Abstract:Simultaneous recovery of biopolymers and enhanced bio-reactor performance are promising options for sustainable wastewater treatment, and the bioactivity of sludge after biopolymer extraction is thus critical for the performance of the system. To this end, stratified extracellular polymeric substances (EPS), including slime, loosely bound EPS (LB-EPS), and tightly bound EPS (TB-EPS), were extracted, and the bioactivities of the consequent extraction residues were assessed using aerobic respirogram, kinetic, and flow cytometry (FCM). After the initial weak extraction of slime, the particle size distribution of the sludge significantly decreased, and subsequent extractions of LB-EPS and TB-EPS produced an equivalent size distribution. In contrast, the fractal dimension decreased after each extraction, suggesting that LB-EPS and TB-EPS affected the compactness of flocs rather than the size. The aerobic bacteria distribution estimated using respirogram shows that slime mainly encapsulated heterotrophs while LB-EPS mainly encapsulated nitrifiers. In addition, the ammonia-nitrogen affinity coefficient decreased from 1.79 to 0.28 mg/L when slime was removed, thereby encouraging the activities of autotrophic nitrifiers. Further removal of LB-EPS induced high energy dispersion as the maintenance coefficient m and the metabolic dispersion index μ/m increased from 0.11 to 0.22 and 0.44 to 0.63, respectively. Meanwhile, the yield rate decreased from 0.77 to 0.66. Although pellets that resulted from TB-EPS extraction were not aerobically active as described by respirogram and growth curves, they were still metabolically active as measured by live/dead cell counting and redox sensor green signal. These pellets used more energy for maintenance as indicated by the high maintenance coefficient than those residual after either slime or LB-EPS extraction. In addition, the variation in bacteria community distribution across flocs was related to the variation in temperatures, suggesting that the inner part of a floc might be hotter than the outer side. Therefore, compared to bacteria in the raw sludge, the viable bacteria bounded in LB-EPS and TB-EPS convert more energy to heat rather than growth. These results indicate that energy was dispersed as metabolic heat for the LB-EPS extracted sludge, and removal of LB-EPS favored thermogenesis and sludge reduction. Based on the above findings, a simultaneously EPS-recovery and performance enhancement configuration is thus proposed, which holds great promise for the integration of next-generation wastewater treatment plants.

Degradation and utilization of EPS from excessive activated sludge by interaction of electrogenesis and light stimulation

A Novel Microbial Electrolysis Cell (MEC) Reactor for Biological Sulfate-Rich Wastewater Treatment Using Intermittent Supply of Electric Field

Maximizing electron flux, microbial diversity and gene abundance in MFC powered electro-Fenton system by optimizing co-addition of lysozyme and 2-bromoethanesulfonate

[Electricity Generation of Surplus Sludge Microbial Fuel Cell Enhanced by Biosurfactant].

Lysozyme regulates the extracellular polymer of activated sludge and promotes the formation of electroactive biofilm

Investigation of electrochemical properties, leachate purification, organic matter characteristics, and microbial diversity in a sludge treatment wetland- microbial fuel cell

Simultaneous enhancement of power generation and chlorophenol degradation in nonmodified microbial fuel cells using an electroactive biofilm carbon felt anode

Extracellular polymeric substances in electroactive biofilms play a crucial role in improving the efficiency of microbial fuel and electrolysis cells

Reason for the increased electroactivity of extracellular polymeric substances with electrical stimulation: Structural change of α-helix peptide of protein

Electric stimulation mitigated the mixed microplastic inhibition to anaerobic digestion during wastewater treatment

Revealing synergistic mechanisms of biochar-assisted microbial electrolysis cells in enhancing the anaerobic digestion performance of waste activated sludge: Extracellular polymeric substances characterization, enzyme activity assay, and multi-omics analysis

Improved Performance of Microbial Fuel Cells Enriched with Natural Microbial Inocula and Treated by Electrical Current

Extracellular Electron Transfer in Electroactive Anaerobic Granular Sludge Mediated by the Phenothiazine Derivative

An Integrated Aerobic-Anaerobic Strategy for Performance Enhancement of Pseudomonas Aeruginosa-Inoculated Microbial Fuel Cell.

Sludge dewaterability improvement with microbial fuel cell powered electro-Fenton system (MFCPEFs): Performance and mechanisms

Engineering Shewanella carassii, a newly isolated exoelectrogen from activated sludge, to enhance methyl orange degradation and bioelectricity harvest

Encapsulation of bacteria in different stratified extracellular polymeric substances and its implications for performance enhancement and resource recovery

Electroactive biofilm communities in microbial fuel cells for the synergistic treatment of wastewater and bioelectricity generation

Extracellular polymeric substances trigger an increase in redox mediators for enhanced sludge methanogenesis

Role of extracellular polymeric substances in methane production from waste activated sludge induced by conductive materials

Exogenous electric field as a biochemical driving factor for extracellular electron transfer: Increasing power output of microbial fuel cell