Abstract:Human enteric viruses are important etiological agents of waterborne diseases. Environmental waters are usually contaminated with low virus concentration requiring large concentration factors for effective detection by (RT)-qPCR. Low-pressure reverse osmosis is often used to remove water contaminants, but very few studies focused on the effective virus removal of reverse osmosis treatment with feed concentrations as close as possible to environmental concentrations and principally relied on theoretical virus removal. The very low viral concentrations usually reported in the permeates (i.e. at least 5 log of removal rate) mean that very large volumes of water need to be analysed to have sufficient sensitivity and assess the process efficiency. This study evaluates two methods for the concentration of adenoviruses, enteroviruses and MS2 bacteriophages at different viral concentrations in large (< 200 L) and very large (> 200 L) volumes. The first method is composed of two ultrafiltration membranes with low-molecular weight cut-offs while the second method primarily relies on adsorption and elution phases using electropositive-charged filters. The recovery rates were assessed for both methods. For the ultrafiltration-based protocol, recovery rates were similar for each virus studied: 80% on average at high virus concentrations (106-107 viruses L-1) and 50% at low virus concentrations (103-104 viruses L-1). For the electropositive-charged filter-based method, the average recoveries obtained were about 36% for ADV 41, 57% for CV-B5 and 1.6% for MS2. The ultrafiltration-based method was then used to evaluate the performance of a low-pressure reverse osmosis lab-scale pilot plant. The retentions by reverse osmosis were similar for all studied viruses and the validated recovery rates applied to the system confirmed the reliability of the concentration method. This method was effective in concentrating all three viruses over a wide range of viral concentrations. Moreover, the second concentration method using electropositive-charged filters was studied, allowing the filtration of larger volumes of permeate from a semi-industrial low-pressure reverse osmosis pilot plant. This reference method was used because of the inability of the UF method to filter volumes on the order of one cubic metre.

Virus harvesting in perfusion culture: Choosing the right type of hollow fiber membrane

Optimizing virus filtration for continuous processing using serial filtration at high area ratio

Affinity and Pseudo-Affinity Membrane Chromatography for Viral Vector and Vaccine Purifications: A Review

Evaluation of various membranes at different fluxes to enable large‐volume single‐use perfusion bioreactors

Effect of inner diameter, filter length, and pore size on hollow fiber filter fouling during perfusion cell culture

Virus Filtration Process Design and Implementation

Virus retention by a hydrophilic triple-layer PVDF microporous membrane filter.

Adapting virus filtration to continuous processing: Effects of product and process variability on filtration performance

High yield sterile filtration process for highly concentrated lentiviral vectors

Production of recombinant vesicular stomatitis virus-based vectors by tangential flow depth filtration

Purification of a recombinant oncolytic virus from clarified cell culture media by anion exchange monolith chromatography

Effect of volumetric concentration factor on virus removal for low-pressure reverse osmosis membrane in drinking water production: A study on different scales

Implementation of a Sensitive Method to Assess High Virus Retention Performance of Low-Pressure Reverse Osmosis Process

Cell culture–based production of defective interfering influenza A virus particles in perfusion mode using an alternating tangential flow filtration system

Improved sieving coefficient in perfusion cell culture with reduced effective filtration length of hollow fibers

Production of Lentiviral Vectors Using a HEK-293 Producer Cell Line and Advanced Perfusion Processing

Protein and virus-like particle adsorption on perfusion chromatography media

Contributions of Chinese hamster ovary cell derived extracellular vesicles and other cellular materials to hollow fiber filter fouling during perfusion manufacturing of monoclonal antibodies

A Bioreactor-Based Yellow Fever Virus-like Particle Production Process with Integrated Process Analytical Technology Based on Transient Transfection

Accelerated Development of AAV Purification Process Using a High-Throughput and Automated Crossflow System

Serial virus filtration: A case study evaluating the product-dependent impact of control strategies on process efficiency