Abstract:Summary Production data are essential for designing and operating electrical submersible pump (ESP) systems. This study aims to develop artificial neural network (ANN) models to predict flow rates of ESP artificially lifted wells. The ANN models were developed using 31,652 data points randomly split into 80% (25,744 data points) for training and 20% (5,625 data points) for testing. Each data set included measurements for wellhead parameters, fluid properties, ESP downhole sensor measurements, and variable speed drive (VSD) sensors parameters. The models consisted of four separate neural networks to predict oil, water, gas, and liquid flow rates. Sensitivity analyses were performed to determine the optimum number of input parameters that can be used in the model. The best performance was achieved with ANN models of 16 input parameters that are readily available in ESP wells. The results of the best ANN configuration indicate that the mean absolute percent error (MAPE) between the predicted flow rates and the actual measurements for the testing data points of the oil, water, gas, and liquid networks is 3.7, 5.2, 6.4, and 4.1%, respectively. In addition, the correlation coefficients (R2) are 0.991, 0.992, 0.983, and 0.979 for the estimated oil, water, gas, and liquid flow rates for the testing data points, respectively. The performance of the ANN models was compared against performance of published physics-based models and the results were comparable. Unlike the physics-based methods, the ANN models have the advantage that they do not require periodic calibration. The ANN models were used to predict the flow rate curves of an oilwell in the Western Desert of Egypt. The results were compared to the actual separator test data. It was clear that the model results matched the actual test data. The ANN model is useful for predicting individual well production rates within wide variety of pumping conditions and completion configurations. This should allow for continuous monitoring, optimization, and performance analysis of ESP wells as well as quicker response to operational issues. In comparison to traditional separators and multiphase flowmeters (MPFMs), the use of the developed ANN models is simple, quick, and inexpensive.

Neural Network Model To Predict Slug Frequency of Low-Viscosity Two-Phase Flow

Application of artificial neural network to predict slug liquid holdup

Combined APSO-ANN and APSO-ANFIS models for prediction of pressure loss in air-water two-phase slug flow in a horizontal pipeline

Development of artificial neural networks for the prediction of the pressure field along a horizontal pipe conveying high-viscosity two-phase flow

Prediction of Pressure Evolution in Non-Venting Self-Pressurized Liquid Hydrogen Tanks Using Artificial Neural Network Approach

Study on Artificial Neural Network for Predicting Gas-Liquid Two-Phase Pressure Drop in Pipeline-Riser System

Artificial Neural Networks for Gas‐Liquid Flow Regime Classification in Small Channels

Artificial Neural Network Model to Predict Production Rate of Electrical Submersible Pump Wells

Designing artificial neural network of nanoparticle diameter and solid–fluid interfacial layer on single‐walled carbon nanotubes/ethylene glycol nanofluid flow on thin slendering needles

CFD and Neural Network-Based Predicting for Oil Delivery Performance of Oil Pump in Engines

Surrogate Model with a Deep Neural Network to Evaluate Gas–Liquid Flow in a Horizontal Pipe

Liquid droplet entrainment in an annular flow boiling regime—A Bayesian regularization algorithm based study

Deterministic prediction of vessel motion in real-time using Artificial Neural Network

Two-equation Turbulent Viscosity Model for Simulation of Transitional Flows: an Efficient Artificial Neural Network Strategy

Two-Phase Flow Pressure Drop Modelling in Horizontal Pipes with Different Diameters

Measurement of intelligent computing via Levenberg Marquardt algorithm (LMA) for accurate prediction of fluid forces in a transient non-Newtonian thermal flow

Dynamic viscosity prediction of nanofluids using artificial neural network (ANN) and genetic algorithm (GA)

Prediction of particle-laden pipe flows using deep neural network models

Heat transfer and pressure drop of Al 2 O 3 /water nanofluid in conically coiled tubes: Experimental and artificial neural network prediction

Applicability of connectionist methods to predict dynamic viscosity of silver/water nanofluid by using ANN-MLP, MARS and MPR algorithms

Performance and application analysis of ANFIS artificial intelligence for pressure prediction of nanofluid convective flow in a heated pipe