Abstract:Abstract Previous study found that the solvent extraction efficiency of lipid in microalgae could be greatly improved by washing algae cells before the second time extraction. Based on the "organic solvents–water–organic solvents" method, this research further studied the effect of four solvent systems (acetone, chloroform/methanol, chloroform/methanol/water, dichloromethane/methanol), two types of water treatment (vortex and ultrasonic), three water treatment time gradient (0 s, 30 s, 120 s) on the lipid extraction at three different microalgae growth stages (3rd day, 5th day, 9th day). The results show that the combination of water treatment type, treatment time and solvent is very important to the efficiency of lipid extraction. The total lipid extracted was generally increased by 10–30% after water treatment. Especially under the condition of 120 s vortex water treatment with dichloromethane/methanol as extraction solvent, the total lipid extracted increased by 61.14%. In addition, microalgae cells at different culture stages had different sensitivity to water treatment. In this study, under the combination of chloroform/methanol/water as extraction solvent and vortex water treatment for 120 s, the highest lipid yield was obtained on the ninth day of cell culture, which accounts 47.88% of the cell dry weight (478 mg/g cell dry weight). The changes of cell morphology and structure after water treatment were studied by scanning electron microscope, and it was found that water treatment could seriously destroy the cell membrane damaged by solvent, thus promoting the release of lipids. This study further optimizes the "solvent–water–solvent" lipid extraction method, which neither produces impurities nor damages the lipid quality, and can reduce the amount of organic solvent applied in the classical lipid extraction method with the same lipid yield, so it has a broad application prospect.

Simultaneous harvesting and cell disruption of microalgae using ozone bubbles: optimization and characterization study for biodiesel production

Combination of cell disruption method and pH variation as pre-treatment for lipid extraction of Nannochloropsis sp.

Microalgae biomass pre-treatment with deep eutectic solvent to optimize lipid isolation in biodiesel production

Combined Enzymatic and Mechanical Cell Disruption and Lipid Extraction of Green Alga Neochloris oleoabundans

Efficiency and mechanism of ozonated microbubbles for enhancing the removal of algae and algae-derived organic matter

Orthogonal Optimization Of A Newly Isolated Microalga Desmodesmus Sp.-Chx1 As A Potential Candidate For Biodiesel Production

Using wet microalgae for direct biodiesel production via microwave irradiation

STUDY ON PREPARATION OF BIODIESEL FROM MICROALGAL OIL

Optimized Bubbling Strategy for Improving Microalgae Growth of Chlorella Vulgaris and Subsequent Valorization to Lipids

Study on the Harvest of Oleaginous Microalgae Chlorella Sp. by Photosynthetic Hydrogen Mediated Auto-Flotation for Biodiesel Production

Maximizing Lipid Extraction from Chlorella pyrenoidosa: A Study on the Effectiveness of Cell Disruption Techniques

Cell disruption methods for improving lipid extraction efficiency in unicellular microalgae

Production of a sustainable fuel from microalgae Chlorella minutissima grown in a 1500 L open raceway ponds

A Comparative Analysis Assessing Growth Dynamics of Locally Isolated Chlorella sorokiniana and Chlorella vulgaris for Biomass and Lipid Production with Biodiesel Potential

OPTIMISATION OF BIOMASS, LIPID AND CARBOHYDRATE PRODUCTIVITIES IN Chlorella vulgaris FOR BIOFUEL PRODUCTION

Optimization of Chlorella biomass harvesting by flocculation and its potential for biofuel production

Optimization of a novel lipid extraction process from microalgae

Improvising Biodiesel Production from Scenedesmus dimorphus via Nutrient Starvation and Optimized Pretreatment Process

Efficient coupling of sulfadiazine removal with microalgae lipid production in a membrane photobioreactor

Dilute acid-assisted microbubbles-mediated ozonolysis of Eucheuma denticulatum phycocolloid for biobased L-lactic acid production

Screening of microalgae species and evaluation of algal-lipid stimulation strategies for biodiesel production