Abstract:This research presents a simulated model of hydrogen generation through the application of the steam gasification process (SGP) for algae biomass coupled with the water-gas shift (WGS) reaction. A non-stoichiometric equilibrium-based model is constructed in Aspen Plus and validated against available experimental results in the literature. Four types of algae, namely Spirulina , Chlorella vulgaris , Spirogyra , and Rhizoclonium sp., are utilized as biomass feedstocks . The impact of operating conditions, such as gasifier temperature and the steam-to-biomass ratio (SBR), on the composition of the product gas is investigated. Exergy efficiency and cold gas efficiency (CGE) for each type of algae are calculated and examined within the SBR range of 0.2–1.2 and the gasifier temperature range of 650 °C–1050 °C. The results indicate that the maximum H 2 concentration is attained at the highest SBR while there exists an optimum value for the gasifier temperature. Exergy efficiency demonstrates an enhancement with an increase in gasification temperature and SBR. Among the algae types, Spirulina exhibits the highest exergy efficiency at a temperature of 1050 °C (61.3 %), whereas Spirogyra demonstrates the lowest exergy efficiency at the same temperature (35 %). Furthermore, at an SBR of 0.2, Rhizoclonium sp. demonstrates the highest exergy efficiency (41.8 %), and Spirogyra exhibits the lowest exergy efficiency (27.9 %). The findings also reveal that an increase in SBR leads to a decrease in CGE, whereas an increase in gasifier temperature improves the CGE. The influence of the WGS reaction on CGE and exergy efficiency is investigated. The results indicate that the WGS reaction contributes to an improvement in exergy efficiency, but it has a negative effect on CGE.

Supercritical water gasification of microalgae with and without oil extraction

Co-hydrotreating of Algae and Used Engine Oil for the Direct Production of Gasoline and Diesel Fuels or Blending Components

Supercritical Water Gasification of Microalgae over a Two-Component Catalyst Mixture

Supercritical water gasification of microalgal biomass for hydrogen production-A review

Catalytic Supercritical Water Gasification of Aqueous Phase Directly Derived from Microalgae Hydrothermal Liquefaction

Catalytic Hydrothermal Gasification Of Microalgae For Producing Hydrogen And Methane-Rich Gas

Supercritical Water Gasification of Waste Water Produced from Hydrothermal Liquefaction of Microalgae over Ru Catalyst for Production of H2 Rich Gas Fuel

Compositions, structures, and confined pyrolysis of the algal Chlorella and its nonhydrolyzable fractions

Supercritical water gasification (SCWG) as a potential tool for the valorization of phycoremediation-derived waste algal biomass for biofuel generation

Iso-conversional Kinetics of Low-Lipid Micro-Algae Gasification by Air

CO2 capture/biofixation and lipid extraction by membrane contactors for enhancing microalgal cultivation

Hydrogen-rich Energy Recovery from Microalgae (Lipid-Extracted) Via Steam Catalytic Gasification

A review of the catalytic gasification of different algae in supercritical water (SCW)

Gasification of Algal Residue for Synthesis Gas Production

Supercritical Water Upgrading of Water-Insoluble and Water-Soluble Biocrudes from Hydrothermal Liquefaction of Nannochloropsis Microalgae

Integration of Hydrothermal Liquefaction and Supercritical Water Gasification for Improvement of Energy Recovery from Algal Biomass

Simulation and exploration of cavitation process during microalgae oil extracting with ultrasonic-assisted for hydrogen production

Data on Characterization of Crude Bio-Oils, Gaseous Products, and Process Water Produced from Hydrothermal Liquefaction of Eight Different Algae.

Non-catalytic liquefaction of microalgae in sub-and supercritical acetone

Effects of dry and wet torrefaction pretreatment on microalgae pyrolysis analyzed by TG-FTIR and double-shot Py-GC/MS

Exergy analysis and cold gas efficiency evaluation for hydrogen generation through algae biomass steam gasification coupled with water-gas shift reaction