Abstract:Synthetic colorants used for dye and mordant purposes in textile industries are currently causing environmental problems in the world. The usage of these synthetic colorants is a major health problem and harms the environment. For this reason, synthetic colorants should be replaced by natural colorants. Therefore, this study aimed to extract natural dye stuff from spent coffee ground and bio-mordant from mango bark. The raw materials were collected, washed, dried, crushed and their physico-chemical properties were determined. Finally, the samples were extracted by using the solvent extraction method. During the extraction process, the central composite design method (CCD) was used to analyze and optimize the effect of dosage (g/l), temperature (°C) and time (min). The maximum natural dye yield value of 18.41% was obtained at a dosage of 60 g/l, temperature of 70°C and time of 90 min. Also, the highest natural mordant yield of 19.03% was achieved at the value of 45 g/l, 70°C and 90 min. The fastness properties of dyed and mordanted cotton fabric results were within a range of acceptable standard values. Therefore, using spent coffee grounds for natural dyes and mango bark for natural mordant can be a feasible commercial alternative to synthetic dyes in textile and dyeing industries. 纺织工业中用于染料和媒染剂目的的合成着色剂目前正在世界范围内引起环境问题. 这些合成着色剂的使用是一个主要的健康问题,并危害环境. 因此,合成着色剂的最佳解决方案之一应该被天然着色剂所取代. 因此,本研究旨在从废咖啡渣中提取天然染料,并从芒果皮中提取生物媒染剂. 对原料进行收集、洗涤、干燥、粉碎,并测定其物理化学性质(水分含量、灰分含量和溶解度). 最后,采用溶剂萃取法对样品进行了萃取. 在提取过程中,使用设计专家13.1.0.1软件包中的中心复合物设计方法(CCD)分析并优化了用量(g/l)、温度(°C)和时间(min)对提取产率的影响. 在用量为60 g/l、温度为70°C、时间为90 min的条件下,天然染料的最大得率为18.41%. 在45 g/l、70°C、90 min的条件下,天然媒染剂的收率最高,达19.03%. 染色和媒染后的棉织物的牢度在可接受的标准值范围内. 因此,在纺织和染色行业中,使用废咖啡渣作为天然染料,使用芒果皮作为天然媒染剂,可以成为合成染料的可行商业替代品.

Assessment of Coffee Pulp as a Potential Source of Tannins for Leather Processing

Extraction of a novel tanning agent from indigenous plant bark and its application in leather processing

Potential Application of Used Coffee Grounds in Leather Tanning

Extraction and Characterization of Natural Dye Stuff from Spent Coffee Ground and Bio-Mordant from Mango Bark

Extract of Trema Orientalis (L.) Stem Bark: A Potential Source of Environmentally Friendly Tanning Agent for Leather Industry

Valorization of faba bean peels for fungal tannase production and its application in coffee tannin removal

The Impact of Cashew Nut (Anacardium occidentale) Testa Tannin Feeding Ratio on the Chemical and Mechanical Characteristics of Leather Tanned from Cowhide, Goatskin and Sheepskin

Utilization of coffee pulp waste for rapid recovery of pectin and polyphenols for sustainable material recycle

Sensitising natural wool with green and brown coffee using a facile extraction method to optimise dye process parameters

Evaluation of Mechanical Properties of Goat Leather Tanned using Acacia xanthophloea

Extraction and Chromatographic Analysis of Ethiopian Oak Bark Plant for Leather Tanning Applications

Extraction and Characterization of Lignin from Instant Coffee and its Anti-UV Application in Stabilized Pickering Emulsion

Unveiling the Nutritional Profile and Safety of Coffee Pulp as a First Step in Its Valorization Strategy

Valorization of Coffee Silverskin through Subcritical Water Extraction: An Optimization Based on T-CQA Using Response Surface Methodology

Application and valorization of novel indigenous Azadirachta indica leaf in leather processing

Method optimization for the extraction of chlorogenic acids from coffee parchment: An ecofriendly alternative

Biomass-based Tanning Agent for Sustainable Leather Manufacture via Cyanuric Chloride Modified Chitooligosaccharide

Antioxidant, antimicrobial and healing properties of an extract from coffee pulp for the development of a phytocosmetic

Bioactive Compounds in Different Coffee Beverages for Quality and Sustainability Assessment

Valorization of Pomegranate Peel Waste as Retanning Agent in Leather Industry and Investigation of Its Effect on Prevention of Cr(VI) Formation

Evaluation of the Physical Properties of Goatskins Tanned using Banana (Musa spp.) Leaf Midrib Tannins