrochloride revealed by structure determination from powder X-ray diffraction data

Phase conversion between anhydrous and hydrated ciprofloxacin

Investigation of Excipient and Processing on Solid Phase Transformation and Dissolution of Ciprofloxacin

Thermodynamic and kinetic mechanism of phase transformation of levofloxacin hydrochloride

Determination of Crystallization Metastable Zone Width of Ciprofloxacin Hydrochloride in Alcohol Aqueous Solution

Effects of Moisture-Induced Crystallization on the Aerosol Performance of Spray Dried Amorphous Ciprofloxacin Powder Formulations

Structural Characterization of Pharmaceutical Cocrystals with the Use of Laboratory X-ray Powder Diffraction Patterns

Reply to the 'Comment on "Polymorphism of levofloxacin: structure, properties and phase transformation"' by Tejender S. Thakur, <i>CrystEngComm</i>, 2020, <bold>22</bold>, DOI: 10.1039/C9CE01400D

Design, Preparation, Characterization and Evaluation of Five Cocrystal Hydrates of Fluconazole with Hydroxybenzoic Acids

Enhancing Stability and Formulation Capability of Fungicides by Cocrystallization Through a Novel Multistep Slurry Conversion Process

Unlocking the secrets of doxepin hydrochloride's crystal structure: Insights from high-quality powder diffraction analysis

X-Ray Diffraction and Theoretical Calculation-Supported Formation of Polymorphic Cocrystals Discovered Through Thermal Methods: A Case Study

CRYSTAL STRUCTURE PREDICTION IN THE CONTEXT OF PHARMACEUTICAL POLYMORPH SCREENING AND PUTATIVE POLYMORPHS OF CIPROFLOXACIN

Synthon polymorphs of 1 : 1 co-crystal of 5-fluorouracil and 4-hydroxybenzoic acid: their relative stability and solvent polarity dependence of grinding outcomes

Characterization of Phase Transitions During Freeze-Drying by In Situ X-ray Powder Diffractometry

Thermodynamic and Kinetic Mechanism of the Phase Transition from Aztreonam Dihydrate to Anhydrates

Polymorphism Observed in Dapsone–flavone Cocrystals That Present Pronounced Differences in Solubility and Stability

Comparative Study of the Cocrystals with Layered/cavity Structure in Regulating in Vitro Pharmaceutical Properties of Diuretic Acetazolamide

A Study on the Crystal Transformation Relationships of Valacyclovir Hydrochloride Polymorphs: Sesquihydrate, Form I, and Form II

Dehydration, Dissolution and Melting of Cyclodextrin Crystals

Solvent Effect on Molecular Conformational Evolution and Polymorphic Manipulation of Cimetidine