Abstract:Development of non-platinum electrocatalysts for oxygen reduction reaction (ORR) is required for wide commercialization of polymer electrolyte fuel cells. We focused on titanium oxide-based electrocatalysts, because of their high chemical stability and much less expensive than platinum. We found that Ti-Nb complex oxide mixed with magneli phase titanium oxide (Ti 4 O 7 ) had high ORR onset potential and superior durability [1]. However, the ORR current was small because of their large particle size. In this study, we have tried to prepare titanium oxide-based nano particles using multi-walled carbon nano-tubes (CNTs) as support via hydrolysis method. We examined the effect of heat-treatment condition such as temperature and time on the ORR activity. We prepared Nb doped titanium oxide [mass ratio of TiO 2 :Nb 2 O 5 = 8:2] supported CNTs with total oxide mass ratio of 20wt%. These catalysts were heat treated at 600-900 o C for 0-60 min under 4%H 2 /Ar atmosphere. The catalyst without heat-treatment had poor ORR activity. The heat-treatment under reductive atmosphere enhanced the ORR activity of the catalysts. Figure 1 shows the dependence of the ORR current at 0.6 and 0.7 V of the catalysts prepared at several temperatures for 10 min under 4%H2/Ar in 0.1M H 2 SO 4 at 30 o C. The catalyst prepared at 800 o C showed highest ORR activity. The SEM observation indicated that the sizes of the oxide-based particles were around 20 nm for all catalysts with and without heat treatment. Therefore, the surface area of the oxide-base particles was almost the same. The dependence of the ORR activity was not responsible for the change of the surface area. The XRD patterns revealed that the catalyst without heat treatment was composed of anatase phase of TiO 2 , and the peaks due to the rutile TiO 2 apparently appeared at around 700-800 o C. In particular, the peaks due to Rutile TiO 2 shifted at lower angular, suggesting that the niobium doped into the TiO 2 phase. Thus, the Nb doping into rutile TiO 2 could affect the ORR activity. Figure 2 shows the Ti 2p XPS spectra of these catalysts. As shown in Fig.2, the peak at 457.8 eV corresponding to Ti 3+ (Ti 2 O 3 ) as well as the peak at 459.2 eV corresponding to Ti 4+ (TiO 2 ) were observed. The peak due to Ti 3+ increased from 600 to 800 o C, and decreased at 900 o C. This behavior was well corresponded to the ORR activity. Therefore, we concluded that Ti 3+ could act as active sites for the ORR. According to the XRD patterns, the Nb doping into rutile TiO 2 proceeded with increasing the temperature from 700 to 800 o C. The niobium doping generated the Ti 3+ via electro-neutral principle. The formation of the Ti 3+ in TiO 2 rutile phase was considered to be essential for emergence of the ORR. [1] A. Ishihara et al., J. Electrochem. Soc, 163(7), F603 (2016). Figure 1

The Oxygen Reduction Reaction on Nb-doped Titanium Dioxide Single Crystal Electrodes

Emergence of Oxygen Reduction Activity in Niobium-Doped Titanium Oxides As Non-Platinum Cathode for PEFCs

Remarkable Synergy Effect of Cu–Nb Oxide Nanorods Toward Electrocatalytic Nitrogen Reduction: the Enhanced Mass and Electron Transfer

Electrocatalysis on Shape-Controlled Titanium Nitride Nanocrystals for the Oxygen Reduction Reaction.

Investigation on the Electrical Properties of Anatase and Rutile Nb-Doped Tio2 by Gga(+U)

First Principles Calculations of the Electronic Structure and Optical Properties of Pure and (nb, N) Co-Doped Anatase

First-Principles Study of the Influences of Oxygen Defects Upon the Electronic Properties of Nb-Doped Tio2 by Gga + U Methods

The Critical Effect of Niobium Doping on the Formation of Mesostructured TiO2 : Single-Crystalline Ordered Mesoporous Nb-TiO2 and Plate-like Nb-TiO2 with Ordered Mesoscale Dimples

Electronic and Optical Properties of Anatase and Rutile Tio2:Nb

Insight into oxygen reduction activity and pathway on pure titanium using scanning electrochemical microscopy and theoretical calculations

The contrasting effect of the Ta/Nb ratio in (111)-layered B-site deficient hexagonal perovskite Ba5Nb4-xTaxO15 crystals on visible-light-induced photocatalytic water oxidation activity of their oxynitride derivatives.

Doped-nitrogen enhanced the performance of Nb2CTx on the electrocatalytic synthesis of H2O2

Effect of Melamine on the Oxygen Reduction Reaction in the n(111)-(111) Series of Pt3Co

Optimum in the thermoelectric efficiency of nanostructured Nb-doped TiO2 ceramics: from polarons to Nb-Nb dimers

Dispersion state and catalytic properties of niobia species on the surface of Nb2O5/TiO2 catalysts

Revealing the Role of D Orbitals of Transition-Metal-Doped Titanium Oxide on High Efficient Oxygen Reduction

Designing Highly Efficient Electrocatalyst for ORR and OER Based on Nb2CO2 MXene: The Role of Transition Metals and N-Doping Content

Enhanced Electron Transport in Nb-doped TiO2 Nanoparticles Via Pressure-Induced Phase Transitions.

Iron tuning electronic structure of nano-TiN embedded in carbon nanofibers as efficient single-atom catalyst for oxygen reduction reaction

Effect of Nb doping on structural, optical and photocatalytic properties of flame-made TiO2 nanopowder

Effects Of Nb Doping On Microstructure And Photocatalytic Properties Of Tio2 Thin Film