Abstract:The central diaphragm is often used to reduce the span to maintain the stability and safety of structure in the construction of large-span loess tunnel due to the structure complexities. In this paper, relying on the field monitoring and measurement for Wangcun tunnel in Huangling-Yan’an expressway expansion project, the crown settlement and horizontal convergence of primary support steel rib and central diaphragm steel rib during the construction are analyzed by the upper bench CD method. According to the internal force transfer, deformation coordination, and arch foot displacement between the two structures, the support system is regarded as the arch-beam fixed structure with three times of statically indeterminate and movable abutment under the loads, and the mechanical calculation model of sidewall steel rib and the central diaphragm structure bearing loads and deformation together is established. Finally, through the mechanical model mentioned above, the deformation characteristics of central diaphragm structure and the horizontal convergence in the upper bench of tunnel are calculated and analyzed. The research shows the following: (1) the accumulated settlement of sidewall steel rib in Part I is greater than that of the sidewall steel rib in Part II, and the accumulated settlement of each part at the support structure during the tunnel excavation is less than the reserved deformation of 150 mm specified in the tunnel excavation; (2) the settlement located at the waist and maximum excavation line position of central diaphragm is mainly affected by the excavation of Parts I and II in upper bench; (3) during the whole excavation process, the excavation of Part I and Part II has the greatest influence on the convergence at arch waist and the maximum excavation line position in Part I, and the convergence at the above two positions all experienced four stages of “convergence-expansion-convergence-gradual stability”; and (4) the errors between the horizontal convergence and the deformation of central diaphragm obtained by the mechanical model and the field monitoring data are between 12.7% and 27.5%. The calculated results are in good agreement with the actual situation. The research can provide a theoretical basis for the study of deformation and mechanical properties for support structure in the construction of large-span loess tunnel by the upper bench CD method.

Study on pressure arch effect of xigeda strata tunnel based on experiment and discrete element simulation

Experimental Study of Soil Arching Effect under Seepage Condition

Study of Deformation Behaviors and Mechanical Properties of Central Diaphragm in a Large-Span Loess Tunnel by the Upper Bench CD Method

Study on the Stress and Deformation of Surrounding Rock and Support Structure of Super Large Section Tunnels Based on Different Excavation Methods

Experimental and Numerical Investigation on the Effects of Foundation Pit Excavation on Adjacent Tunnels in Soft Soil

Decoupling Analysis of Interaction between Tunnel Surrounding Rock and Support in Xigeda Formation Strata

Analysis of Malignant Expansion of Plastic Zone of Surrounding Rocks in High Ground Temperature Hydraulic Tunnels and the Mechanical Characteristics of the Support Structure

The Stability Analyses of Tunnel Faces in Saturated Soils with Soil Arching Effect

Study on Stress Characteristics of Multi-arch Tunnel Lining under Weak Surrounding Rock Conditions Based on Field Measurement

Stress Analysis and Spalling Failure Simulation on Surrounding Rock of Deep Arch Tunnel

Calculation of earth pressure distribution on the deep circular tunnel considering stress-transfer mechanisms in different zones

Analysis of Arch Forming Factors of Shallow Buried Hard Rock Tunnel under Overlying Load

Study on the influence of roof load combination on deformation control of shallow buried tunnel section

Effect of tunnelling-induced ground loss on the distribution of earth pressure on a deep underground structure

Mechanical behaviors of surrounding rock and supporting structure of shallow-buried unsymmetrical pressure tunnel crossing soil–rock interface

Investigation of the Stress and Strain Distribution in the Surrounding Soil of a Tunnel Induced by the Double-Heading at Bottom Method

Study on Stability and Bearing Characteristics of Macroscopic Pressure Arch of Surrounding Rock in Western Deep Buried Stope of China

Soil movement mechanism associated with arching effect in a multi-strutted excavation in soft clay

A theoretical model for trapdoor tests considering the interaction of soil arches

Numerical study on the lateral soil arching effect and associated tunnel responses behind braced excavation in clayey ground

Numerical Simulation Analysis on the Supporting Effect of Different Pre-reinforcement Methods in Portal Section of the Shallow Buried Soft Rock Tunnel