Phosphorus recovery by struvite from anaerobic co-digestion effluents during residual biomass treatment

Carolina Ochoa,Mario A. Hernández,Olga L. Bayona,Hernando A. Camargo,Iván O. Cabeza,Angélica M. Candela
DOI: https://doi.org/10.1007/s13399-020-01146-6
IF: 4.05
2020-11-21
Biomass Conversion and Biorefinery
Abstract:The residual biomass from agricultural activities has macronutrients and micronutrients, which could be recovered after an anaerobic co-digestion process. In this study, the effluents of the anaerobic co-digestion, which use coffee, cocoa mucilage, and pig manure, were evaluated to produce struvite. The effects of the Ca2+/PO43− ratio on the purity of struvite precipitation from synthetic and anaerobic co-digestion effluents was evaluated. The influence of pH, Ca2+/PO43− ration, and stirring speed on the efficiency of PO43− recovery and the removal of Ca2+ was studied. The phosphorus recovery increased from 85 to 99% with pH change from 8.5 to 10. The lowest removal of Ca2+ was 6.6% in the anaerobic effluent with the a ratio Ca2+/PO43− of 0.3:1 at pH 10. Struvite precipitate with high purity was obtained when the molar ratio was less than 0.3:1, and the pH was fixed to 10. X-ray diffraction analysis and scanning electron microscopy (SEM) confirmed the orthorhombic phases and morphology typical of struvite, respectively. In addition, the presence of K as a macronutrient and Ca and Na as micronutrients increases the viability of the struvite as fertilizer. The high recovery of phosphorus as struvite indicates it could be an alternative for nutrient recovery and utilization of these effluents.
energy & fuels,engineering, chemical
What problem does this paper attempt to address?
The main problem that this paper attempts to solve is to prepare high - purity struvite through phosphorus recovery in anaerobic co - digestion liquor (using coffee pectin, cocoa pectin and pig manure as raw materials). Specifically, the research focuses on the following aspects: 1. **Phosphorus recovery efficiency**: Evaluate the phosphorus recovery rate under different conditions, especially the influence of the Ca²⁺/PO₄³⁻ ratio, pH value and stirring speed on the phosphorus recovery efficiency. 2. **Calcium removal effect**: Study the influence of these conditions on the calcium removal effect to reduce the interference of calcium on struvite crystallization. 3. **Struvite purity**: Analyze by X - ray diffraction (XRD) and scanning electron microscope (SEM) to confirm the crystal structure and morphology of struvite and ensure its high purity. ### Key problems and solutions - **The relationship between phosphorus recovery and calcium removal**: - The research found that when the Ca²⁺/PO₄³⁻ ratio is 0.3:1 and the pH is 10, the phosphorus recovery rate can be as high as 99%, while the calcium removal rate is at least 6.6%. This indicates that a low Ca²⁺/PO₄³⁻ ratio helps to improve the phosphorus recovery rate and reduce calcium interference. - **Optimal pH value**: - When the pH value increases from 8.5 to 10, the phosphorus recovery rate increases significantly, from 85% to 99%. This is because at a higher pH value, phosphate ions (PO₄³⁻) are more likely to combine with other ions to form struvite. - **Influence of stirring speed**: - The stirring speed has no significant influence on the phosphorus recovery rate and the calcium removal rate, so it is fixed at 450 rpm in the experiment. - **Characterization of struvite**: - XRD analysis confirms the orthorhombic phase of struvite, and SEM images show the typical struvite morphology. In addition, K is detected as a major element and Ca and Na as trace elements, which increases the feasibility of struvite as a fertilizer. ### Conclusion This research successfully and efficiently recovers phosphorus from anaerobic co - digestion liquor and prepares high - purity struvite by optimizing the Ca²⁺/PO₄³⁻ ratio, pH value and other parameters. This achievement not only helps to solve the problem of sustainable use of phosphorus resources, but also provides a new way for the resource utilization of agricultural wastes.