Abstract:The emission of hydrophobic Volatile Organic Compounds (VOCs) is a serious environmental issue. Typically, biofilters (BFs) are employed for their treatment, with the potential enhancement of mass transfer through the addition of surfactants. However, disparate results in previous studies have been observed, attributed to uncontrolled conditions during the introduction of surfactants to BFs. Additionally, there has been limited exploration of microbial consortium adaptation to surfactants. To address these gaps, this study followed two approaches. First, the long-term (247 days) removal of cyclohexane was studied in a stirred tank bioreactor (STBR) inoculated with Rhodococcus erythropolys E1 and using Tween 80 at three times the critical micelle concentration (CMC). Second, the short-term (9 days) impact of two (bio)surfactants [Tween 80 (1 × CMC) and Quillaja Saponin (QS, 1 × CMC)] on the removal of cyclohexane, hexane and toluene was investigated in batch tests using three types of inocula: a pure culture of Rhodococcus erythropolys E1 (X 0 ), a microbial consortium adapted to cyclohexane (X 1 ), and a microbial consortium adapted to cyclohexane with Tween 80 (X 2 ). For long-term operation, the addition of Tween 80 at 3 × CMC improved cyclohexane removal efficiency (RE) to 87 ± 1% (elimination capacity, EC = 145 ± 25 mg m −3 h −1 , gas residence time, GRT = 20 min, inlet concentration, C in = 14.9 ± 2.5 ppm v ), compared to a RE of 32 ± 9% (EC = 44 ± 8 mg m −3 h −1 , GRT = 20 min, C in = 15.1 ± 0.7 ppm v ) under similar conditions without surfactants. For short-term operation, the addition of QS at 1 × CMC significantly increased biomass growth, resulting in lower maximum specific consumption rates for X 1 and X 2 compared to scenarios without surfactants or 1 × CMC Tween 80. The most abundant genera in X 1 and X 2 were Paludisphaera (26-23%), 67-14 genus (17–23%), and Rhodococcus (9–18%), respectively.

Pseudomonas taiwanensis biofilms for continuous conversion of cyclohexanone in drip flow and rotating bed reactors

Deactivation Kinetic Study on Vapor Phase Beckmann Rearrangement of Cyclohexanone Oxime and Design of the Multi-Layer Inclined Channel Bionic Reactor

Effects of Process Conditions on Products Distribution of Cyclohexane Non-Catalytic Oxidation in Microcapillary

Toward Upscaled Biocatalytic Preparation of Lactone Building Blocks for Polymer Applications

Continuous testing system for Baeyer-Villiger biooxidation using recombinant Escherichia coli expressing cyclohexanone monooxygenase encapsulated in polyelectrolyte complex capsules

Maximizing Photosynthesis-Driven Baeyer–Villiger Oxidation Efficiency in Recombinant Synechocystis sp. PCC6803

An automated microscale platform for evaluation and optimization of oxidative bioconversion processes

Expanding the Substrate Scope of Phenylacetone Monooxygenase from Thermobifida Fusca Towards Cyclohexanone by Protein Engineering

Intensification of a Biocatalytic Oxidation under Fine Bubble Aeration in a Rotating Bed Reactor

Debottlenecking 4-hydroxybenzoate hydroxylation in Pseudomonas putida KT2440 improves muconate productivity from p-coumarate

Coated-wall microreactor for continuous biocatalytic transformations using immobilized enzymes

A multistep (semi)-continuous biocatalytic setup for the production of polycaprolactone

Enhancing the biodegradation of hydrophobic volatile organic compounds: A study on microbial consortia adaptation and the role of surfactants

Stability and Oscillatory Behavior of Microbial Consortium in Continuous Conversion of Crude Glycerol to 1,3-Propanediol.

First industrial-scale biomimetic oxidation of hydrocarbon with air over metalloporphyrins as cytochrome P-450 monooxygenase model and its mechanistic studies

Designing a Stable Continuous Fluid Catalytic Xylem-Based Reactor with a High Mass Transfer Efficiency Via in Situ Grown ZIF-8-immobilized Β-Glucosidase on Natural Directional Channel

Discovery and Engineering of a Novel Baeyer‐Villiger Monooxygenase with High Normal Regioselectivity

Continuous multistep synthesis of perillic acid from limonene by catalytic biofilms under segmented flow

Engineering Pseudomonas Putida for Lignin Bioconversion into Cis-Cis Muconic Acid

One-pot Baeyer–Villiger Oxidation of Cyclohexanone with in Situ Generated Hydrogen Peroxide over Sn-Beta Zeolites

Coupling the Phenolic Oxidation Capacities of a Bacterial Consortium and in Situ-Generated Manganese Oxides in a Moving Bed Biofilm Reactor (MBBR)